Aircraft Parts Catalogue

ATA 01 Page15-58 2 HOT AIR VALVE (DETAIL A) 21-50 COOLING 3 COOLING WINDOW INTAKE ATA 23 COMMUNICATIONS 23-10 SPEECH COMMUNICATIONS 1 COMM 1 ANTENNA 23-50 AUDIO INTEGRATING 2 AUDIO PANEL 3 MIC/PHONE CONNECTORS ATA 24 ELECTRICAL POWER 24-30 DC GENERATION 1 ALTERNATOR ASSY 2 BATTERY INSTALLATION 24-40 EXTERNAL POWER 3 EXTERNAL POWER INSTALLATION 24-60 DC ELECTRICAL LOAD DISTRIBUTION 4 FIREWALL ELECTRICAL COMPONENTS 5 BATTERY BACKUP AND RELAYS INTALLATION 6 GROUNDING COMPONENTS 7 BREAKER PANEL 8 CONNECTORS ATA 25 EQUIPMENT AND FURNISHINGS 25-10 FLIGHT COMPARTMENT ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page16-58 1 FLIGHT COMPARTMENT PARTS (SHEET 1) 2 FLIGHT COMPARTMENT PARTS (SHEET 2) 3 3-POINT SAFETY BELTS 4 4-POINT SAFETY BELTS (OPT) 25-50 CARGO COMPARTMENT 5 BAGGAGE COMPARTMENT (SHEET 1) 6 BAGGAGE COMPARTMENT (SHEET 2) 7 BAGGAGE COMPARTMENT (SHEET 3) 25-60 EMERGENCY 8 ELT COMPONENTS 9 STALL WARNING BUZZER 25-80 INSULATION 10 INSULATION PANELS ATA 27 FLIGHT CONTROLS 27-10 AILERON AND TAB 1 AILERON CONTROL 2 AILERON CONTROL (RODS INSTALLATION) 27-20 RUDDER 3 RUDDER CONTROL GENERAL VIEW 4 DETAIL A (SHEET 1) 5 DETAIL A (SHEET 2) 6 RUDDER CONTROL 27-30 ELEVATOR AND TAB ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page17-58 7 TAB CONTROL 27-40 HORIZONTAL STABILIZER / STABILATOR 8 STABILATOR AND TAB CONTROLS GENERAL VIEW 9 STABILATOR AND TAB CONTROLS 10 STICK ASSY (DETAIL A) 11 STABILATOR CONTROL 27-50 FLAPS 12 FLAP CONTROL INSTALLATION ATA 28 FUEL SYSTEM 28-10 STORAGE 1 FUEL TANK 28-20 DISTRIBUTION – DRAIN VALVES 2 FUEL SYSTEM (INSIDE) 3 FUEL SYSTEM (COWLING SIDE) 28-40 INDICATING 4 TELEVEL INSTALLATION ATA 31 INDICATING RECORDING SYSTEM 31-10 INSTRUMENT AND CONTROL PANELS 1 INSTRUMENT PANEL GENERAL VIEW 2 FRONT PANEL 3 CENTRAL PEDESTAL PANEL 31-60 CENTRAL DISPLAY SYSTEM 4 CENTRAL DISPLAY INSTALLATION ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page18-58 ATA 32 LANDING GEAR 32-00 GENERAL 1 GENERAL 32-10 MAIN GEAR AND DOORS 2 MLG 3 MLG BRAKE 32-20 NOSE GEAR/TAIL GEAR AND DOORS 4 NLG 5 NLG FAIRINGS 32-40 WHEEL AND BRAKES 6 GENERAL BRAKE SYSTEM 7 DETAIL A (SHEET 1) 8 DETAIL A (SHEET 2) 9 DETAIL B 10 DETAIL C ATA 33 LIGHTS 33-40 EXTERIOR LIGHTING 1 TIP LIGHTS 2 LANDING LIGHT ATA 34 NAVIGATION 34-10 FLIGHT ENVIRONMENT DATA 1 ANEMOMETRIC SYSTEM ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page19-58 2 STATIC DRAIN (DETAIL A) 34-20 ATTITUDE AND DIRECTION 3 COMPASS AND MAGNETOMETER LOCATION 4 MAGNETOMETER INSTALLATION 34-50 DEPENDENT POSITION DETERMINING 5 GPS ANTENNA INSTALLATION 6 DME TRANSPONDER ANTENNA 7 TRANSPONDER GTX 35R ATA 52 DOORS 52-00 GENERAL 1 GENERAL 52-10 PASSENGER / CREW 2 FUSELAGE HINGE 3 LOCK AND HANDLE SYSTEM 4 GRAB HANDLE AND OPENING SYSTEM 5 OPENING 52-40 SERVICE 6 EXTERNAL POWER DOOR 7 WING INSPECTION PANELS 8 CENTRAL PEDESTAL INSPECTION PANELS ATA 53 FUSELAGE 53-00 GENERAL 1 GENERAL ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page20-58 53-10 FUSELAGE STRUCTURE 2 ONLY CARBON FIBER FUSELAGE PARTS (SHEET 1) 3 ONLY CARBON FIBER FUSELAGE PARTS (SHEET 2) 4 PARACHUTE PARTS INSTALLATION DETAIL 5 FUSELAGE METALLIC PARTS (SHEET 1) 6 DETAL A/DETAIL B 7 DETAL C/DETAIL D 8 DETAL E/DETAIL F/ DETAIL G 9 FUSELAGE METALLIC PARTS (SHEET 2) 10 FUSELAGE METALLIC PARTS (SHEET 3) ATA 55 STABILIZERS 55-00 GENERAL 1 GENERAL 55-10 HORIZONTAL STABILIZER / STABILATOR OR CANARD 2 STABILATOR AND TAB 3 STABILATOR STRUCTURE 55-40 RUDDER 4 RUDDER STRUCTURE ATA 56 WINDOWS 56-10 FLIGHT COMPARTMENT 1 WINDOWS ATA 57 WINGS 57-10 WINGS STRUCTURE ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page21-58 1 WINGS STRUCTURE 2 WINGS SKIN 3 LEADING EDGE AND WING STRUT PARTS 4 STALL WARNING 5 FLAPS STRUCTURE 6 AILERON STRUCTURE ATA 61 PROPELLERS 61-10 PROPELLER ASSEMBLY 1 PROPELLER INSTALLATION ATA 71 POWERPLANT 71-00 GENERAL 1 GENERAL VIEW 71-10 COWLING 2 COWLING INSTALLATION 71-20 MOUNTS 3 ENGINE MOUNT 4 ENGINE SUPPORT 71-70 ENGINE DRAINS 5 ENGINE DRAINS ATA 74 IGNITION 74-10 ELECTRICAL POWER SUPPLY 1 SMD ELECTRONIC MODULE 74-30 SWITCHING ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page22-58 2 IGNITION SWITCH ATA 75 BLEED AIR LIQUID COOLING SYSTEM 75-20 ENGINE COOLING 1 COOLING SYSTEM GENERAL VIEW 2 COOLANT STORAGE 3 COOLANT DISTRIBUTION 4 RADIATOR INSTALLATION (SHEET 1) 5 RADIATOR INSTALLATION (SHEET 2) ATA 76 ENGINE CONTROLS 76-10 POWER CONTROL 1 THROTTLE CONTROL 2 CHOKE CONTROL ATA 77 ENGINE INDICATING 77-10 POWER 1 OIL PRESSURE PROBE 2 FUEL PRESSURE AND MAP SENSOR 77-20 TEMPERATURE 3 OIL AND COOLANT TEMPERATURE PROBE 77-40 INTEGRATED ENGINE INSTRUMENT SYSTEM 4 GEA 24 ATA 78 EXHAUST 78-00 GENERAL 1 EXHAUST GENERAL VIEW ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page23-58 78-10 COLLECTOR/NOZZLE 2 EXHAUST SYSTEM ATA 79 Oil system 79-10 STORAGE 1 OIL TANK 79-20 DISTRIBUTION 2 OIL DISTRIBUTION 3 OIL DISTRIBUTION (TO ENGINE) 4 RADIATOR INSTALLATION 5 OIL DISTRIBUTION (FROM ENGINE) ATA 80 STARTING 80-10 CRANKING 1 STARTER RELAY INSTALLATION 2 ENGINE STARTER ATA 93 SUPPLEMENT LIST ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-03 TABLE OF CONTENTS ATA 01 Page24-58 INTENTIONALLY LEFT BLANK ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page25-58 GENERAL ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page26-58 1. Purpose Costruzioni Aeronautiche Tecnam S.p.A. , Via Maiorise , 81043 Capua, Italy built the Tecnam P92Echo MK2. You can use the Illustrated Parts Catalogue to identify spare parts for the Tecnam P92Echo MK2. You can also use the Illustrated Parts Catalogue to identify their series or optional equipment. The Tecnam P92Echo MK2 Illustrated Parts Catalogue does not identify spare parts for the Rotax 912S engine. Only parts made by Costruzioni Aeronautiche Tecnam for engine installation will be identified in the Illustrated Parts Catalogue. For data on spare parts for the engine refer to the Rotax 912ULS2 Illustrated Parts Catalogue. The informations included in this Illustrated Parts Catalogue are based on data available at the time of pubblication. The Illustrated Parts Catalogue will be update, supplemented by all informations issued In Tecnam S.p.A. . Users are urged to keep abreast of the latest revision available through the Tecnam S.p.A. Official Website. 2. Effectivity This Illustrated Parts Catalogue is applicable to the Tecnam P92Echo MK2 aircraft. If one or more aircraft parts are applicable to specific Aircraft serial number, it is Specified in the "S/N" column of the detailed part list. 3. Record of Revisions The Illustrated Parts Catalogue has a Record of Revisions.  The revised pages replace the existing pages in the Illustrated Parts Catalogue.  The new pages will be inserted in the Illustrated Parts Catalogue by chapter, section, and page number. ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page27-58 4. Page Numbering System The page number is at the top on the outer right edge. The Pages Numbering System used in the Illustrated Parts Catalogue (in accordance with ATA 100 Specification), consists of two elements number separated by a dash. Chapter/system (e.i. Flight Control) Subject/Subsystems/section (e.i. Rudder) 27-20 5. Part numbering system Each assy is identified with a Part Number, which, in turn, is made of a series of sub assy. The sub assy are made of separate item also individually identified with another P/N. The P/N is a numerical code, thanks to which we can identify the group it belongs to. It is made of four numerical part separate with a dash (for example. 218-0-0000-000) Attached picture explains the “etymology” of a P/N: Identification aircraft number Origin sub-assy: -1, 2, 3, ... sub-assy group Sub-assy/single item/single item of -000 assy number -000 assy -1 single item -1/2 LH/RH single item -001, 002, ... single item of -000 assy -0-0000-000 218 In particular:  The first number is an abbreviation of the aircraft name, in this case is “P92Echo MK2” then “218”; ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page28-58  The second part, identifies the group. The P92Echo MK2 has been divided into nine groups: WINGS -1 FUSELAGE -2 FLIGHT CONTROLS -5 VERTICAL TAIL -6 STABILIZER -7 LANDING GEAR -8 SYSTEMS -9 ENGINE -10 INTERIORS -12  The third parts is a sequential number to identify a sub assy, a single item or a single item of an -000 assy/sub-assy.  The fourth and last part concern the assy (-000) or a single part (-1, -2, -3). Is also used to specify if there is a single part or a double left and right part (1/2 LH/RH, …). ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page29-58 The groups described are shown below: Engine Landing gear Wing Fuselage Vertical tail Stabilizer Systems Flight controls Interiors For example, an item having Part Number 218-1-1500-1/2 belongs to P92Echo MK2, located in the wing, and split in left (-1) and right (-2). 6. Detailed parts list (Refer Fig.1)  The Item Number (1) or the Alphabetic Character (only for assy) (2) refers to the Item Number in the corresponding illustration.  The Part Number column (4) includes the numbers assigned to the parts by the manufacturer.  The Nomenclature column (5) includes a brief description of the parts.  The "S/N" column (6) includes the number which indicate that use of the part is restricted. For example: “S/N xxx” indicates that the part is used only for the A/C with serial number xxx; “from S/N xxx to S/N yyy” indicates that the part is used from the A/C with S/N xxx to the A/C with S/N yyy; “from S/N xxx” indicates that the part is used from the A/C with S/N xxx.  The Q.ty Column (7) shown the quantity necessary for the next higher assembly or installation (LH or RH when it is necessary). ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page30-58 Figure 1 ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page31-58 7. Abbreviations The following abbreviations have been used in this Illustrated Parts Catalogue ABBREVIATION WORD & AND A AMPERE A/P AUTOPILOT AC ALTERNATING CURRENT A/C AIRCRAFT ADF AUTOMATIC DIRECTION FINDER ALT ALTERNATE AN ARMY - NAVY STANDARDS ASSY ASSEMBLY ATA AIR TRANSPORT ASSOCIATION OF AMERICA AUX AUXILIARY CYL CYLINDER DC DIRECT CURRENT DME DISTANCE MEASURING EQUIPMENT EXT EXTERNAL FG FIBERGLASS FIG. FIGURE FWD FORWARD KIAS KNOTS INDICATED AIRSPEED LH LEFT HAND LWR LOWER MLG MAIN LANDING GEAR MS MILITARY STANDARD NAS NATIONAL AEROSPACE STANDARDS NLG NOSE LANDING GEAR OAT OUTSIDE AIR TEMPERATURE ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page32-58 P/N PART NUMBER PSI POUND SQUARE INCH Q.TY QUANTITY RH RIGHT HAND RPM REVOLUTION OER MINUTE S/N SERIAL NUMBER SB SERVICE BULLETIN SECT SECTION STD STANDARD OPT OPTIONAL SYS SYSTEM TEMP. TEMPERATURE TH THICKNESS UNI ENTE NAZIONALE PER L'UNIFICAZIONE UPR UPPER V VOLT VFR VISUAL FLIGHT RULES VHF VERY HIGH FREQUENCY VOR VERY HIGH FREQUENCY OMNI DIRECTIONAL RADIO RANGING W WATT ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page33-58 8. Numerical Index The Numerical Index gives all the spare parts in the Illustrated Parts Catalogue. 9. How to use the Illustrated Parts Catalogue - If Part Numbers is known If the Part Number is known proceed as follows (Refers Figure 2) NOTE: For example search P/N "218-10-1002-1"  Find the Part Number (1) in the Numerical Index.  Locate the related chapter, section subject, figure and item number (2) in the Numerical Index.  Turn to chapter, section, subject and figure (3).  Locate the Part Number and the related Item Number (4) in the Part List.  Locate Item Number (5) on the illustrated through the Item Number. ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page34-58 Figure 2 5 1 2 4 3 ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page35-58 10. How to use the Illustrated Parts Catalogue - If Part Numbers is Unknown If the Part Number is Unknown proceed as follows (Refers figure 3) NOTE: For example search "Upper cowling".  Turn to Table of contents (1).  Search for "Powerplant" in the list (2).  Note the related Chapter 71 Powerplant (3).  Note the related Section 71-10 Cowling (4).  Note the related Figure "Cowling installation" (5).  Locate the related Chapter-Section (6).  Turn to the related Figure illustration (7).  Locate the related part in the illustration and note the Item number (8).  Turn to the related Detailed Part list and locate the item number (9).  Note Part Number, Description and Quantity of the related part (10). ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page36-58 1 Figure 3 2 3 4 5 6 7 8 9 10 ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page37-58 11. Spares Orders When you order spare parts, you must give the name of the system and its Chapter number. Or you must give the sub-system with its Section number. You must also give this data:  Figure and item number  Part number  Description  Quantity required  S/N of the airplane Example, you want to send an order for an Upper cowling. You must give this data:  Chapter 71-10; Cowling  Figure - Item 2 - 1  Part Number 218-10-1002-1  Description Upper cowling  Quantity 1  S/N 004 If the spare part does not have a part number, give:  Figure number  Item number  Description  Quantity Send you order to this address: Tecnam Costruzioni Aeronautiche S.p.A. , Via Maiorise , 81043 Capua, Italy. Or you can telephone (+39) 0823 622297 or Fax (+39) 0823 622899 ILLUSTRATED PARTS CATALOGUE Ed. 1 Rev. 0 ATA 01-04 GENERAL ATA 01 Page38-58 INTENTIONALLY LEFT BLANK