Mooney M20D Master Checklist

Full document text

Preflight Preflight Inside Cockpit Maint. Status Sheet Check Squawk Sheets Check VOR Checks (IFR Only) Within 30 days Required Docs. (AROW) On Board Weight and CG Within Limits Avionics & Electrical Switches Off Magneto Switch Off Master Switch On Fuel Gauges Check Quantity Green Gear Down Indicator Check On Anti-Collision Light Check Master Switch Off Flaps Extend Fuel Tube & Strainer Remove Preflight Exterior Right Flap & Aileron Check Wing Tip Check Fuel Quantity Visually Check Fuel Vent Check Clear Fuel Drain Drain & Check Tie-Down & Chocks Remove Gear Truss & Door Check Condition Main Tire Check Condition Brakes Check Wear Preflight continued Preflight Exterior Windshield Assure Clean Oil Quantity Min 6/Max 8 Propeller & Spinner Check Alternator Belt Check Air Inlets Check Open Nose Wheel Chock Remove Nose Gear Truss & Doors Check Condition Nose Tire Check Condition Fuel Selector Drain & Check Fuel Vent Check Open Fuel Drain Drain & Check Tie-Down & Chocks Remove Main Gear Truss & Door Check Condition Main Tire Check Condition Brakes Check Stall Warning Switch Check Pitot Head Check 2 Openings Wing Tip Check Left Aileron and Flap Check Left Side Fuselage Check Left Side Static Port Check Antennas Check Horizontal Stabilizer & Elevator Check Vertical Stabilizer & Rudder Check Tail Tie-Down Remove Right Side Fuselage Check Right Side Static Port Check Open Baggage Door Secure For all Night Flights Check Navigation Light Landing Lights Cockpit Lights Flashlight on Board Engine Start Engine Start Maintenance Status Sheets Check Squawk Sheets Check Hobbs Sheet Record Information Seats Adjust & Lock Seats Belts Fasten Circuit Breakers Check In Fuel Selector Fullest Tank Master Switch On Gear Lever Up/Locked Gear Down Light On Anti-Collision Light Always Remains On Carburetor Heat Off Mixture Full Rich Propeller Max RPM Fuel Pump On & Check Pressure Throttle Pump & Set ¼” Open Brakes Hold Propeller Area Call Clear Starter Engage Throttle 1000 RPM Oil Pressure Check Cowl Flaps Open Avionics Switch On Radios On Transponder Standby Before Takeoff Before Takeoff Checklist Fuel Selector On Fullest Tank Brakes Set & Hold Throttle 1,700 RPM Magnetos Check Left & Right Max Drop 125 RPM Max Diff. 50 RPM Carburetor Heat Max Drop 200 RPM Throttle 2,200 RPM Propeller Cycle Engine Gauges Check Fuel Quantity & Press Check Suction Check 5.0” +/- 0.1” Hg Speed Brakes On/Check/Off Throttle 1,000 RPM Flight Instruments Adjust Avionics Set Flight Controls Check Electric Fuel Pump On Mixture Set Flaps Set to 15˚ Trim Set for Take-Off Doors & Windows Latched Seat Backs Erect Safety Belts/Harness Fastened Empty Seats Seat Belt Fastened Transponder Altitude Pre Landing/After Landing/Engine Shutdown Pre-Landing Checklist Fuel Selector On Fullest Tank Electric Fuel Pump On Landing Gear Extend Below 120 MPH Gear Down Light Check Illuminated Flaps As Needed Below 100 MPH Mixture Rich Propeller Max RPM Cowl Flaps Closed Carburetor Heat As Required After-Landing Checklist Flaps Retract Electric Fuel Pump Off Transponder Standby Cowl Flaps Open Engine Shutdown Checklist Avionics Switch Off Electrical Equipment (Except Strobe & Master) Off Throttle 1000 RPM Mixture Idle Cutoff Master (Strobe stays on) Off Magneto Switch Off Hobbs Sheet Record Information Pilot Call Window Latched Front Seats Slide Full Aft Emergency Checklist Emergency Checklist ENGINE FAILURE Airspeed Trim for 105 MPH Landing Site Choose Fuel Selector Switch Tanks Electric Fuel Pump On Mixture Rich Carburetor Heat On Engine Gages Check for cause Magnetos (Check) Left/Right/Both Throttle/Mixture Different settings Emergency Checklist POWER OFF LANDING Transponder Squawk 7700 Transmit Distress Signal 121.5 MHz Gear Extend if appropriate Flaps Extend when landing assured Mixture Idle Cutoff Master Switch Off Fuel Selector Off Magnetos Off Seat Belts Tight Door Open