Piper Arrow PA28-R200 N56130 CHECKLIST

AVIONICS ............................................................................................... OFF ENGINE START MASTER SWITCH .................................................................................... ON GEAR LIGHTS ................................................................................ 3 GREEN PROP ............................................................................................ FORWARD FUEL SELECTOR VALVE ..................................................... DESIRED TANK THROTTLE ............................................................................ OPEN ½ INCH MASTER .................................................................................................. . ON BEACON ................................................................................................... . ON NAV LIGHTS (NIGHT) .............................................................................. ON ELECTRIC FUEL PUMP............................................................................ ON Starting engine when hot: MIXTURE ................................................................................ IDLE CUT-OFF MAGNETOS ........................................................................................ START WHEN ENGINE FIRES………………ADVANCE MIXTURE AND THROTTLE AS DESIRED Starting engine when cold: MIXTURE ............................... FULL RICH UNTIL FUEL FLOW INDICATION MIXTURE ................................................................................ IDLE CUT-OFF MAGNETOS ........................................................................................ START WHEN ENGINE FIRES............... ADVANCE MIXTURE AND THROTTLE AS DESIRED If engine doesn't fire in 5-10 seconds, disengage starter and reprime. OIL PRESSURE ................................................................................. CHECK OIL TEMPERATURE .......................................................................... CHECK ELECTRIC FUEL PUMP ......................................................................... OFF FUEL PRESSURE ............................................................................. CHECK Piper Arrow II PA28-R200 NORMAL CHECKLIST 5 AVIONICS .................................................................................................. ON LIGHTS ................................................................................... AS REQUIRED MIXTURE ............................................................................... GROUND LEAN GPS............................................................................................ CONFIGURE ATIS .................................................................................................. OBTAIN FLIGHT INSTRUMENTS ............................................................ CHECK/SET ALTIMETER .............................................................................................. SET CLEARANCE ..................................................................................... OBTAIN TRANSPONDER .............................................................................. SET/ALT TAXI CLEARANCE ................................................................ OBTAIN/BRIEF WARM-UP AND GROUND CHECK PARKING BRAKE .................................................................................... SET FLIGHT CONTROLS ................................................. FREE AND CORRECT PROP ............................................................................................. FORWARD MIXTURE ................................................................................................ RICH POWER ......................................................................................... 2000 RPM OIL PRESSURE ................................................................................ CHECK OIL TEMPERATURE ........................................................................... CHECK ALTERNATE AIR ............................................................................... CHECK MAGNETOS (175/50 RPM) ...................................................... CHECK/BOTH VACUUM GAUGE ...................................................................... 5” Hg +/- .1” PROP CONTROL ................................................................ CYCLE 3 TIMES AMMETER .......................................................................................... CHECK POWER ..................................................................... IDLE THEN 1000 RPM BEFORE TAXI LIGHTS ................................................................................... AS REQUIRED MIXTURE ............................................................................... GROUND LEAN GPS............................................................................................ CONFIGURE FLIGHT INSTRUMENTS ............................................................ CHECK/SET TRANSPONDER .............................................................................. SET/ALT TAXI CLEARANCE ................................................................ OBTAIN/BRIEF Piper Arrow II PA28-R200 NORMAL CHECKLIST 6 TAXI PARKING BRAKE ..................................................................... RELEASED ATTITUDE INDICATOR............................... LESS THAN 5 DEGREES BANK HEADING INDICATOR ............................................... DIRECTION OF TURN TURN COORDINATOR .................................BANK TOWARDS/BALL AWAY BEFORE TAKEOFF TAKEOFF BRIEFING ...................................................................COMPLETE FLIGHT CONTROLS .................................................. FREE AND CORRECT FUEL SELECTOR .................................................................PROPER TANK ELECTRIC FUEL PUMP............................................................................. ON ENGINE GAUGES .............................................................................. CHECK FLIGHT INSTRUMENTS .............................................. CHECKED AND SET ALTERNATE AIR ............................................................................. CLOSED PROP ...................................................................................................... SET MIXTURE ................................................................................................ SET SEAT BACKS ................................................................................. UPRIGHT SEAT BELTS/HARNESSES ......................................................... FASTENED FLAPS ...................................................................................................... SET TRIM TAB ................................................................................................ SET EMERGENCY GEAR EXTENSION LEVER .............................................. UP DOOR ..................................................................... CLOSED AND LATCHED Piper Arrow II PA28-R200 NORMAL CHECKLIST 7 CLIMB GEAR .......................................................................................................... UP FLAPS ......................................................................................................... UP After 1000’: PROP .............................................................................................. 2500 RPM THROTTLE ........................................................................................... 25” MP FUEL PUMP ............................................................................................ OFF FUEL PRESSURE .............................................................................. CHECK AIRSPEED ................................................................................ 105-110 MPH MIXTURE ...................................................................... LEAN AS REQUIRED CRUISE CRUISE POWER ...................................................................................... SET MIXTURE ................................................................................................ LEAN Piper Arrow II PA28-R200 NORMAL CHECKLIST 8 DESCENT SEAT BACKS ................................................................................ UPRIGHT SEAT BELTS/HARNESS .............................................................. FASTENED FUEL SLECTOR .....................................................................PROPER TANK FUEL PUMP .............................................................................................. ON MIXTURE ................................................................................................ SET PROPELLER ........................................................................................... SET EMERGENCY GEAR EXTENSION LEVER ............................................... UP GEAR ........................................................................ DOWN (150 MPH MAX) FLAPS ........................................................................... SET (125 MPH MAX) BEFORE LANDING (GUMP) GAS........................................................... FULLEST TANK/FUEL PUMP ON UNDERCARRIAGE ......................................................................... 3 GREEN MIXTURE ................................................................................................ RICH PROPELLER ............................................................................... FORWARD SEATBELTS ................................................................................... SECURED SWITCHES ....................................................................... AS APPROPRIATE “GUMPS” check on base, “100’-3 green on final.” AFTER LANDING FLAPS ............................................................................................. RETRACT ELECTRIC FUEL PUMP........................................................................... OFF TAXI ROUTE .......................................................................... OBTAIN/BRIEF Piper Arrow II PA28-R200 NORMAL CHECKLIST 9 SHUTDOWN TRANSPONDER ............................................................................ 1200/VFR AVIONICS ................................................................................................ OFF PROP ............................................................................................ FORWARD THROTTLE ..................................................................................... 1500 RPM MAGNETOS ................................................................ VERIFY GROUNDING THROTTLE ..................................................................................... 1000 RPM MIXTURE .................................................................................IDLE CUT-OFF THROTTLE ................................................................................................ AFT MAGNETOS ............................................................................................. OFF LIGHTS ..................................................................... OFF/EXCEPT BEACON MASTER SWITCH .................................................................................... OFF RAMP IN HOBBS TIME ......................................................................................... NOTE TACH TIME ............................................................................................ NOTE SQUAWKS ...................................................................................... COMPILE FLIGHT SCHEDULE PRO .............................................................. CHECK IN SECURE CONTROL WHEEL LOCK ................................................................ INSTALL CABIN AIR VENTS .............................................................................. CLOSE TIE DOWNS ................................................................................... SECURED MAIN WHEELS .................................................................................. CHOCK PITOT COVER ................................................................................... INSTALL WINDSCREEN .................................................................................... CLEAN WINDOW SHADE .............................................................................. INSTALL WINDOWS/CABIN DOORS...................................................... CLOSE/LOCK Piper Arrow II PA28-R200 NORMAL CHECKLIST 10 OPERATING NOTES: PATTERN WORK DOWNWIND PROP .............................................................................................. 2400 RPM THROTTLE ........................................................................................... 18” MP FUEL PUMP .............................................................................................. ON ABEAM TOUCHDOWN POINT GEAR ................................................................................. DOWN (3 GREEN) THROTTLE ......................................................................................... 13” MP FLAPS ........................................................................................ 10 DEGREES AIRSPEED ....................................................................................... 105 MPH BASE FLAPS ...................................................................................... 25 DEGREES AIRSPEED ........................................................................................ 90 MPH FINAL FLAPS ....................................................................................... 40 DEGREES AIRSPEED ......................................................................................... 85 MPH OPERATING NOTES: GO-AROUND MIXTURE ...................................................................................... FORWARD PROP ........................................................................................... FORWARD THROTTLE ................................................................................... FORWARD FLAPS ....................................................................................... 25 DEGREES AIRSPEED ........................................................................................ 100 MPH When positive rate of climb: GEAR ........................................................................................................ . UP FLAPS ............................................................................................ RETRACT 11 Procedures containing items within a dashed box are time critical and should be committed to memory. Remaining procedures are non-critical in the sense that time is usually available for consulting the check list EMERGENCY CHECKLIST Piper Arrow II PA28-R200 EMERGENCY CHECKLIST 12 ENGINE FAILURE IMMEDIATELY AFTER TAKEOFF If sufficient runway remains for a normal landing: GEAR ....................................................................................... KEEP DOWN LAND ................................................................................ STRAIGHT AHEAD If enough altitude to attempt a restart: AIRSPEED .......................................................................... SAFE (105 MPH) FUEL SELECTOR ............................................................................. SWITCH ELECTRIC FUEL PUMP............................................................................. ON MIXTURE ............................................................................................... RICH ALTERNATE AIR ........................................................................................ ON EMERGENCY GEAR LEVER ................................................ AS REQUIRED If power is not restored, proceed with power off landing procedures. Piper Arrow II PA28-R200 EMERGENCY CHECKLIST 13 ENGINE FAILURE DURING FLIGHT AIRSPEED ........................................................................................ 105 MPH GEAR AND FLAPS ................................................................................... UP FUEL SELECTOR ........................................................................... SWITCH ELECTRIC FUEL PUMP ........................................................................... ON MIXTURE ............................................................................................... RICH ALTERNATE AIR ....................................................................................... ON ENGINE GAUGES ............................................................................. CHECK IF NO PRESSURE INDICATED ........ CHECK TANK SELECTOR POSITION TO BE SURE ITS ON A TANK CONTAINING FUEL When power is restored: ALTERNATE AIR .................................................................................... OFF ELECTRIC FUEL PUMP.......................................................................... OFF If above steps do not restore power, prepare for an emergency landing. If time permits: IGNITION SWITCH .............................................. “L,” “R,” BACK TO “BOTH” THROTTLE AND MIXTURE .................................... DIFFERENT SETTINGS FUEL TANK ..................................................................................... SWITCH If power is not restored, proceed with power off landing procedures. NOTE: If engine failure was caused by fuel exhaustion, power will not be restored after tanks are switched until empty fuel lines are filled, which may require up to 10 seconds. Piper Arrow II PA28-R200 EMERGENCY CHECKLIST 14 POWER OFF LANDING AIRSPEED ...................................................................................... 105 MPH LANDING SITE ................................................................................... CHECK PROP ................................................................................. DECREASE RPM TRANSPONDER ..................................................................................... 7700 RADIO ............................................................................................... MAYDAY When field can be easily reached: AIRSPEED .......................................................................................... 90 MPH FLAPS .................................................................................... AS REQUIRED GEAR ..................................................................................... AS REQUIRED Gear down landing (smooth and firm fields): GEAR .................................................................................................... DOWN THROTTLE ....................................................................................... CLOSED MASTER ................................................................................................. OFF IGNITION SWITCHES ............................................................................. OFF MIXTURE ............................................................................... IDLE CUT-OFF SEAT BELTS/HARNESS ................................................................. TIGHTEN TOUCHDOWN ........................................... LOWEST POSSIBLE AIRSPEED Gear up landing (rocky fields): FLAPS ........................................................................................AS DESIRED THROTTLE ........................................................................................CLOSED MASTER .................................................................................................. OFF IGNITION SWITCHES ............................................................................ OFF FUEL SELECTOR VALVE ....................................................................... OFF MIXTURE ................................................................................ IDLE CUT-OFF SEAT BELT/HARNESS ...................................................................TIGHTEN TOUCHDOWN .......................................... LOWEST POSSIBLE AIRSPEED Piper Arrow II PA28-R200 EMERGENCY CHECKLIST 15 ENGINE FIRE ON THE GROUND If engine has not started: MIXTURE ................................................................................ IDLE CUT-OFF THROTTLE ........................................................................................... OPEN STARTER ............................................................... CONTINUE TO ENGAGE If engine has already started and is running: CONTINUE OPERATING If fire continues longer than a few seconds: FLAMES .................................................................................... EXTINGUISH If using a fire extinguisher: FUEL SELECTOR VALVES .................................................................... OFF MIXTURE ................................................................................ IDLE CUT-OFF ENGINE FIRE IN FLIGHT FUEL SELECTOR .................................................................................... OFF THROTTLE .......................................................................................... CLOSE MIXTURE .................................................................................IDLE CUT-OFF HEATER.................................................................................................... OFF DEFROSTER ........................................................................................... OFF LAND ...................................................................... AS SOON AS POSSIBLE ELECTRICAL FIRE IN FLIGHT MASTER SWITCH .................................................................................... OFF VENTS .................................................................................................. OPEN CABIN HEAT .......................................................................................... OFF LAND............................................................... AS SOON AS PRACTICABLE Piper Arrow II PA28-R200 EMERGENCY CHECKLIST 16 PROPELLER OVERSPEED THROTTLE ...................................................................................... RETARD OIL PRESSURE ................................................................................ CHECK PROPELLER CONTROL ....... FULL, DECREASE RPM, THEN SET IF ANY CONTROL AVAILABLE AIRSPEED ........................................................................................ REDUCE THROTTLE ....................... AS REQUIRED TO REMAIN BELOW 2700 RPM SPIN RECOVERY THROTTLE .............................................................................................. IDLE RUDDER ............................. FULL OPPOSITE DIRECTION OF ROTATION ELEVATOR ........................................................................ FULL FORWARD AILERONS .......................................................................................NEUTRAL When rotation stops: RUDDER .................................................................................... NEUTRALIZE ELEVATOR .................................. AS REQUIRED TO SMOOTHLY REGAIN LEVEL FLIGHT ATTITUDE 17 ABNORMAL CHECKLIST Piper Arrow II PA28-R200 ABNORMAL CHECKLIST 13 LANDING GEAR FAILS TO EXTEND MASTER SWITCH ...................................................................................... ON CIRCUIT BREAKERS ......................................................................... CHECK PANEL LIGHTS ................................................................. OFF IN DAYTIME GEAR INDICATOR BULBS ............................................................... CHECK EMERGENCY GEAR EXTENSION LEVER .............................................. UP NOTE: When the Emergency Landing Gear Extension is performed for training purposes, pull the circuit breaker prior to executing the emergency extension procedure. Breaker must be reset after the completion of the procedure to allow normal gear system operation. If landing gear doesn’t check down and locked: AIRSPEED ......................................................................... BELOW 100 MPH LANDING GEAR SELECTOR ........................................... DOWN POSITION If gear has still failed to lock down: HOLD EMERGENCY GEAR LEVER DOWN TO “EMERGENCY DOWN” POSITION If gear has still failed to lock down: YAW AIRPLANE ABRUPTLY FROM SIDE TO SIDE WITH RUDDER If nose gear will not lock down using above procedure, slow aircraft to the lowest safe speed attainable using the lowest possible power setting required for safe operation and accomplish the following: LANDING GEAR SELECTOR ............................................ DOWN POSITION NOTE: If all electrical power has been lost, the landing gear must be extended using the above emergency procedures. The landing gear position lights will not be operative. Piper Arrow II PA28-R200 ABNORMAL CHECKLIST 14 GEAR UP LANDING FLAPS ....................................................................................... AS DESIRED THROTTLE ....................................................................................... CLOSED MASTER ................................................................................................. OFF IGNITION SWITCHES ............................................................................ OFF FUEL SELECTOR VALVE ....................................................................... OFF MIXTURE ................................................................................ IDLE CUT-OFF SEAT BELT/HARNESS .................................................................. TIGHTEN TOUCHDOWN ........................................... MINIMUM POSSIBLE AIRSPEED NOTE: With the master off, the landing gear cannot be retracted. Piper Arrow II PA28-R200 ABNORMAL CHECKLIST 15 ROUGH ENGINE OPERATIONS/LOSS OF POWER Loss of oil pressure: LAND....................................................................... AS SOON AS POSSIBLE ALTITUDE ...................................................................................... MAINTAIN POWER SETTINGS ............................. . DON’T CHANGE UNNECESARILY IF ENGINE STOPPAGE, PROCEED TO POWER OFF LANDING High oil temperature: LAND................................................................ AS SOON AS PRACTICABLE OIL PRESSURE GAUGE ............................................................. MONITOR Loss of fuel pressure: FUEL PUMP ............................................................................................... ON MIXTURE ....................................................................................... FORWARD FUEL SELECTOR ........................................................................ FULL TANK Piper Arrow II PA28-R200 ABNORMAL CHECKLIST 16 ALTERNATOR FAILURE ELECTRICAL LOAD ........................................................................ REDUCE ALTERNATOR CIRCUIT BREAKERS ............................................... CHECK ALT SWITCH ................................................... OFF (1 SECOND), THEN ON If the ammeter continues to indicate no output, or alternator will not stay reset, turn off ALT switch, maintain minimum electrical load, and land as soon as practical. STARTING A FLOODED ENGINE THROTTLE .................................................................................. FULL OPEN MASTER SWITCH ...................................................................................... ON FUEL PUMP ............................................................................................. OFF MIXTURE ................................................................................IDLE CUT-OFF STARTER ........................................................................................ ENGAGE When the engine fires, advance the mixture control and retard the throttle. NOTE: It is recommended that cranking periods be limited to thirty seconds with a two-minute rest between cranking periods. Longer cranking periods will shorten the life of the starter. Piper Arrow II PA28-R200 ABNORMAL CHECKLIST 17 INADVERTENT ICING ENCOUNTER PITOT HEAT ............................................................................................... ON OPEN DOOR NOTE: An open door will not affect normal flight characteristics, and a normal landing can be made with the door open. To close the door in flight: AIRSPEED ....................................................................... SLOW TO 100 MPH CABIN VENTS ..................................................................................... CLOSE STORM WINDOW ................................................................................ OPEN If upper latch open: UPPER LATCH ................................................................................... LATCH If lower latch open: UPPER LATCH .................................................................................... OPEN DOOR .............................. PUSH OPEN FURTHER THEN CLOSE RAPIDLY UPPER LATCH ..................................................................................... LATCH 18 CHECKLIST SUPPLEMENT Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 17 V SPEEDS VSO ...................................................................................................... 64 MPH VS ....................................................................................................... 71 MPH VR ................................................................................................. 60-70 MPH VX ....................................................................................................... 85 MPH VY .................................................................................................... 100 MPH VFE ................................................................................................... 125 MPH VLO (MAX GEAR RETRACTION SPEED)...................................... 125 MPH VLE ................................................................................................... 150 MPH VNO ................................................................................................. 170 MPH VNE .................................................................................................. 214 MPH VA ..................................................................................................... 131 MPH Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 18 MAXIMUM GLIDE Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 19 BRIEFING GUIDE PASSENGER BRIEFING • Seatbelts • Air Vents • Fire Extinguisher • Exit Use • Survival Items • Traffic Watch CREW BRIEFING • Airport Diagram • ATIS / AWOS / FSS • Runways in use • Crosswind Component • Takeoff / Accelerate-Stop Distance • Departure / Taxi Clearance • Va • Who is PIC / Acting PIC? • Positive Exchange of Flight Controls • Sterile Cockpit • Safe Attitude PRE-TAKEOFF BRIEFING • Runway Available / Runway Required Obstacles on Departure • Wake Turbulence • Windsock / Crosswind Control Position EMERGENCY PLAN OF ACTION • Engine Failure or system malfunction: o Prior to rotation o After rotation, runway remaining o After rotation, no runway remaining Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 20 Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 21 Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 22 Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 23 Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 24 Piper Arrow II PA28R-200 CHECKLIST SUPPLEMENT 25