PARTS MANUAL FOR WIPLINE MODEL 2350 FLOATS ON CESSNA 172 & 175 SERIES

2. Name of person placing order 3. Invoicing information: a. Customer name - company or individual b. Address c. Phone and fax number 4. Shipping information: a. Address (if different from invoice address) b. Method of shipment/preferred carrier 5. Aircraft model, float model, and serial numbers 6. Wipaire part number; name; type, e.g. left or right; quantity 7. Payment method: VISA, MasterCard, C.O.D. (Collect on Delivery) (U.S. customers only), pre-payment by check or wire transfer, open account (see Credit Policy) Note: Any information not found in this manual for strut package parts and other installation items refer to the installation drawing package provided with the STC at the time of float installation. Additional drawing copies are available for purchase through the Wipaire Customer Service Department. P/N 1002168 Page 7 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES All references in this manual to LEFT and RIGHT are from the perspective of the pilot's seat with the floats fully installed and ready for floatplane operation. The following is a list of abbreviations that may appear in the description nomenclature fields of this manual: AB Afterbody Inbd. Inboard Amphib. Amphibious Lg. Large AR As Required Lt. Left Assy. Assembly Lwr. Lower Brkt. Bracket Opt. Optional Btm. Bottom Otbd. Outboard Bulk. Bulkhead Reinf. Reinforcement Ctr. Center Rr. Rear Cyl. Cylinder Rt. Right Ft. Front Sm. Small Ftg. Fitting SN Serial Number Fus. Fuselage Spr. Spreader Fwd Forward Upr. Upper Horiz. Horizontal Vert. Vertical Hyd. Hydraulic W.W. Wheel Well INTRODUCTION PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 8 P/N 1002168 USING THIS PARTS MANUAL COVERAGE Parts information is provided in this manual for the hulls and all "deck down" parts. For information on strut package parts and other aircraft installation items, refer to the installation drawing package provided with the STC at the time of float installation. Additional drawing copies are available for purchase through Wipaire Customer Service Department. ITEM QTY PART NO. PART DESCRIPTION - 1 1008815 ASSEMBLY BULKHEAD #1, 10000 1 1 1008797 PANEL, BULKHEAD #1 2 1 13A01156-085 DOUBLER #1 BULKHEAD 3 1 13A01357-049 CLEAT, SISTER KEEL ATTACH #1 BULKHEAD 4 1 13A01357-050 CLEAT, SISTER KEEL ATTACH #1 BULKHEAD 5 1 6A01156-054 ANGLE – TOP RAIL 6 1 6A01156-055 ANGLE – TOP RAIL 7 17 MS21047L4 NUT PLATE, SELF LOCKING To order an individual part, order the part number associated with item number. BULKHEAD #1 Name of main part in the section. Example: This part is showing the components made up in Bulkhead #1. Items with a (-) instead of a number represent the main part as an assembly. Other parts represent the parts included in the assembly. Main part image. If the image has numbers associated with it, then those numbers are item numbers shown in the table below. 7 4 5 2 1 3 6 P/N 1002168 Page 9 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 1 HULL BULKHEAD ASSEMBLIES CONTENTS HULL ASSEMBLY OVERVIEW - AMPHIBIAN ..............................................................................................10 HULL ASSEMBLY OVERVIEW - SEAPLANE ...............................................................................................12 NOSE BUMPER AMPHIBIAN ONLY .............................................................................................................14 NOSE BUMPER SEAPLANE ONLY ..............................................................................................................15 BULKHEAD #1 .................................................................................................................................................16 BULKHEAD #3 .................................................................................................................................................17 BULKHEAD #4 .................................................................................................................................................18 BULKHEAD #5 .................................................................................................................................................19 BULKHEAD #6 FWD .......................................................................................................................................20 BULKHEAD #6 AFT .........................................................................................................................................21 BULKHEAD #6 FWD SEAPLANE ONLY .......................................................................................................22 BULKHEAD #6 AFT SEAPLANE ONLY .........................................................................................................23 BULKHEAD #7 LEFT FLOAT AMPHIBIAN ONLY .........................................................................................24 BULKHEAD #7 RIGHT FLOAT AMPHIBIAN ONLY ......................................................................................25 BULKHEAD #8 LEFT FLOAT AMPHIBIAN ONLY .........................................................................................26 BULKHEAD #8 RIGHT FLOAT AMPHIBIAN ONLY ......................................................................................27 BULKHEAD #10 AMPHIBIAN ONLY ..............................................................................................................28 BULKHEAD #10 SEAPLANE ONLY ...............................................................................................................29 BULKHEAD #11 ...............................................................................................................................................30 BULKHEAD #12...............................................................................................................................................31 BULKHEAD #13...............................................................................................................................................32 BULKHEAD #15...............................................................................................................................................33 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 10 P/N 1002168 HULL ASSEMBLY OVERVIEW - AMPHIBIAN P/N 1002168 Page 11 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A01163-067 BULKHEAD #1 2 1 21A01000-265 ASSEMBLY, BULKHEAD #3 3 1 21A01000-261 ASSEMBLY, 2350 BULKHEAD #4 4 1 23A01000-296 ASSEMBLY, BULKHEAD STN #5 5 1 23A01000-297 BULKHEAD STN #6 ASSY 6 1 21A01000-252 ASSEMBLY, 2350 BULKHEAD #6 7 LT 1 21A01000-293 WHEEL WELL BUILD UP ASSY. LT. 7 RT 1 21A01000-294 WHEEL WELL BUILD UP ASSY RT. 8 1 21A01000-395 BULKHEAD STN. #11 ASSY 9 1 21A01000-396 ASSY, BULKHEAD #12 10 1 21A01000-397 ASSEMBLY, BULKHEAD #13 11 1 23A01000-298 BULKHEAD #15 ASSY 12 1 21A01000-260 SPREADER BAR PANEL FWD. ASSY. 13 1 21A01000-259 SPREADER BAR PANEL AFT ASSY 14 1 21A01000-295 NOSE BUMPER AMPHIBIAN 15 2 21A03115-001 TUBE, SPREADER BAR, MOUNTING PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 12 P/N 1002168 HULL ASSEMBLY OVERVIEW - SEAPLANE P/N 1002168 Page 13 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A01163-067 BULKHEAD #1 2 1 21A01000-265 ASSEMBLY, BULKHEAD #3 3 1 21A01000-261 ASSEMBLY, 2350 BULKHEAD #4 4 1 23A01000-296 ASSEMBLY, BULKHEAD STN #5 5 1 23A01000-297 BULKHEAD STN #6 ASSY 6 1 21A01000-252 ASSEMBLY, 2350 BULKHEAD #6 7 1 21S01000-308 ASSEMBLY, 2350 BULKHEAD #6 8 1 21S01000-309 ASSEMBLY, 2350 BULKHEAD #6 9 1 21S01000-322 ASSEMBLY, BULKHEAD 10, 2350 COMP 10 1 21A01000-395 BULKHEAD STN. #11 ASSY 11 1 21A01000-396 ASSY, BULKHEAD #12 12 1 21A01000-397 ASSEMBLY, BULKHEAD #13 13 1 23A01000-298 BULKHEAD #15 ASSY 14 1 23A01000-302 ASSY, SPREADER BAR PANEL, FWD 15 1 21A01000-259 ASSY, SPREADER BAR PANEL, AFT 16 1 21S01738-001 NOSE BUMPER - SEAPLANE 17 2 21A03115-001 TUBE, SPREADER BAR, MOUNTING PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 14 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-295 NOSE BUMPER - AMPHIBIAN 1 1 21A01000-295-1 NOSE BUMPER 2 2 21A01000-295-2 ANGLE, MOUNT, NOSE BUMPER 3 2 21A01000-295-3 PLATE, SCREW MOUNT, NOSE BUMPER 4 4 4HFW3 PUSH NUT WASHER 5 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 6 4 MS51958-67 SCREW, BUTTON HEAD NOSE BUMPER AMPHIBIAN ONLY P/N 1002168 Page 15 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21S01738-001 NOSE BUMPER - 2100 SEAPLANE NOSE BUMPER SEAPLANE ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 16 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01163-067 BULKHEAD #1 BULKHEAD #1 P/N 1002168 Page 17 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-265 ASSEMBLY, BULKHEAD #3 1 1 21A01158-184 BULKHEAD #3 2 1 21A01326-005 ANGLE, SUPPORT BULKHEAD #3 3 1 21A01326-006 ANGLE, SUPPORT BULKHEAD #3 4 30 AN470AD4-5 RIVET BULKHEAD #3 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 18 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-261 ASSEMBLY, 2350 BULKHEAD #4 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01158-174 BULKHEAD #4 - FORMED 3 1 21A01158-175 BULKHEAD SUPPORT #4 - FORMED BULKHEAD #4 P/N 1002168 Page 19 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 23A01000-296 ASSEMBLY, BULKHEAD STN #5 1 1 23A01158-196 BULKHEAD #5 - FORMED 2 2 21A01158-177 SUPPORT, BULKHEAD #6 3 3 3A01158-003 CLAMP, PUMP OUT TUBE BULKHEAD #5 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 20 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 23A01000-297 BULKHEAD STN #6 ASSY 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01158-177 SUPPORT, BULKHEAD # 6 3 1 21A01163-066 SPREADER BAR PANEL 4 1 23A01158-197 BULKHEAD #6 - 2350 5 1 23A01326-016 ANGLE, BULKHEAD STN #5 6 1 23A01326-017 ANGLE, BULKHEAD STN #5 BULKHEAD #6 FWD P/N 1002168 Page 21 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-252 ASSEMBLY, 2350 BULKHEAD #6 1 1 21A01158-189 BULKHEAD #6 2 1 21A01158-177 SUPPORT, BULKHEAD # 6 3 1 MS35489-19 GROMMET, RUBBER BULKHEAD #6 AFT PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 22 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21S01000-308 ASSEMBLY, 2350 BULKHEAD #6 SEAPLANE 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01158-177 SUPPORT, BULKHEAD #6 3 1 21A01158-189 BULKHEAD #6 BULKHEAD #6 FWD SEAPLANE ONLY P/N 1002168 Page 23 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21S01000-309 ASSEMBLY, 2350 BULKHEAD #6 SEAPLANE 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01158-177 SUPPORT, BULKHEAD #6 3 1 21A01158-189 BULKHEAD #6 4 1 21S01158-203 ANGLE, BULKHEAD #8 AFT BULKHEAD #6 AFT SEAPLANE ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 24 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-267 ASSEMBLY, BULKHEAD #7, LH 1 1 21A01158-187 SUPPORT, BLKHD 7, RH, 2350 2 1 21A01158-181 BULKHEAD #7 - LH BULKHEAD #7 LEFT FLOAT AMPHIBIAN ONLY P/N 1002168 Page 25 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-266 ASSEMBLY, BULKHEAD #7, RH 1 1 21A01158-182 BULKHEAD #7 - RH 2 1 21A01158-188 SUPPORT, BLKHD 7, LH, 2350 BULKHEAD #7 RIGHT FLOAT AMPHIBIAN ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 26 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-263 ASSY, BULKHEAD #8, LH 1 1 21A01158-179 ANGLE - AFTERBODY ATTACH - RH 2 1 21A01158-180 ANGLE - AFTERBODY ATTACH - LH 3 1 21A01158-191 BULKHEAD #8 - LH - FORMED 4 1 21A01158-193 SUPPORT - LH - BULKHEAD #8 BULKHEAD #8 LEFT FLOAT AMPHIBIAN ONLY P/N 1002168 Page 27 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-264 ASSY, BULKHEAD #8, RH 1 1 21A01158-179 ANGLE - AFTERBODY ATTACH - RH 2 1 21A01158-180 ANGLE - AFTERBODY ATTACH - LH 3 1 21A01158-190 BULKHEAD #8 - RH - FORMED 4 1 21A01158-192 SUPPORT - RH - BULKHEAD #8 BULKHEAD #8 RIGHT FLOAT AMPHIBIAN ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 28 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-262 ASSY, BLKHD 10, 2350 COMP 1 1 21A01158-169 BULKHEAD #10 - FORMED 2 1 21A01163-066 SPREADER BAR PANEL 3 1 21A01326-011 ANGLE, SIDE BAR, BULKHEAD #10, LF 4 1 21A01326-012 ANGLE, SIDE BAR, BULKHEAD #10, RT 5 1 3A01158-003 CLAMP, PUMP OUT TUBE BULKHEAD #10 AMPHIBIAN ONLY P/N 1002168 Page 29 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21S01000-322 ASSEMBLY, BULKHEAD 10, 2350 COMP 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01158-169 BULKHEAD #10 - FORMED 3 1 21A01163-066 SPREADER BAR PANEL 4 1 21A01326-011 ANGLE, SIDE BAR, BULKHEAD #10, LF 5 1 21A01326-012 ANGLE, SIDE BAR, BULKHEAD #10, RT BULKHEAD #10 SEAPLANE ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 30 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-395 BULKHEAD STN. #11 ASSY 1 1 21A01158-168 BULKHEAD #11 - FORMED BULKHEAD #11 P/N 1002168 Page 31 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-396 ASSY, BULKHEAD #12 1 1 21A01158-167 BULKHEAD #12 - FORMED BULKHEAD #12 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 32 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-397 ASSEMBLY, BULKHEAD #13 1 1 21A01158-166 BULKHEAD #13 - FORMED BULKHEAD #13 P/N 1002168 Page 33 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 23A01000-298 BULKHEAD #15 ASSY 1 1 23A01158-198 BULKHEAD #15 2 1 21A08156-130 PLATE - WATER RUDDER STOP 3 1 1009187 CHANNEL - BULKHEAD #15 BULKHEAD #15 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 34 P/N 1002168 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002168 Page 35 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 2 WHEEL WELL ASSEMBLIES CONTENTS WHEEL WELL BUILD UP ASSEMBLY LEFT FLOAT ...................................................................................36 WHEEL WELL BUILD UP ASSEMBLY RIGHT FLOAT.................................................................................38 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 36 P/N 1002168 WHEEL WELL BUILD UP ASSEMBLY LEFT FLOAT ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-293 WHEEL WELL BUILD UP ASSY. LT. 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01000-255 ASSEMBLY, WHEEL WELL LONG, LH 1 21A01359-196 ANGLE - WHEEL WELL 1 21A01359-198 ANGLE, WHEEL WELL, LONG, 2350 COMP 1 21A01017-007 CARRY THRU STRAP - SHORT - LH 1 21A01160-022 PLATE - SUPPORT WHEEL WELL WIDE - RH 1 21A01160-020 PLATE - SUPPORT - WHEELWELL - RH 1 21A01357-058 ANGLE, WIDE WHEEL WELL, LONG, RT, 2350 1 21A01002-135 PANEL - WHEEL WELL LONG 3 1 21A01000-257 ASSY, WHEEL WELL. SHORT, LT, 2350 1 1003343 DOUBLER, PROXIMITY SWITCH 1 21A01002-133 PANEL, WHEEL WELL SHORT 1 21A01017-005 CARRY THRU STRAP - LONG - SMALL HOLE - LH P/N 1002168 Page 37 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 21A01160-021 PLATE - SUPPORT WHEEL WELL- LH 1 21A01160-023 PLATE - SUPPORT - WHEEL WELL WIDE - LH 1 21A01357-056 ANGLE, WIDE WHEEL WELL SHORT, RIGHT 1 21A01359-195 ANGLE - WHEEL WELL 1 21A01359-200 ANGLE, LONG WHEEL WELL SHORT 4 1 21A01000-262 ASSY, BLKHD 10, 2350 COMP 5 1 21A01000-263 ASSY, BULKHEAD #8, LH 6 1 21A01000-267 ASSEMBLY, BULKHEAD #7, LH 7 1 21A01000-289 ASSY, SIDE PANEL, WHEEL WELL, LT. 2350 1 21A01158-185 PANEL - LH - WHEEL WELL 1 13A01156-124 SUPPORT, INSPECTION COVER, WHEEL WELL, LARGE 8 1 21A01000-290 ASSY, SIDE PANEL, WHEEL WELL, RT. 2350 1 21A01158-186 PANEL - RH - WHEEL WELL 1 13A01156-124 SUPPORT, INSPECTION COVER, WHEEL WELL, LARGE 9 1 21A01000-291 ASSY, CARRY THRU STRAP, LT, 2350 1 21A01017-002 CARRY THRU STRAP - LONG - LARGE HOLE - RH 1 21A01156-132 ANGLE, CARRY THRU, RIGHT 10 1 21A01156-125 SPACER, CARRY THRU STRAP, 2350 11 1 21A01326-015 ANGLE, CARRY THRU PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 38 P/N 1002168 WHEEL WELL BUILD UP ASSEMBLY RIGHT FLOAT ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-294 WHEEL WELL BUILD UP ASSY. RT. 1 1 3A01158-003 CLAMP, PUMP OUT TUBE 2 1 21A01000-254 ASSEMBLY, WHEEL WELL LONG, RH 1 21A01002-135 PANEL - WHEEL WELL LONG 1 21A01017-006 CARRY THRU STRAP - SHORT - RH 1 21A01359-197 ANGLE, LONG WHEEL WELL, LONG 1 21A01359-195 ANGLE - WHEEL WELL 1 21A01160-023 PLATE - SUPPORT - WHEEL WELL WIDE - LH 1 21A01160-021 PLATE - SUPPORT WHEEL WELL- LH 1 21A01357-059 ANGLE, WIDE WHEEL WELL LONG, LT, 2350 3 1 21A01000-256 ASSY, WHEEL WELL PANEL, SHORT, RH 1 1003343 DOUBLER, PROXIMITY SWITCH 1 21A01002-133 PANEL, WHEEL WELL SHORT P/N 1002168 Page 39 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 21A01017-004 CARRY THRU STRAP - LONG - SMALL HOLE - RH 1 21A01160-020 PLATE - SUPPORT - WHEEL WELL - RH 1 21A01160-022 PLATE - SUPPORT WHEEL WELL WIDE - RH 1 21A01357-057 ANGLE, WIDE WHEEL WELL SHORT, LEFT 1 21A01359-196 ANGLE - WHEEL WELL 1 21A01359-199 ANGLE, LONG WHEEL WELL SHORT 4 1 21A01000-262 ASSY, BLKHD 10, 2350 COMP 5 1 21A01000-264 ASSY, BULKHEAD #8, RH 6 1 21A01000-266 ASSEMBLY, BULKHEAD #7, RH 7 1 21A01000-289 ASSY, SIDE PANEL, WHEEL WELL, LT. 2350 1 21A01158-185 PANEL - LH - WHEEL WELL 1 13A01156-124 SUPPORT, INSPECTION COVER, WHEEL WELL, LARGE 8 1 21A01000-290 ASSY, SIDE PANEL, WHEEL WELL, RT. 2350 1 21A01158-186 PANEL - RH - WHEEL WELL 1 13A01156-124 SUPPORT, INSPECTION COVER, WHEEL WELL, LARGE 9 1 21A01000-292 ASSY, CARRY THRU STRAP, RT, 2350 1 21A01017-003 CARRY THRU STRAP - LONG - LARGE HOLE - LH 1 21A01156-131 ANGLE, CARRY THRU, LEFT 10 1 21A01156-125 SPACER, CARRY THRU STRAP, 2350 11 1 21A01326-015 ANGLE, CARRY THRU PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 40 P/N 1002168 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002168 Page 41 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 3 SKINS & STIFFENERS CONTENTS BOTTOM & SIDE SKINS & STIFFENERS OVERVIEW - AMPHIBIAN .......................................................42 BOTTOM & SIDE SKINS & STIFFENERS OVERVIEW - SEAPLANE ........................................................44 BOTTOM SKIN ASSEMBLIES .......................................................................................................................46 BOTTOM SKIN WITH STIFFENERS LEFT ..................................................................................................47 BOTTOM SKIN WITH STIFFENERS RIGHT ................................................................................................48 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 42 P/N 1002168 BOTTOM & SIDE SKINS & STIFFENERS OVERVIEW - AMPHIBIAN P/N 1002168 Page 43 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 3A01000-005 STEP – BOARDING 2 2 21A01156-126 REINFORCEMENT – COVER 3 2 21A01000-427 COVER, SIDE ACCESS ASS’Y 2 21A01004-101 COVER – INSP. 56 AN526-632R6 SCREW – ATTACH 2 21A01567-012 GASKET 4 1 23A01004-109 SIDE SKIN – STEP TO BOW L. OUTBR’D 1 23A01004-108 SIDE SKIN – STEP TO BOW R. OUTBR’D 1 23A01004-111 SIDE SKIN – STEP TO BOW L. INBR’D 1 23A01004-110 SIDE SKIN – STEP TO BOW R. INBR’D 1 3A01158-093 BRACKET (PADDLE) 1 1002113 PADDLE STOP 1 3A01503-001 CLIP (HOLDS PADDLE) 1 0238-0035 PADDLES 5 1 23A01004-113 SIDE SKIN – STEP TO STERN L. OUTBR’D 1 23A01004-112 SIDE SKIN – STEP TO STERN R. OUTBR’D 1 23A01004-115 SIDE SKIN – STEP TO STERN L. INBR’D 1 23A01004-114 SIDE SKIN – STEP TO STERN R. INBR’D 6 2 23A01340-114 STIFFENER – SIDE SKIN 7 2 23A01340-115 STIFFENER – SIDE SKIN 8 2 23A01340-116 STIFFENER – SIDE SKIN 9 2 23A01340-117 STIFFENER – SIDE SKIN 10 2 23A01340-118 STIFFENER – SIDE SKIN 11 1 1011500 ASSEMBLY, SKIN, BOTTOM, FWD, LEFT, 2350 (SEE DETAIL) 1011501 ASSEMBLY, SKIN, BOTTOM, FWD, RIGHT, 2350 (SEE DETAIL) 12 1 23A01004-121 BOTTOM SKIN AFTERBODY L. 1 23A01004-120 BOTTOM SKIN AFTERBODY R. 13 1 21A01000-274 ASS’Y SPRAY RAIL L. 1 21A01000-275 ASS’Y SPRAY RAIL R. 14 1 21A01000-429 BOOSTER – SISTER KEEL L. 1 21A01000-428 BOOSTER – SISTER KEEL R. 15 1 21A01162-033 DOUBLER – GUNWALL AFT L. 16 1 21A01162-031 DOUBLER – GUNWALL FWD L. 1 21A01162-032 DOUBLER – GUNWALL FWD R. 1 21A01162-034 DOUBLER – GUNWALL AFT R. 17 1 1009446 SCALLOP, FORMED WITH FOAM, RIGHT 2350 S/N 23177 OR LATER 1 1009539 SCALLOP, FORMED WITH FOAM, LEFT 2350 S/N 23177 OR LATER PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 44 P/N 1002168 BOTTOM & SIDE SKINS & STIFFENERS OVERVIEW - SEAPLANE P/N 1002168 Page 45 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 23S01004-123 SIDE SKIN – STEP TO BOW L. OUTBR’D 1 23S01004-122 SIDE SKIN – STEP TO BOW R. OUTBR’D 1 23S01004-125 SIDE SKIN – STEP TO BOW L. INBR’D 1 23S01004-124 SIDE SKIN – STEP TO BOW R. INBR’D 1 3A01158-093 BRACKET (PADDLE) 1 1002113 PADDLE STOP 1 3A01503-001 CLIP (HOLDS PADDLE) 1 0238-0035 PADDLES 2 1 23A01004-113 SIDE SKIN – STEP TO STERN L. OUTBR’D 1 23A01004-112 SIDE SKIN – STEP TO STERN R. OUTBR’D 1 23A01004-115 SIDE SKIN – STEP TO STERN L. INBR’D 1 23A01004-114 SIDE SKIN – STEP TO STERN R. INBR’D 3 2 23A01340-114 STIFFENER – SIDE SKIN 4 2 23A01340-115 STIFFENER – SIDE SKIN 5 2 23A01340-116 STIFFENER – SIDE SKIN 6 2 23A01340-117 STIFFENER – SIDE SKIN 7 2 23A01340-118 STIFFENER – SIDE SKIN 8 1 1011500 ASSEMBLY, SKIN, BOTTOM, FWD, LEFT, 2350 (SEE DETAIL) 1011501 ASSEMBLY, SKIN, BOTTOM, FWD, RIGHT, 2350 (SEE DETAIL) 9 1 23S01004-133 BOTTOM SKIN AFTERBODY L. 1 23S01004-132 BOTTOM SKIN AFTERBODY R. 10 1 21A01000-275 ASS’Y SPRAY RAIL L. 1 21A01000-274 ASS’Y SPRAY RAIL R. 11 1 21A01000-429 BOOSTER – SISTER KEEL L. 1 21A01000-428 BOOSTER – SISTER KEEL R. 12 1 21A01162-033 DOUBLER – GUNWALL AFT L. 1 21A01162-034 DOUBLER – GUNWALL AFT R. 13 1 21A01162-031 DOUBLER – GUNWALL FWD L. 1 21A01162-032 DOUBLER – GUNWALL FWD R. 14 1 1009539 SCALLOP, FORMED WITH FOAM, LEFT, 2350 1 1009446 SCALLOP, FORMED WITH FOAM, RIGHT, 2350 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 46 P/N 1002168 BOTTOM SKIN ASSEMBLIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1011500 ASSEMBLY, SKIN, BOTTOM, FWD, LEFT, 2350 (SEE DETAIL) 2 1 1011501 ASSEMBLY, SKIN, BOTTOM, FWD, RIGHT, 2350 (SEE DETAIL) P/N 1002168 Page 47 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES BOTTOM SKIN WITH STIFFENERS LEFT ITEM QTY PART NO. PART DESCRIPTION - 1 1011500 ASSEMBLY, SKIN, BOTTOM, FWD, LEFT, 2350 1 1 1011412 STIFFENER, BOTTOM SKIN, FWD 2 1 1011413 STIFFENER, BOTTOM SKIN, FWD 3 3 1011420 STIFFENER, BOTTOM SKIN, FWD 4 1 1011422 SKIN, BOTTOM, LH, FWD, 2350 5 1 1011424 STIFFENER, BOTTOM SKIN, FWD 6 1 1011425 STIFFENER, BOTTOM SKIN, FWD 7 1 1011426 STIFFENER, BOTTOM SKIN, FWD 8 1 1011428 STIFFENER, BOTTOM SKIN, FWD PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 48 P/N 1002168 BOTTOM SKIN WITH STIFFENERS RIGHT ITEM QTY PART NO. PART DESCRIPTION - 1 1011501 ASSEMBLY, SKIN, BOTTOM, FWD, RIGHT, 2350 1 1 1011412 STIFFENER, BOTTOM SKIN, FWD 2 1 1011413 STIFFENER, BOTTOM SKIN, FWD 3 3 1011421 STIFFENER, BOTTOM SKIN, FWD 4 1 1011423 SKIN, BOTTOM, RH, FWD, 2350 5 1 1011424 STIFFENER, BOTTOM SKIN, FWD 6 1 1011425 STIFFENER, BOTTOM SKIN, FWD 7 1 1011426 STIFFENER, BOTTOM SKIN, FWD 8 1 1011429 STIFFENER, BOTTOM SKIN, FWD P/N 1002168 Page 49 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 4 TOP DECK ASSEMBLY CONTENTS TOP DECK - AMPHIBIAN ...............................................................................................................................50 TOP DECK - SEAPLANE ................................................................................................................................53 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 50 P/N 1002168 TOP DECK - AMPHIBIAN P/N 1002168 Page 51 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 23A01004-117 SKIN – FWD SECTION L. 1 23A01004-116 SKIN – FWD SECTION R. 2 1 23A01004-119 SKIN – AFT SECTION L. 1 23A01004-118 SKIN – AFT SECTION R. 3 4 21A01002-130 SUPPORT – INSP. COVER – LARGE A/R 1002481 NUT – TINNERMAN & INSULATOR 4 5 21A01002-131 SUPPORT – INSP. COVER – SMALL A/R 1002481 NUT – TINNERMAN & INSULATOR 5 4/3 21A01000-258 INSP. COVER – LARGE – W/ ANGLE & GASKETS A/R #8 X 5/8 SCREW – ATTACH 4/3 1001437 SEAL – GASKET ONLY 4/3 21A01567-001 SEAL – GASKET ONLY 6 5 21A01000-284 INSP. COVER – SMALL & GASKETS A/R #8 X 5/8 SCREW – ATTACH 5 1001728 SEAL – GASKET ONLY 5 21A01567-002 SEAL – GASKET ONLY 7 1 21A01002-137 COVER – GEAR INDICATOR L. 1 21A01002-138 COVER – GEAR INDICATOR R. 1 10A3-6338-1 PLACARD – DOWN - LAND 1 10A3-6338-2 PLACARD – UP - WATER 4 2600-3 SCREW – CAM - LOK 2 1126000-5 SCREW – CAM – LOK 6 212-12 RECEPTACLE – CAM – LOK 8 1 21A01150-131 JAMB – BAGGAGE DOOR 1 1002067 JAMB – HINGE SIDE 9 1 21A01000-268 ASSY – BAGGAGE DOOR 1 21A01162-035 COVER - SKIN 1 21A01741-004 HINGE 1 1002186 HINGE PIN 2 21A01010-012 STIFFENER - DOOR 2 21A01004-106 STIFFENER ENDS 2 3A01206-001 RETAINER - LOCK 2 3A01273-004 LOCK PIN 2 3A01702-004 CATCH – LATCH 2 3A01525-003 LOCK SPRING 2 1002663 RING – OPENING 1 1001438 SEAL – GASKET (NOT SHOWN) BAGGAGE HUTCH 12 01692-0410 POP RIVET 2 10/32 X ½ SS BOLT 10 1 21A01326-003 TOP RAIL – BAGGAGE OPENING L. 1 21A01326-002 TOP RAIL – BAGGAGE OPENING R. PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 52 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 11 2 21A01326-004 JAMB – BAGGAGE DOOR 12 2 21A01203-001 CLEAT – TIE DOWN 4 21A01280-004 BUSHING 4 AN525-10R24 SCREW – ATTACH 13 1 21A01000-273 INSP. COVER – LARGE – W/ ANGLE (2 CUPS) & GASKETS A/R #8 X 5/8 SCREW – ATTACH 1 1001437 SEAL – GASKET ONLY P/N 1002168 Page 53 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES TOP DECK - SEAPLANE PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 54 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 23S01004-139 SKIN – FWD SECTION L. 1 23S01004-138 SKIN – FWD SECTION R. 2 1 23S01004-141 SKIN – AFT SECTION L. 1 23S01004-140 SKIN – AFT SECTION R. 3 5 21A01002-130 SUPPORT – INSP. COVER - LARGE A/R 1002481 NUT – TINNERMAN & INSULATOR 4 5 21A01002-131 SUPPORT – INSP. COVER – SMALL A/R 1002481 NUT – TINNERMAN & INSULATOR 5 5 21A01000-258 INSP. COVER – LARGE – W/ ANGLE & GASKETS A/R #8 X 5/8 SCREW – ATTACH 5 1001437 SEAL – GASKET ONLY 5 21A01567-001 SEAL – GASKET 6 5 21A01000-284 INSP. COVER – SMALL & GASKETS A/R #8 X 5/8 SCREW – ATTACH 5 1001728 SEAL – GASKET ONLY 5 21A01567-002 SEAL – GASKET 7 1 21S01000-399 COVER W/ GASKET 1 21S01567-013 SEAL – GASKET A/R #8 X 5/8 SCREW – ATTACH A/R 1002481 NUT – TINNERMAN & INSULATOR 2 30S01326-035 STIFFENER – ANGLE 8 1 21A01150-131 JAMB – BAGGAGE DOOR 1 1002067 JAMB – BAGGAGE DOOR, HINGE SIDE 9 1 21A01000-268 ASSY – BAGGAGE DOOR 1 21A01162-035 COVER – SKIN 1 21A01741-004 HINGE 2 21A01010-012 STIFFENER – DOOR 1 1002186 HINGE PIN 2 21A01004-106 STIFFENER ENDS 2 3A01206-004 RETAINER – LOCK 2 3A01273-004 LOCK PIN 2 3A01702-001 CATCH – LATCH 2 3A01525-003 LOCK SPRING 2 1002663 RING – OPENING 1 1001438 SEAL – GASKET (NOT SHOWN) 12 01692-0410 POP RIVET 2 10/32 X ½ SS BOLT 10 1 21A01326-003 TOP RAIL – BAGGAGE OPENING L. 1 21A01326-002 TOP RAIL – BAGGAGE OPENING R. 11 1 21A01326-004 JAMB – BAGGAGE DOOR 12 2 21A01203-001 CLEAT – TIE DOWN P/N 1002168 Page 55 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 4 21A01280-004 BUSHING 4 AN525-10R24 SCREW – ATTACH 13 1 21A01000-273 INSP. COVER – LARGE – W/ ANGLE (2 CUPS) & GASKETS A/R #8 X 5/8 SCREW – ATTACH 1 1001437 SEAL – GASKET ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 56 P/N 1002168 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002168 Page 57 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 5 EXTRUSIONS CONTENTS HULL EXTRUSIONS - AMPHIBIAN ...............................................................................................................58 HULL EXTRUSIONS - SEAPLANE ................................................................................................................60 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 58 P/N 1002168 HULL EXTRUSIONS - AMPHIBIAN P/N 1002168 Page 59 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 23A01324-003 GUNWALL – L. 1 23A01324-004 GUNWALL – R. 2 1 23A01340-013 CHINE - FWD L. 1 23A01340-012 CHINE – FWD R. 3 1 23A01340-011 CHINE – AFTERBODY L. 1 23A01340-010 CHINE – AFTERBODY R. 4 1 23A01321-002 KEEL - MAIN 5 1 23A01008-170 KEEL - AFTERBODY 6 1 23A01005-295 STRAP – CHINE L. 1 23A01005-296 STRAP – CHINE R. PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 60 P/N 1002168 HULL EXTRUSIONS - SEAPLANE P/N 1002168 Page 61 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 23A01324-003 GUNWALL – L. 1 23A01324-004 GUNWALL – R. 2 1 23A01340-013 CHINE - FWD L. 1 23A01340-012 CHINE – FWD R. 3 1 23A01340-011 CHINE – AFTERBODY L. 1 23A01340-010 CHINE – AFTERBODY R. 4 1 23S01321-003 KEEL - MAIN 5 1 23S01008-173 KEEL - AFTERBODY 6 1 21S01163-037 ANGLE SUPPORT – AFTERBODY L. 1 21S01163-038 ANGLE SUPPORT – AFTERBODY R. 7 1 23A01005-295 STRAP - CHINE L. 1 23A01005-296 STRAP – CHINE R. PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 62 P/N 1002168 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002168 Page 63 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 6 PUMPER TUBE INSTALLATION CONTENTS PUMPER TUBE ...............................................................................................................................................64 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 64 P/N 1002168 PUMPER TUBE ITEM QTY PART NO. PART DESCRIPTION 1 1 4A01749-001 CUP – PUMPOUT ALUM. A/R MS20470AD4-4 RIVETS 2 1 57134 CLAMP – UPPER END 3 1 3A01158-003 CLAMP – LOWER END 4 1 2111 STOPPER – PUMPER TUBE 5 1 21A01618-062 PUMPOUT TUBE 10.5 IN. 1 21A01618-061 PUMPOUT TUBE 12.5 IN. 1 21A01618-060 PUMPOUT TUBE 15.0 IN. 1 21A01618-059 PUMPOUT TUBE 17.5 IN. 1 21A01618-058 PUMPOUT TUBE 23.0 IN. 1 21A01618-056 PUMPOUT TUBE 21.5 IN. 1 21A01618-055 PUMPOUT TUBE 18.5 IN. P/N 1002168 Page 65 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 7 WATER RUDDER AND STEERING & RETRACT SYSTEM CONTENTS WATER RUDDER INSTALLATION ................................................................................................................66 RETRACT HANDLE ASSEMBLY ...................................................................................................................68 STEERING AND RETRACT SYSTEM .........................................................................................................70 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 66 P/N 1002168 WATER RUDDER INSTALLATION P/N 1002168 Page 67 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A08000-123 ASS’Y., BLADE 1 1002649 WATER RUDDER BLADE 2350 1 21A08019-001 ARM, L. 1 21A08019-002 ARM, R. 2 1 1003858 WATER RUDDER POST WITH BELLCRANK ASSEMBLY 1 1003854 WATER RUDDER POST ASSEMBLY 1 1003267 WATER RUDDER POST 2 05DU06 BUSHING, SELF LUBRICATING, .313 ID X .375 LONG 1 1003853 BELLCRANK, WATER RUDDER POST ASSEMBLY 1 1003274 BELLCRANK, WATER RUDDER POST 2 03DU04 SELF LUBRICATING BUSHINGS 1 21A08648-002 BUMPER, DOWN STOP 1 1001457 ROLL PIN 1 21A8602-009 GUIDE, RETRACT 1 5/16 X 1 ½ INCHES PIN ATTACH 3 2 21A08525-006 SPRING 4 1 AN5-25A BOLT, 5/16-24, 2.1875 GRIP, UNDRILLED, STEEL 3 NAS1149D0516J WASHER, 0.328 ID, 0.016 THK, ALUMINUM 1 NAS 1149D0563J WASHER, 0.328 ID, 0.063 THK, ALUMINUM 1 MS21083N5 NUT, LOCKING, LOW HEIGHT, 5/16-24 UNF 5 1 AN5-11A BOLT, 5/16-24, 0.6875 GRIP, UNDRILLED, STEEL A/R NAS1149D0563J WASHER, 0.328 ID, 0.063 THK, ALUMINUM 1 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF 6 1 21A01000-299 ASS’Y., TOP BEARING 1 21A01019-003 BRACKET, TOP RUDDER BEARING 1 21A01705-003 BUSHING, TOP RUDDER PLATE 7 1 21A08000-157 ASS’Y., LOWER BEARING 1 21A08318-002 BRACKET - WATER RUDDER, LOWER PIVOT 1 05DU06 BUSHING, SELF LUBRICATING, .313 ID X .375 LONG 8 2 21A08154-009 STOP, WATER RUDDER, STEERING 2 AN4-6A BOLT, 1/4-28, 0.3125 GRIP, UNDRILLED, STEEL 2 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 2 MS21083N4 NUT, LOCKING, LOW HEIGHT, 1/4-28 UNF 2 AN3-6A BOLT, 10-32, 0.375 GRIP, UNDRILLED, STEEL 2 NAS1149D0316J WASHER, 0.203 ID, 0.016 THK, ALUMINUM 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 9 1 AN5-12A BOLT SIZE 5/16-24, LNGTH +/- 1/64 - 1-11/32, GRIP LNGTH 13/16 A/R NAS1149D0563J WASHER, 0.328 ID, 0.063 THK, ALUMINUM 1 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 68 P/N 1002168 RETRACT HANDLE ASSEMBLY P/N 1002168 Page 69 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A08000-128 ASS’Y – RETRACT HANDLE 1 3A08003-015 BRACKET SIDE L. 1 3A08003-016 BRACKET SIDE R. 2 1 3A08414-001 HANDLE 3 1 21A08000-137 CABLE ASS’Y 4 1 MS20219-2 PULLEY 1 AN4-10A BOLT, 1/4-28, 0.5625 GRIP, UNDRILLED, STEEL 2 NAS1149F0463P WASHER, 0.265 ID, 0.063 THK, STEEL 1 NAS679A4W KAYNAR NUT 5 2 AN3-10A BOLT, 10-32, 0.625 GRIP, UNDRILLED, STEEL 2 3A08613-001 PLASTIC TUBE 8 NAS1149F0316P WASHER, I.D. 13/64", O.D. 7/16" 4 NAS679A3W KAYNAR NUT 6 2 3A08702-006 PIN PIVOT 2 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL 2 NAS679A3W KAYNAR NUT 7 1 4A08506-002 SWIVEL 8 1 MS24665-285 PIN – COTTER 9 1 3A3-1115-2 PLACARD – DOWN 1 3A3-1115-3 PLACARD – UP 1 3A3-1115-1 PLACARD – WATER RUDDER CONTROL PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 70 P/N 1002168 STEERING AND RETRACT SYSTEM P/N 1002168 Page 71 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A08000-128 ASS’Y – RETRACT HANDLE (SEE DETAIL) 4 AN526-1032R8 SCREW - ATTACH 4 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 2 1 3A08151-046 PULLEY BRACKET 4 AN526-1032R8 SCREW – ATTACH 4 NAS1149D0316J WASHER, 0.203 ID, 0.016 THK, ALUMINUM 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 3 1 MS20219-2 PULLEY 1 AN4-7A BOLT, 1/4-28, 0.4375 GRIP, UNDRILLED, STEEL 2 NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM 1 MS21044N4 NUT 4 3 21A08000-125 ASS’Y – PULLEY BRACKET 1 21A08008-150 BRACKET 1 21A08230-002 SPACER - BLOCK 1 MS20219-2 PULLEY 1 AN4-7A BOLT, 1/4-28, 0.4375 GRIP, UNDRILLED, STEEL 1 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 1 MS21083N4 NUT, LOCKING, LOW HEIGHT, 1/4-28 UNF 1 NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM 5 6 AN42B4A EYE BOLT 6 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 6 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 6 3 AN3-17A BOLT 3 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 7 1 21A08359-201 EXTENSION – RUDDER HORN 2 AN3-6A BOLT – ATTACH 2 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 8 2 21A08525-005 SPRING 9 3 MS21251B3S TURNBUCKLE – BARREL 3 MS21252-3RS FORK – TERMINAL 3 MS20392-2-1 PIN ATTACH 3 MS24665-132 PIN – COTTER 3 NAS1149D0316J WASHER, 0.203 ID, 0.016 THK, ALUMINUM 10 10 AN100-3 THIMBLE – CABLE 10 18-2-G NICOPRESS – CLAMP 11 5 MS20115-3 SHACKLE 5 MS20392-2-11 PIN – ATTACH 5 MS24665-132 PIN – COTTER PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 72 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 12 A/R 3/32 7X 7 S.S. CABLE (REQUEST LENGTH) 13 1 MS21251B3S BARREL 1 MS21252-3RS FORK 14 2 MS20115-3 SHACKLE 1 MS20392-2-19 PIN – CLEVIS P/N 1002168 Page 73 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 8 LANDING GEAR CONTENTS NOSE GEAR RETRACTION ASSEMBLY .....................................................................................................74 NOSE GEAR LOWER ASSEMBLY ................................................................................................................76 NOSE WHEEL ASSEMBLY (GROVE ONLY) ................................................................................................78 NOSE WHEEL ASSEMBLY (PARKER ONLY) ..............................................................................................80 MAIN GEAR RETRACTION INSTALLATION ................................................................................................82 MAIN GEAR WHEEL (GROVE / WIPAIRE ASSEMBLY) ..............................................................................85 MAIN GEAR WHEEL (CLEVELAND / PARKER ASSEMBLY) .....................................................................87 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 74 P/N 1002168 NOSE GEAR RETRACTION ASSEMBLY P/N 1002168 Page 75 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1002571 CYLINDER, NOSE GEAR, 2350 2 1 21A07032-005 LINK - TROLLEY, NOSE GEAR 3 1 21A07094-002 END - ROD, CYLINDER, NOSE GEAR 4 1 21A07187-009 TROLLEY - NOSE GEAR 5 1 21A07237-002 END CAP, NOSE BOX 6 1 21A07323-001 BOX, NOSE GEAR 7 1 21A07349-003 END, NOSE GEAR TRACK LEFT 8 1 21A07349-004 END, NOSE GEAR TRACK, RIGHT 9 1 21A07359-194 EXTRUSION, ANGLE 10 1 21A07509-007 AXLE, TROLLEY LINK 11 1 30A07567-011 GASKET, COVER, NOSE BOX 12 2 34A07509-008 AXLE, TROLLEY 13 2 3A07530-001 BEARING - TROLLEY, NOSE GEAR 14 4 3A07604-001 BLOCK, SLIDE, TROLLEY, NOSE GEAR 15 2 5100-46-H SNAP RING 16 1 8A01008-080 COVER, BULKHEAD HYD CYL. HOLE 17 1 AN316-5R NUT 18 2 AN4-53A BOLT 19 4 AN4-5A BOLT 20 2 AN4-6A BOLT 21 4 AN526-1032R4 SCREW, MACHINE, TRUSS HEAD 22 1 AN816-4D NIPPLE, FLARED TUBE AND PIPE THREAD 23 1 MS20822-4D ELBOW 24 6 MS21044N4 NUT 25 4 MS35333-39 STAR WASHER 26 8 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 27 8 NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM 28 2 NAS679-A4W KAYNAR NUT 29 8 AN4-5A BOLT 16 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 8 MS21044N4 NUT 30 2 3A07005-178 CLIP, SWITCH, NOSE & MAIN PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 76 P/N 1002168 NOSE GEAR LOWER ASSEMBLY P/N 1002168 Page 77 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1095K41 COMMON GREASEZERK 2 1 21A06000-020 WELDMENT, PIVOT SHAFT, FORK, NOSE GEAR 3 1 21A06020-001 FORK, NOSE GEAR 4 1 21A06160-053 PRESSURE PLATE 5 1 21A06194-005 BLOCK - SPRING 6 1 21A06213-006 TOW HOOK NOSE GEAR 7 1 21A06237-001 BEARING PLATE, LOWER, NOSE GEAR 8 1 21A06318-005 BLOCK - PIVOT, NOSE GEAR 9 1 21A06475-006 FRICTION CUP 10 1 21A06476-003 PIN, ANTIROTATION 11 1 21A06605-002 PLUNGER- NOSE WHEEL 12 1 21A06653-001 SPRING NOSE GEAR 13 1 21A06705-005 PRESSURE SPRING 14 1 30A06702-016 BOLT - MODIFIED, PIVOT BLOCK 15 1 3A06602-001 THRUST WASHER 16 1 9528K15 1/4" CHROME BALL BEARING 17 4 AN4-7A BOLT, 1/4-28, 0.4375 GRIP, UNDRILLED, STEEL 18 2 AN5-14A BOLT 19 2 AN5-16A BOLT 20 1 AN6227-9 O-RING 21 1 M62-350 SPRING 22 1 MS16997-60 SOCKET HEAD CAP SCREW 23 5 MS21044N4 NUT 24 4 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF 25 4 MS35333-39 STAR WASHER 26 1 MS35649-2252 NUT 27 2 NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM 28 8 NAS1149F0463P WASHER, 0.265 ID, 0.063 THK, STEEL 29 4 NAS1149F0532P WASHER, 0.328 ID, 0.032 THK, STEEL 30 4 NAS1149F0563P WASHER 31 4 NAS1352-316P SOCKET HEAD CAP SCREW PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 78 P/N 1002168 NOSE WHEEL ASSEMBLY (GROVE ONLY) P/N 1002168 Page 79 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1005927 BOLT, AXLE, NOSE GEAR 2 2 1005929 SPACER 3 1 1005931 ASSEMBLY, NOSE WHEEL 3.1 1 49-12AF-001 ASSEMBLY, WHEEL, GROVE 3.1.1 1 010-019 GREASE RETAINER 3.1.2 2 471570 SEAL, TIMKEN (EQUIVALENT TO GROVE OEM P/N 010-026) 3.1.3 1 015-020A WHEEL HALF INNER 3.1.4 1 016-020AF WHEEL HALF OUTER 3.1.5 2 A4050 BEARING CORE 3.1.6 2 A4138 BEARING CONE 3.1.7 3 AN4-23A BOLT 3.1.8 3 MS21044N-4 NUT 3.1.9 2 MS28775-029 O-RING 3.1.10 6 NAS1149F0416 WASHER 3.2 1 XA1AA* INNER TUBE, 2.80 X 4 3.3 1 AD1A2* TIRE, 2.50 / 2.80 - 4 4 1 1095K41 COMMON GREASE ZERK 5 1 3A06702-003 MODIFIED WASHER 6 1 MS21083N8 NUT 7 1 NAS1149D0863J WASHER 8 1 21A06476-003 PIN ANTI ROTATE AXEL * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 80 P/N 1002168 NOSE WHEEL ASSEMBLY (PARKER ONLY) P/N 1002168 Page 81 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1095K41 COMMON GREASEZERK 2 2 3A06259-001 SPACER 3 1 3A06702-002 MODIFIED BOLT 4 1 3A06702-003 MODIFIED WASHER 5 1 21A06000-021 NOSE WHEEL ASSEMBLY 5.1 1 D-30380 PARKER WHEEL ASSEMBLY 5.1.1 1 068-30373 GASKET 5.1.2 2 161-30382 WHEEL HALF 5.1.3 3 AN4-7A BOLT, 1/4-28, 0.4375 GRIP, UNDRILLED, STEEL 5.1.4 3 MS21044N4 NUT 5.1.5 6 NAS1149F0432P WASHER 5.2 1 XA1AA* INNER TUBE, 2.80 X 4 5.3 1 AD1A2* TIRE, 2.50 / 2.80 - 4 5.4 2 A4050 BEARING CORE 5.5 2 A4138 BEARING CONE 6 1 MS21083N8 NUT 7 2 NAS1149D0863J WASHER * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 82 P/N 1002168 MAIN GEAR RETRACTION INSTALLATION P/N 1002168 Page 83 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A04000-077 ASS’Y – DRAG LINK L. 1 21A04000-076 ASS’Y – DRAG LINK R. 2 08FDU12 BEARING 2 1 23A04000-113 ASS’Y SHOCK STRUT 1 21A04000-075 ASS’Y – LOWER END 1 21A04585-002 SLEEVE 2 1095K41 ZERK – GREASE 1 21A04000-074 ASS’Y – UPPER END 1 1002088 DUAL BUSHING ASSEMBLY 1 1001101 BUSHING ASSEMBLY 1 21A04503-004 RETAINING PIN 1 MS24665-151 COTTER PIN 2 NAS1149F0416J WASHER 2 NAS1149F0463J WASHER 3 1 21A05114-005 TRACK – MAIN GEAR L. 1 21A05114-006 TRACK – MAIN GEAR R. 1 10DU12 BEARING - UPPER 1 08DU12 BEARING – LOWER 4 1 1002574 CYLINDER 2 MS20822-4D FITTING - ELBOW 5 1 21A05705-002 ROD END 1 AN316-5 JAMB NUT 1 21A05260-005 SPACER 1 MS20002C6 CHAMFERED WASHER (CHAMFERED EDGE GOES AGAINST CYLINDER) 6 1 21A05000-017 ARM – RETRACT L. 1 21A05000-016 ARM – RETRACT R. 7 1 21A04454-006 AXLE – SHOCK STRUT 8 1 21A05000-022 INDICTATOR ASS’Y 9 1 21A05000-018 GEAR ACTUATOR 10 2 21A05520-003 ROLLER – TRACK 11 2 93783A033 WASHER – SEALING 12 1 21A05000-019 BOLT – ASSEMBLY 13 1 21A04263-007 RETAINER - GREASE 2 MS28775-210 “O” RING 1 1095K41 ZERK – GREASE 14 1 MS21044N8 NUT 2 NAS1149F0863P WASHER 15 1 MS21083N5 NUT, LOCKING, LOW HEIGHT, 5/16-24 UNF A/R NAS1149F0563P WASHER 16 1 AN5-11A BOLT, 5/16-24, 0.6875 GRIP, UNDRILLED, STEEL PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 84 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 2 NAS1149F0563P WASHER 1 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF 17 2 AN4-13A BOLT 4 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 2 MS21044N4 NUT 18 8 AN3-6A BOLT – TRACK ATTACH 8 NAS1149D0316J WASHER, 0.203 ID, 0.016 THK, ALUMINUM 8 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 8 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 19 1 AN8-33A BOLT 1 NAS1149F0832P WASHER 1 NAS1149F0863P WASHER 1 MS21044N8 NUT 20 1 21A05003-079 PLATE - SEPARATING 4 AN3-5A BOLT 8 NAS1149D0316J WASHER, 0.203 ID, 0.016 THK, ALUMINUM 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF P/N 1002168 Page 85 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES MAIN GEAR WHEEL (GROVE / WIPAIRE ASSEMBLY) PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 86 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 1002144 ASS’Y – WHEEL AND BRAKE (COMPLETE) INCLUDES ALL ITEMS BELOW EXCEPT TIRE & TUBE 2 1 3A04620-001 GASKET - TEFLON 3 1 010-009 GREASE RETAINER 4 1 018-002 BRAKE DISC 5 3 AN4-23A BOLT 6 3 NAS1149F0432P WASHER 7 3 MS21044N4 NUT 8 2 08125 BEARING RACE, NON-CHROME 9 2 08231 BEARING CUP, NON-CHROME 10 2 473237 SEAL - INSIDE/OUTSIDE *DRILL #50 HOLE IN SIDE OF SEAL TO BE USED IN OUTBOARD SIDE OF WHEEL. 11 1 AA1D4* TIRE –TYPE III 5.00 X 5-6 12 1 XA1AC* TUBE 5.00 13 1 32-3 BRAKE ASSEMBLY 2 017-003 PISTON 2 MS28775-217 O-RING 14 1 220-0063 BLEEDER ASSEMBLY 1 MS20823-3D FITTING 45˚ BRAKE LINE 15 2 013-001 TORQUE PIN 2 MS21044N4 NUT 16 1 10-3 BACK PLATE ASSEMBLY 1 066-111 BRAKE PAD 3 066-001 RIVET 17 1 11-2 PRESSURE PLATE ASSEMBLY 1 066-111 LINING 3 066-001 RIVET 18 1 020-001 BRAKE TORQUE PLATE ASSEMBLY 19 3 AN4H-15A BOLT 3 NAS1149F0432P WASHER 20 1 3A04093-001 SPACER 21 1 3A04268-003 NUT – AXLE 22 1 MS24665-351 COTTER PIN 23 1 015-002 WHEEL HALF-INNER (HALVES NOT SOLD SEPERATELY) 1 016-002 WHEEL HALF-OUTER (HALVES NOT SOLD SEPERATELY) * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. P/N 1002168 Page 87 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES MAIN GEAR WHEEL (CLEVELAND / PARKER ASSEMBLY) PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 88 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 3A04000-002 ASS’Y – WHEEL (W/ TUBE & TIRE) 1 3A04000-060 ASS’Y 2 1 3A04620-001 GASKET - TEFLON 3 1 3A04616-001 GREASE RETAINER 4 1 164-01700 BRAKE DISC 5 3 AN4-22A BOLT 6 3 NAS1149F0432P WASHER 7 3 MS21044N4 NUT 8 2 8231 BEARING CUP 2 8231CP BEARING CUP, CHROME (OPT.) 9 2 8125 BEARING CONE 2 8125CP BEARING CONE, CHROME (OPT.) 10 2 473237 SEAL - INSIDE/OUTSIDE 11 1 AA1D4* TIRE –TYPE III 1 XA1AC* TUBE 12 2 3A04000-052 ASS’Y – BRAKE AND TORQUE PLATE 13 2 030-00903 ASS’Y – CALIPER 2 062-00300 PISTON 2 AN6227-23 “O” RING 2 MS20823-3D FITTING - 45 DEGREES (BRAKE LINE) 14 2 081-30619 SEAT – BLEEDER 2 79-3 SCREW – BLEEDER 2 183-1 CAP – BLEEDER 15 4 069-00400 ANCHOR BOLT 4 NAS1149F0463P WASHER, 0.265 ID, 0.063 THK, STEEL 4 MS21044N4 NUT 16 2 074-02700 ASS’Y – BACK PLATE 2 064-00500 PLATE – BACK 2 066-10600 LINING 6 105-2 RIVET 17 2 073-04800 ASS’Y – PRESSURE PLATE 2 063-00500 PLATE - PRESSURE 2 066-10600 LINING 6 105-2 RIVET 18 1 23A04000-109 BRAKE TORQUE PLATE - LEFT 1 23A04000-110 BRAKE TORQUE PLATE – RIGHT 19 4 AN4H15A BOLT 4 NAS1149F0432P WASHER 20 1 3A04093-001 SPACER 21 1 3A04268-003 NUT – AXLE 22 1 MS24665-351 COTTER PIN * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. P/N 1002168 Page 89 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 9 STRUTS, WIRES, STEPS, & SPREADER BARS CONTENTS STRUTS, WIRES, STEPS & SPREADER BARS .........................................................................................90 SPREADER BAR PANEL FWD ASSEMBLY AMPHIBIAN ONLY ................................................................93 SPREADER BAR PANEL FWD ASSEMBLY SEAPLANE ONLY .................................................................94 SPREADER BAR PANEL AFT ASSEMBLY...................................................................................................95 MOUNTING SPREADER BAR TUBE ............................................................................................................96 VENTRAL FIN & FUSELAGE STEPS INSTALLATION ................................................................................97 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 90 P/N 1002168 STRUTS, WIRES, STEPS & SPREADER BARS P/N 1002168 Page 91 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 2 23A02000-174 ASS’Y – FRONT STRUT 1 23A02053-010 FITTING - UPPER 4 AN5-16A BOLT – FITTING ATTACH 8 NAS1149F0563P WASHER 4 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF 1 21A02334-020 STRUT – BLANK WITH BUSHINGS 4 NAS1149F0532P WASHER, 0.328 ID, 0.032 THK, STEEL 2 2 23A02000-230 ASS’Y - STRUT – CENTER WITH BUSHINGS 3 2 21A02000-161 ASS’Y – STRUT – REAR WITH BUSHINGS 4 2 1002111 ASS’Y – DRAG WIRE – FWD 2 SP4ZF6 CLEVIS - PIN 2 SP90C5 PIN – COTTER 1 AN665-46LS * TERMINAL CLEVIS “L” 1 AN665-46RS * TERMINAL CLEVIS “R” 1 AN316C5L CHECK NUT “L” 1 AN316C5R CHECK NUT “R” 5 2 21A02000-137 ASS’Y – DRAG WIRE – AFT 2 SP4ZF6 PIN - CLEVIS 2 SP90C5 PIN – COTTER 1 AN665-46LS * TERMINAL CLEVIS “L” 1 AN665-46RS * TERMINAL CLEVIS ”R” 1 AN316C5L CHECK NUT “L” 1 AN316C5R CHECK NUT “R” 6 2 21A02062-009 FITTING – LOWER FRONT STRUT 7 1 21A02000-141 ASS’Y - FITTING – UPPER FRONT STRUT L. 1 21A02000-142 ASS’Y – FITTING – UPPER FRONT STRUT R. 8 2 21A02062-010 FITTING – LOWER AFT STRUT 9 1 23A02000-219 ASS’Y – MAIN FUSELAGE FITTING L. 1 23A02000-222 ASS’Y – MAIN FUSELAGE FITTING R. 10 2 21A02462-005 WIRE PULL LOWER FWD 11 2 21A02519-007 WIRE PULL LOWER AFT 12 4 21A03032-006 BLOCK – DECK FITTING 13 4 21A03214-003 SPACER 14 4 21A03154-008 SPACER – BEARING 15 4 21A03115-001 TUBE – SPREADER BAR MOUNT 16 2 21A03356-047 SPREADER BAR 17 2 AN45-12A EYEBOLT 18 2 AN6-31A BOLT, SHOULDER, GEAR ACTUATOR, 1450 19 2 AN6-17A BOLT, 3/8-24, 1.3125 GRIP, UNDRILLED, STEEL 20 4 AN5-16A BOLT 21 4 AN6-17A BOLT, 3/8-24, 1.3125 GRIP, UNDRILLED, STEEL PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 92 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 22 4 AN6-42A BOLT, STEEL, 3/8-24 THREAD, GRIP 3.688", CAD 2 PLATING 23 4 AN6-26A BOLT SIZE 3/8-24, LENGTH 1/64 - 2-53/64, GRIP LENGTH 2-3/16 24 8 AN5-24A BOLT, 5/16-24 THREAD, 2-1/16" GRIP, 2-19/32" LENGTH 25 2 AN6-35A BOLT, 3/8-24 THREAD, 3-1/16" GRIP, 3-45/64 LENGTH 26 4 21A02095-003 BUSHING 27 10 AN4-6A BOLT, 1/4-28, 0.3125 GRIP, UNDRILLED, STEEL 28 2 AN7-13A BOLT, 7/16-20, 0.8125 GRIP, UNDRILLED, STEEL 29 2 21A02010-018 COVER – GEAR OPENING 30 A/R NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM 31 10 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 32 A/R NAS1149D0563J WASHER, 0.328 ID, 0.063 THK, ALUMINUM 33 6 MS21044N5 NUT, LOCKING, REGULAR HEIGHT, 5/16-24 UNF 34 A/R NAS1149D0663J WASHER, 0.39 ID, 0.063 THK, ALUMINUM 35 18 MS21044N6 NUT, LOCKING, REGULAR HEIGHT, 3/8-24 UNF 36 A/R NAS1149D0763J WASHER, 0.453 ID, 0.063 THK, ALUMINUM 37 2 MS210365-720A NUT * DENOTES STAINLESS STEEL P/N 1002168 Page 93 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-260 SPREADER BAR PANEL FWD ASSY. 1 1 21A01163-065 PANEL, SUPPORT, SPREADER BAR 2 1 21A01326-007 ANGLE SUPPORT, LH, BULKHEAD #5 3 1 21A01326-008 ANGLE SUPPORT, RH, BULKHEAD #5 SPREADER BAR PANEL FWD ASSEMBLY AMPHIBIAN ONLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 94 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 23A01000-302 ASSY, SPREADER BAR PANEL, FWD 1 1 21A01163-065 PANEL, SUPPORT, SPREADER BAR 2 1 23A01326-018 ANGLE, RH, SPREADER BAR PANEL, FWD 3 1 23A01326-019 ANGLE, LH, SPREADER BAR PANEL, FWD 4 2 AN4-5A BOLT, 1/4-28, 0.1875 GRIP, UNDRILLED, STEEL 5 2 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 6 2 NAS1149F0463P WASHER, 0.265 ID, 0.063 THK, STEEL SPREADER BAR PANEL FWD ASSEMBLY SEAPLANE ONLY P/N 1002168 Page 95 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION - 1 21A01000-259 SPREADER BAR PANEL AFT ASSY 1 1 21A01163-065 PANEL, SUPPORT, SPREADER BAR 2 1 21A01326-009 ANGLE, SIDE BAR, SHORT 3 1 21A01326-010 ANGLE, SIDE BAR, SHORT 4 2 AN4-5A BOLT, 1/4-28, 0.1875 GRIP, UNDRILLED, STEEL 5 2 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 6 2 NAS1149F0463P WASHER, 0.265 ID, 0.063 THK, STEEL SPREADER BAR PANEL AFT ASSEMBLY PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 96 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 21A03115-001 TUBE, SPREADER BAR, MOUNTING 2 3 AN4-22A BOLT, 1/4-28, 1.8125 GRIP, UNDRILLED, STEEL 3 3 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 4 1 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 5 7 NAS1149D0463J WASHER, 0.265 ID, 0.063 THK, ALUMINUM MOUNTING SPREADER BAR TUBE P/N 1002168 Page 97 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES VENTRAL FIN & FUSELAGE STEPS INSTALLATION PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 98 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 21A12000-042 VENTRAL FIN (172) 2 24 AN526-832R8 SCREW, MACHINE, TRUSS HEAD 3 14 MS21047L08 NUTPLATE 4 10 MS27130A13 RIVNUT 5 10 MS35333-38 STAR WASHER 6 14 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 7 10 NAS1149FN832P WASHER, 0.174 ID, 0.032 THK, STEEL 8 2 21A02369-035 STEP – L. & R. 4 AN3-20A BOLT, 10-32, 1.625 GRIP, UNDRILLED, STEEL 2 AN3-24A BOLT, 10-32 THREAD, 2-1/8" GRIP, 2-17/32" LENGTH 12 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 6 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 6 BFP HOLE PLUG 4 6A02273-006 SPACER – FRONT STRUT P/N 1002168 Page 99 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 10 HYDRAULIC SYSTEM CONTENTS HYDRAULIC SYSTEM INSTALLATION POST SERVICE LETTER 228...................................................100 HYDRAULIC SYSTEM INSTALLATION PRE SERVICE LETTER 228 .....................................................103 HYDRAULIC PUMP ASSEMBLY POST SERVICE LETTER 228 ..............................................................106 HYDRAULIC PUMP ASSEMBLY PRE SERVICE LETTER 228 ................................................................ 110 HYDRAULIC PUMP OVERVIEW POST SERVICE LETTER 228.............................................................. 113 HYDRAULIC PUMP OVERVIEW PRE SERVICE LETTER 228 ................................................................ 115 HYDRAULIC SCHEMATIC ...........................................................................................................................117 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 100 P/N 1002168 HYDRAULIC SYSTEM INSTALLATION POST SERVICE LETTER 228 P/N 1002168 Page 101 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 1011849 ASSEMBLY, HYDRAULIC POWER PACK, 12V 1 1011850 ASSEMBLY, HYDRAULIC POWER PACK, 24V 1 1011851 SPACER, INSTALLATION, HYDRAULIC POWER PACK 2 2 AN3-3A (TOP BRACKET) BOLT, 10-32, 0.063 GRIP, UNDRILLED, STEEL 4 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 3 2 AN4-6A (BOTTOM BRACKET) BOLT, 1/4-28, 0.313 GRIP, STEEL 4 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL 2 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 4 1 21A09348-020 ANGLE, LOWER PUMP ATTACH 4 AN3-4A BOLT, 10-32, 0.125 GRIP, UNDRILLED, STEEL 4 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 5 1 21A09000-240 ASSEMBLY, MANIFOLD 1 6A09046-001 MANIFOLD 2 AN3-5A BOLT, 10-32, 0.25 GRIP, UNDRILLED, STEEL 4 AN816-4D FITTING, NIPPLE, FLARED TUBE AND PIPE THREAD 4 AN816-4-4D FITTING, NIPPLE, FLARED TUBE AND PIPE THREAD 2 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 6 3 AN832-4D UNION, BULKHEAD, FLARED TUBE 3 NAS1149F0763P WASHER, 0.453 ID, 0.063 THK, STEEL 3 AN924-4D NUT, TUBE, 7/16-20 THREAD 7 1 21A11158-194 COVER, SQUARE GEAR CONTROL HEAD 4 MS35214-42 GEAR CONTROL HEAD MOUNTING SCREW, 8-32, 0.50 LENGTH 8 1 21A09000-194 ASSEMBLY, EMERGENCY HAND PUMP 9 3 AN3-4A (MOUNTING HARDWARE) BOLT, 10-32, 0.125 GRIP, STEEL 3 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 3 AN970-3 WASHER, 0.203 ID, 0.875 OD, .063 THK, STEEL 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 10 1 642873 HAND PUMP (ONLY) 11 1 12A3-7379-1 PLACARD, EMERGENCY HAND PUMP 12 1 21A09156-129 BRACKET, PUMP ATTACH 13 1 21A09396-001 HANDLE 1 9283K13 CAP PLUG 14 1 21A09746-001 UNION 1 MS28775-012 O-RING, HYDRAULIC PACKING, 0.364 ID 15 1 AN814-4D PLUG, 7/16-20 THREAD 1 MS28775-012 O-RING, HYDRAULIC PACKING, 0.364 ID 16 1 AN815-4D UNION 1 MS28775-012 O-RING, HYDRAULIC PACKING, 0.364 ID PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 102 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 17 1 AN919-6D UNION 1 MS28775-014 O-RING, HYDRAULIC PACKING, 0.489 ID 18 2 MS16997-77 SOCKET HEAD CAP SCREW, 5/16-18 THREAD 2 MS35333-41 LOCK WASHER, INTERNAL TOOTH 2 NAS1149F0563P WASHER, 0.328 ID, 0.063 THK, STEEL 19 1 MS35489-49 GROMMET 20 2 21A04000-080 ASSEMBLY, BRAKE LINE (NOT SHOWN) 2 63-190600-3 FITTING, AERO QUIP HOSE #3 P/N 1002168 Page 103 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES HYDRAULIC SYSTEM INSTALLATION PRE SERVICE LETTER 228 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 104 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 21A09000-239 ASS’Y - PUMP 12V 1 21A09000-283 ASS’Y – PUMP 24V 2 1 21A09000-240 ASS’Y – MANIFOLD 1 6A09046-001 MANIFOLD 4 AN816-4-4D NIPPLE – FITTING 2 AN3-5A BOLT - ATTACH 2 NAS1149F0363P WASHER 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 4 AN816-4D NIPPLE FITTING 3 3 AN832-4D UNION - FIREWALL 3 NAS1149F0763P WASHER 3 AN924-4D NUT 4 2 AN3-4A BOLT - TOP BRACKET ATTACH 4 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 5 1 21A09348-020 ANGLE – LOWER PUMP ATTACH 4 AN3-4A BOLT 4 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 6 1 21A09000-194 ASS’Y – HAND PUMP 7 1 21A12000-052 ASS’Y – SELECTOR HANDLE 1 12A3-7379-1 PLACARD 8 3 AN3-4A BOLT – ATTACH 3 AN970-3 WASHER 3 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 9 1 MS35489-49 GROMMET 10 1 21A09396-001 HANDLE - PUMP 11 1 642873 HAND PUMP (ONLY) 12 1 21A09156-129 BRACKET – PUMP ATTACH 13 1 AN814-4D PLUG 1 MS28775-012 “O” RING 14 1 21A09746-001 UNION 1 MS28775-012 “O” RING 15 1 AN815-4D UNION 1 MS28775-012 “O” RING 16 1 AN919-6D UNION 1 MS28775-014 “O” RING 17 1 9283K13 CAP PLUG 18 2 5/16-18 UNC-28 X .63 CAP SCREW – ATTACH 2 MS35333-40 LOCK WASHER P/N 1002168 Page 105 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 2 NAS1149F0563P WASHER 19 2 21A04000-080 ASS’Y – BRAKE LINE (NOT SHOWN) 2 63-190600-3 FITTING PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 106 P/N 1002168 HYDRAULIC PUMP ASSEMBLY POST SERVICE LETTER 228 P/N 1002168 Page 107 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 108 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 1011849 ASSEMBLY, HYDRAULIC POWER PACK, 12V - 1 1011850 ASSEMBLY, HYDRAULIC POWER PACK, 24V 1 1 1009428 ASSEMBLY, SENSOR, FLUID LEVEL 1 93786A200 PRESSURE SEALING WSHER, M12 2 2 1011062 ASSEMBLY, PLUG, PRESSURE SWITCH PORT 3 1 1011842 ANGLE, MOUNTING HYDRAULIC PUMP 2 MS16997-96 SOCKET HEAD CAP SCREW, 3/8-16 THREAD 2 MS35338-46 WASHER, SPLIT 4 1 1011845 ASSEMBLY, SUPPORT PLATE, HYDRAULIC POWER PACK, 12V 1 1011846 ASSEMBLY, SUPPORT PLATE, HYDRAULIC POWER PACK, 24V 4.1 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 4 02-09-1104 PIN, CRIMP FEMALE, 1/8" DIA 4.2 1 1005042 TIMER RELAY HARNESS, 12VDC 1 1005043 TIMER RELAY HARNESS, 24VDC 4.3 1 1009143-01 PLACARD, K1 INDICATOR 1 1009143-02 PLACARD, K2 INDICATOR 1 1009143-03 PLACARD, K3 INDICATOR 4.4 1 1009144-01 PLACARD, CR INDICATOR 4.5 1 1009144-02 PLACARD, AC INDICATOR 4.6 1 1011798 ASSEMBLY, CAPACITOR 1 MS21919WDG10 CLAMP, LOOP, CUSHIONED, 5/8" TUBE OD 1 AN3-3A BOLT, 10-32, 0.063 GRIP, UNDRILLED, STEEL 1 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 1 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 4.7 1 1011843 TOP PLATE, HYDRAULIC PUMP 4.8 1 1011844 ELECTRONIC SIDE PLATE 4.9 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 3 66103-4 PIN, CRIMP SOCKET, 24-20 AWG 1 206062-3 CLAMP, CABLE, CPC SIZE 11 4.10 1 206430-2 PLUG, FEMALE, CPC SIZE 1, 4 PIN 3 66105-4 CRIMP SOCKET, FEMALE 1 206062-3 CLAMP, CABLE, CPC SIZE 11 4.11 1 3453LF2A FUSE HOLDER 1 AGC-1 FUSE, 250V, 1 AMP 4.12 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 2 AN526C632R8 SCREW, MACHINE, TRUSS HEAD, 6-32 THREAD 2 MS21044N06 NUT LOCKING, REGULAR HEIGHT, 6-32 UNC 12 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 3 1N4004 DIODE 4.13 1 73F-250-32-NL CONNECTOR, FEMALE, 10-12 AWG, FULLY INSULATED 4.14 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG, FULLY INSULATED P/N 1002168 Page 109 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 4.15 3 BR05-FW SOCKET, 5 PRING, PLASTIC 14 1-901-355-917 TERMINAL 3 AN3-3A BOLT, 10-32, 0.063 GRIP, UNDRILLED, STEEL 6 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNC 4.16 1 MS35489-9 GROMMET, RUBBER (NOT SHOWN) 4.17 1 MS35489-14 GROMMET, RUBBER 4.18 3 V23234- A0001-X032 RELAY, PRONG, 12V 3 0-332-209-211 RELAY, 5 PRONG, 24V 5 1 1011847 ASSEMBLY, HYDRAULIC RESERVOIR 5.1 1 1011848 PLACARD, OIL LEVEL 5.2 1 1EJT7 BREATHER VENT 5.3 1 AN816-4D NIPPLE, FLARED TUBE AND PIPE THREAD 5.4 2 LSP151-04-01 LIQUID LEVEL SIGHT PLUG 6 1 20PS001EB 700W50OW PRESSURE SWITCH 2 03-09-2022 CONNECTOR, PLUG, FEMALE 4 02-09-2118 PIN, CRIMP MALE, 1/8" DIA. 7 4 AN3-16A BOLT, 10-32, 1.375 GRIP, UNDRILLED, STEEL 8 2 AN919-3D FITTING, REDUCER 2 MS28775-013 O-RING, HYDRAULIC 9 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 10 2 MS25036-157 RING TERMINAL, 1/4 STUD, 10-12 AWG, YELLOW 11 2 NAS1149F0332P WASHER, 0.203 ID., 0.032 THK, STEEL 12 5 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 13 2 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL 14 1 YBZS- C0.63W1T100K/ UVZOT2 HYDRAULIC PUMP, 12VDC 1 YBZS- C0.63W2T100K/ UVZOT2 HYDRAULIC PUMP, 24VDC PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 110 P/N 1002168 HYDRAULIC PUMP ASSEMBLY PRE SERVICE LETTER 228 P/N 1002168 Page 111 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 3 0-332-209-137 RELAY, 12V, 5 PRONG 3 0-332-209-211 RELAY. 24V, 5 PRONG 2 4 02-09-1104 PIN, CRIMP FEMALE, 1/8" DIA 3 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 4 14 1-901-355-917 TERMINAL 5 1 1004949 CABLE, DIODE ADAPTOR 6 1 1005042 TIMER RELAY HARNESS 7 3 1N4004 DIODE, 2-1/2” 8 2 206062-3 CLAMP, CABLE, CPC SIZE 11 9 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 10 1 206430-2 CPC FREE HANG, 4 PIN, FEMALE 11 1 21A09000-215 ASSEMBLY, HYDRAULIC PUMP, 12V 1 21A09000-282 ASSEMBLY, HYDRAULIC PUMP, 24V 12 1 21A09005-264 SUPPORT, HYD. PUMP ATTCH PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 112 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 13 1 21A09352-030 ANGLE, MOUNTING, HYD. PUMP 14 6 FT 22759-16-12-9 WIRE, 12 AWG, WHITE 15 10.1 FT 22759-16-20-9 WIRE, 20 AWG, WHITE 16 1 73F-250-32-NL CONNECTOR, FEMALE, 10-12 AWG 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG 17 1 3453LF2A FUSE HOLDER 18 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 19 3 66103-4 PIN, CRIMP SOCKET, 24-20G 20 3 66105-4 CRIMP SOCKET, FEMALE 21 1 AGC-1 FUSE, 250V, (S2565-1) 22 3 AN3-3A BOLT 23 2 AN526-632R8 SCREW, MACHINE, TRUSS HEAD 24 3 BR05FW SOCKET, 5 PRONG, PLASTIC 25 1.5 FT HS105-3/16-0 HEAT SHRINK, TUBING, BLACK 26 2 MS16997-96 SOCKET HEAD CAP SCREW 27 2 MS21044N06 NUT 28 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 29 2 MS35338-46 WASHER, SPLIT 30 1 MS35489-14 GROMMET, RUBBER 31 4 NAS1149D0363J WASHER, 0.203 ID, 0.063 THK, ALUMINUM 32 6 NAS1149F0332P WASHER P/N 1002168 Page 113 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES HYDRAULIC PUMP OVERVIEW POST SERVICE LETTER 228 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 114 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 202-0003 BI-DIRECTIONAL PUMP, 0.64 ML/R 2 1 299-0008 SEAL KIT, BI-DIRECTIONAL GEAR PUMP 3.1 1 610-0010 DC MOTOR, 12V, .8KW 3.2 1 610-0017 DC MOTOR, 24V, .8KW 4 2 631-0005 PRESSURE RELIEF VALVE 5 2 631-0006 THERMAL RELIEF VALVE 6 2 632-0004 ASSEMBLY, PILOT OPERATED CHECK VALVE 7 1 637-0024 SHUTTLE VALVE 8 1 682-0019 FILTER, PICKUP TUBE, HYDRAULIC PUMP 9 1 682-0055 SUCTION HEX TUBE 10 1 682-0056 RETURN TUBE 11 1 683-0011 COUPLING, MOTOR TO PUMP 12 2 685-0012 SPRING, SHUTTLE VALVE 13 11 687-0001 SEAL KIT, RESERVIOR O-RING, PILOT OPERATED RELIEF VALVE O-RING, THERMAL AND PRESSURE RELIEF VALVE O-RING (NOT SHOWN) P/N 1002168 Page 115 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES HYDRAULIC PUMP OVERVIEW PRE SERVICE LETTER 228 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 116 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 1 21A09000-215 HYDRAULIC PUMP ASS’Y (12V) 1 21A09000-282 HYDRAULIC PUMP ASS’Y (24V) 1 640661 MOTOR (12V) 1 641131 MOTOR (24V) 2 1 634873 BASIC PUMP 3 2 362136 TUBE EXTENSIONS 4 2 410521* FILTER 5 1 410578* SEAL RESERVIOR 6 1 365047 RETURN TUBE 7 1 775260 RESERVIOR – GAUGE ASS’Y 8 1 415067 SEAL THREAD 9 1 409715* SCREW – RESERVIOR ATTACH 10 1 361183* COUPLING – MOTOR TO PUMP 11 1 410512 SEAL – PUMP SHAFT 12 1 405673 “O” RING MOTOR TO BASE *Reference Wipaire drawing 1011065 for alternate part numbers. P/N 1002168 Page 117 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES HYDRAULIC SCHEMATIC PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 118 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION 1 2 21A09000-197 ASSY, HOSE, MAIN PUMP TO MANIFOLD, 18" 2 1 21A09000-201 ASSY, HOSE, LWR RES FITTING TO FW, 18" 3 2 21A09000-200 ASSY, HOSE, FIREWALL TO MANIFOLD, 8" 4 2 21A09000-202 ASSY, HOSE, FIREWALL TO HAND PUMP, 60" 5 1 21A09000-203 ASSY, HOSE, FIREWALL TO HAND PUMP 40" 6 2 21A09000-198 ASSY, HOSE, LH FLOAT TO MANIFOLD 74" 7 2 21A09000-199 ASSY, HOSE RH FLOAT TO MANIFOLD 62" 8 4 21A09000-222 ASSEMBLY, HOSE – TEE TO TOP UP – DN 9 2 23A09000-235 HYD. LINE ASSY. 10 2 23A09000-236 HYD. LINE ASSY. 11 2 23A09000-237 HYD. LINE ASSY. 12 2 23A09000-238 HYD. LINE ASSY. 13 2 21A04000-080 TOP DECK FLOAT TO FUS., BRAKE 2 63-190600-3 FITTING – ENDS 14 2 AN833-3D FITTING – ELBOW 4 NAS1149D0663J WASHER 2 AN924-3D JAM NUT 15 2 21A04000-079 ALUM BRAKE LINE 16 2 21A04000-078 HYD. LINE ASSY. WHEEL WELL BRAKE LINE 17 2 23A04000-118 BRAKE LINE ASS'Y P/N 1002168 Page 119 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES SECTION 11 ELECTRICAL CONTENTS ELECTRICAL SCHEMATIC POST SERVICE LETTER 228 ......................................................................120 ELECTRICAL SCHEMATIC PRE SERVICE LETTER 228 .........................................................................122 GEAR CONTROL (ROUND) .........................................................................................................................124 GEAR CONTROL (RECTANGLE) ................................................................................................................127 GEAR CONTROL (G1000 ONLY).................................................................................................................129 PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 120 P/N 1002168 ELECTRICAL SCHEMATIC POST SERVICE LETTER 228 P/N 1002168 Page 121 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 4 1005724 GEAR POSITION SWITCH, PROXIMITY, 3 WIRE 2 4 1006668 ELECTRIC WATER RUDDER RETRACT SOLENOID 3 2 4-140 TERMINAL BLOCK, 4 POSITION 4 1 4A11000-012 WIRE HARNESS, GEAR SELECTOR, FLOATS, HYD. PUMP 5 8 5801 GEAR POSITION SWITCH, PROXIMITY, MAGNETIC 6 2 6-140 TERMINAL BLOCK, 6 POSITION 7 1 6A10000-004 WIRE HARNESS, LEFT FLOAT 8 1 6A10000-005 WIRE HARNESS, RIGHT FLOAT 9 1 7277-2-5 CIRCUIT BREAKER, 5 AMP 10 1 73F-250-32-NL CONNECTOR, FEMALE, 12-10 AWG 11 1 73M-250-32-NL CONNECTOR, MALE, 12-10 AWG 12 8 21A09005-262 CLIP, GEAR POSITION SWITCH HOLDER 13 1 MS24523-21 TOGGLE SWITCH, ELECTRIC WATER RUDDER RETRACT 14 8 S1635-1 PIN 15 8 S1636-1 SOCKET 16 8 S1637-1 HOUSING 17 8 S1637-2 HOUSING 18 1 W23-X1A1G-25 CIRCUIT BREAKER, 25 AMP, 24VDC 19 1 W23-X1A1G-40 CIRCUIT BREAKER, 40 AMP, 12VDC PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 122 P/N 1002168 ELECTRICAL SCHEMATIC PRE SERVICE LETTER 228 P/N 1002168 Page 123 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES ITEM QTY PART NO. PART DESCRIPTION 1 1 4A11000-011 ASSY, WIRING HARNESS, GEAR SELECTOR 3 1 4A11000-014 ASSY, WIRING HARNESS, GEAR ADVISORY 4 1 7277-2-2 BREAKER, CIRCUIT, KLIXON, 2AMP 5 1 7277-2-5 BREAKER, CIRCUIT, KLIXON, 5AMP 6 8 S1635-1SF PIN 7 8 S1636-1 SOCKET 8 8 S1637-1 HOUSING 9 8 S1637-2 HOUSING 10 1 W-23- X1A1G-25 BREAKER, CIRCUIT, 25AMP 11 1 W-23-X1A1G-40 BREAKER, CIRCUIT, 40AMP A1 3 0-332-209-211 RELAY 12V A2 3 0-332-209-137 RELAY 24V A3 3 BR05FW' RELAY SOCKET A4 7 1N4004 DIODE A5 1 AGC-1 FUSE 1 AMP A6 1 3453LF2A FUSE HOLDER A7 2 1005042 ASSEMBLY, TIMER RELAY 12V A9 1 1004949 DIODE CABLE ADAPTOR A10 8 5801 SWITCH, 2 WIRE A12 2 4-140 ELECTRICAL TERMINAL, 4 CONNECT A15 1 6A10000-004 HARNESS W'IRE, FLOATS LT A16 1 6A10000-005 HARNESS W'IRE, FLOATS, RT PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 124 P/N 1002168 GEAR CONTROL (ROUND) P/N 1002168 Page 125 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 126 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A11000-009 GEAR SELECTOR ASSY. ROUND (12V) - 1 21A11000-019 GEAR SELECTOR ASSY. ROUND (24V) 1 1 8857K44 SWITCH 2 1 A101SYCB TOGGLE SWITCH, SPDT, ON-ON 3 9 515-0012 SOCKET 4 1 507-3914-1431-600 INDICATOR LAMP, 14V, RED 1 507-3918-1431-600 INDICATOR LAMP, 28V, RED 5 4 507-3914-1432-600 INICATOR LAMP, 14V, GREEN 4 507-3918-1432-600 INICATOR LAMP, 28V, GREEN 6 4 507-3914-1434-600 INDICATOR LAMP, 14V, BLUE 4 507-3918-1434-600 INDICATOR LAMP, 28V, BLUE 7 1 21A11179-001 BLOCK, GEAR CONTROL 8 1 4A11000-008 HARNESS ASSEMBLY, GEAR SELECTOR 9 1 21A11259-003 GEAR SWITCH KNOB 10 1 RH-5-35 RESISTOR, 14V, DALE RH5 5W 1 RH-5-180 RESISTOR, 28V, DALE RH5 5W 11 3 AN526-632R8 SCREW, TRUSS HEAD, 6-32 12 1 10B3-6202 PLACARD, ROUND 2100 GEAR SELECTOR 13 3 R-3 RING CONNECTOR, #6, 20 AWG, RED 14 5 PLT1M-M CABLE TIE 15 16 IN HIXR-3/16 SHRINK WRAP, 3/16, WHITE 16 3 IN HS105-1/2-0 HEAT SHRINK TUBING 17 6 IN 22759-16-20-9 WIRE, 20 AWG, WHITE P/N 1002168 Page 127 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES GEAR CONTROL (RECTANGLE) PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 128 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 21A11000-010 ASSEMBLY, INDICATOR, GEAR CONTROL, SQUARE, 12V - 1 21A11000-018 GEAR SELECTOR ASSY. RECTANGLE (24V) 1 1 10B3-6277 PLACARD, GEAR CONTROL SQUARE 2 1 21A11179-002 BLOCK GEAR CONTROL SQUARE 3 1 21A11259-003 GEAR SWITCH KNOB 4 1 4A11000-008 WIRING HARNESS ASSY. SELECTOR 3 IN HS105-1/2-0 HEAT SHRINK TUBING 5 1 5073914-1431-600 LAMP LIGHT, RED 14V 507-3918-1431-600 INDICATOR LAMP, 28V, RED 6 4 5073914-1432-600 LAMP LIGHT, GREEN 14V 507-3918-1432-600 INICATOR LAMP, 28V, GREEN 7 4 5073914-1434-600 LAMP LIGHT, BLUE, 14V 507-3918-1434-600 INDICATOR LAMP, 28V, BLUE 8 9 515-0012 SOCKET 9 1 8857K44 SWITCH 10 1 A101SYCB TOGGLE SWITCH 11 3 AN526-632R8 SCREW, TRUSS HEAD MACHINE, 6-32 THREAD, 1/2" LENGTH 12 12" HS105-3/32-0 HEAT SHRINK, TUBING - BLACK 13 3 PLT1M-M CABLE TIE, NYLON, WHITE, 4" (SMALL) 14 3 R-3 TERMINAL, RING #6 STUD, 16-22 AWG, RED 15 1 RH-5-35 RESISTOR, 14V, DALE RH5 5W 1 RH-5-180 RESISTOR, 28V, DALE RH5 5W 16 6 IN 22759-16-20-9 WIRE, 20AWG, WHITE (NOT SHOWN) 17 16 IN HIXR-3/16 SHRINK WRAP, 3/16, WHITE (NOT SHOWN) P/N 1002168 Page 129 Revision N PARTS MANUAL 2350 FLOATS ON CESSNA 172 &175 SERIES GEAR CONTROL (G1000 ONLY) PARTS MANUAL 2350 FLOATS ON CESSNA 172 & 175 SERIES Revision N Page 130 P/N 1002168 ITEM QTY PART NO. PART DESCRIPTION - 1 1001431 ASSEMBLY, INDICATOR, GEAR CONTROL, G1000 1 1 4A11000-008 ASSEMBLY, WIRE HARNESS 2 1 21A11259-003 GEAR SWITCH KNOB 3 1 507-3918-1431-600 INDICATOR LAMP, 28V, RED 4 4 507-3918-1432-600 INDICATOR LAMP, 28V, GRN 5 4 507-3918-1434-600 INDICATOR LAMP, 28V, BLU 6 9 515-0012 SOCKET, GEAR SELECTOR LIGHTS 7 1 8857K44 SWITCH, GEAR SELECTOR, 2100/7000 8 1 1001172 BLOCK, GEAR CONTROL, GLASS PANEL 9 1 1001173 PLACARD, GEAR CONTROL, GLASS PANEL 10 1 A101SYCB TOGGLE SWITCH, SPDT, ON ON 11 3 AN526-632R6 SCREW, MACHINE, TRUSS HEAD 12 3 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 13 1 RH005180R0FE02 RESISTOR, 28V