Supplemental Airplane Flight Manual

2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 8. AIRPLANE HANDLING, SERVICE, AND MAINTENANCE 45 INTRODUCTION 45 MOORING 45 BEACHING – HEELING IN 46 SERVICING 47 AMPHIBIOUS LANDING GEAR 47 ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 8 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E This page intentionally left blank. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 9 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 1. GENERAL This supplemental manual, applicable to those Cessna Model 206 Series airplanes equipped with Aerocet Model 3400 Amphibious Seaplane Floats, provides information and limitations not included in the basic FAA approved markings and placards, and/or Airplane Flight Manual. Whenever the words "Not Applicable" (NA) appear in this supplemental manual, they are used to indicate that the related information may not be the same as that shown in the Cessna markings and placards, and/or Flight Manual and are not required by the airplane certification basis and, therefore, should not be referenced. The aircraft is to be operated under the "NORMAL CATEGORY" only. PERFORMANCE – SPECIFICATIONS (for model T206H see Section 5 for additional performance information) SPEED: NA CRUISE: NA RATE OF CLIMB AT SEA LEVEL: EXCEEDS 550 FPM (CAR 3.85a) SERVICE CEILING: NA TAKEOFF PERFORMANCE ON WATER: NA LANDING PERFORMANCE ON WATER: NA TAKEOFF PERFORMANCE ON LAND: Increase take-off roll distance by 10% factored @ 3600 Gross Weight Pounds using Hartzell PHC-C3YF- 1RF/F8468A-6R propeller LANDING PERFORMANCE ON LAND: Increase landing roll distance by 16% factored @ 3600 Gross Weight Pounds STALL SPEED (POWER OFF, FORWARD CG @ 3744 lb.) FLAPS UP: 61 KCAS FLAPS DOWN 30º: 54 KCAS MAXIMUM WEIGHT: RAMP or DOCK: 3755 LBS. TAKE-OFF FLOATS: 3744 LBS. LANDING FLOATS: 3661 LBS. TAKE-OFF WHEELS: 3735 LBS. LANDING WHEELS: 3550 LBS. EMPTY WEIGHT: SEE ACTUAL WT. & BALANCE FORM FOR AIRCRAFT MAXIMUM USEFUL LOAD: REF. ACTUAL WT. & BALANCE FORM FOR A/C ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 10 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E PERFORMANCE – SPECIFICATIONS (Cont’d) BAGGAGE ALLOWANCE: IN AIRPLANE: NO CHANGE IN EACH FLOAT: 100 LBS. (CAUTION: ASSURE CG RANGE IS PROPER WHEN LOADING) WING LOADING: NA POWER LOADING: NA RANGE: NA FUEL CAPACITY: NO CHANGE OIL CAPACITY: NO CHANGE ENGINE: NO CHANGE PROPELLER: One of the following propellers is required. Models A through G: The propeller installation is not covered by this STC and must be FAA approved by a separate FAA approval, (such as TCDS, STC, or 337). • Hartzell PHC-C3YF-1RF/F8468A-6R or greater in approved diameter • Hartzell PHC-C3YF-1RF/F8068-2 (-0 ok) • Hartzell PHC-J3YF-1RF/F8068-2 (-0 ok) • McCauley D3A34C401/90DFA-2 (-4,-8,-10 ok) • McCauley D3A34C402/90DFA-2 (-4,-8,-10 ok) Models H only: • Hartzell HC-F3YR-1RF/F8468A-2R (-4R, -6R ok) i.a.w. Aerocet STC • McCauley B3D36C432/80VSA -1 (not less than 77.5") i.a.w. Cessna TCDS ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 11 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 2. LIMITATIONS CENTER OF GRAVITY LIMITS Center of Gravity Range: (inches aft of reference datum –front face of firewall) (+42.1) to (+47.4) at 3744 lbs. Maximum G.W. (+36.5) to (+47.4) at 2600 lbs. or less with a straight line variation between points given. WEIGHT LIMITS Maximum Ramp or Dock: 3755 lbs. Maximum Take-off Floats: 3744 lbs. Maximum Landing Floats: 3661 lbs. Maximum Take-off Wheels: 3735 lbs. Maximum Landing Wheels: 3550 lbs. Maximum Weight in Baggage Compartment: NO CHANGE Maximum Weight in Float Baggage Compartment: 100 lbs. each AIRSPEED LIMITS KCAS KIAS MPH CAS MPH IAS Never Exceed Speed (Vne) No Change No Change No Change No Change Max Structural Cruising (Vno) No Change No Change No Change No Change Max Maneuvering Speed (Va) No Change No Change No Change No Change Max. Speed with Flaps (Vfe) No Change No Change No Change No Change Max Ldg. Gear Operating Speed (Vlo) 118 120 136 138 Max Ldg. Gear Extended Speed (Vle) 148 150 170 172 TAKEOFF WITH KNOWN HULL LEAK OR STRUCTURAL DAMAGE IS PROHIBITED. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 12 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E MANEUVER LIMITS The maneuver limits defined in the basic handbook are applicable to the amphibian. “Avoid slips with wing flaps extended” FLAP LIMITATIONS Approved Takeoff Range: 0° to 20°. Approved Runway Landing Range: 0° to 30°. Approved Water Landing Range: 0° to 30°. NOTE: Wing flaps must be retracted to 20° immediately following power application for a balked landing go-around. AIR SPEED INDICATOR MARKINGS The airspeed indicator markings are the same as shown in the basic markings/Flight manual. Due to differences in airspeed calibration and speeds with floats installed, the indicated stall speeds and maximum structural cruising speed vary slightly from airspeed indicator markings. PLACARDS 1. Aerocet P/N 35A-59330 Placard is located in plain view of the pilot: “EMERGENCY LANDING GEAR OPERATION If electric driven hydraulic pump fails, use hand operated pump to retract and extend landing gear. Land on sod if gear position is unknown. DO NOT LAND ON WATER UNLESS GEAR IS FULLY RETRACTED” ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 13 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E PLACARDS (Cont’d) 2. Aerocet P/N 36-15605 Placard is located near the emergency gear hand pump: “EMERGENCY HAND PUMP OPERATING INSTRUCTIONS 1. Pull landing gear motor circuit breaker. 2. Move landing gear position switch to desired position. 3. Rotate emergency gear selector valve to desired position. 4. Pump emergency gear hydraulic pump until gear lights show for desired position and there is significant force on the pump handle. Always keep gear selector valve in OFF position (detent engaged –handle pointed toward pilot seat) except for emergency operation.” 3.Aerocet P/N 35A-59332 Placard is located on the instrument panel: “IN FLOATPLANE, AMPHIBIAN AND SKIPLANE RETRACT FLAPS TO 20° IMMEDIATELY AFTER APPLYING POWER FOR BALKED LANDING GO-AROUND.” 4. Refer to Cessna type data for required fuel placards. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 14 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E PLACARDS (Cont’d) 5. Aerocet P/N 35A-59334 Placard on instrument panel: “IN FLOATPLANE, AMPHIBIAN AND SKIPLANE AVOID SLIPS WITH FLAPS EXTENDED.” 6. Aerocet P/N 35-70006 Placard is located on aft part of console near water rudder handle in the "RETRACT" position: "WATER RUDDER ALWAYS UP EXCEPT WATER TAXIING" 7. Aerocet P/N 35-70011 Placard is located in plain view of the pilot: "AVOID TAIL-LOW TAKEOFFS AND LANDINGS WITH FLOATPLANE STINGER INSTALLED DURING OPERATIONS AS A LANDPLANE 8. Aerocet P/N 36-15601 Placard is located inside the float locker panels: "MAX BAGGAGE: 100 LBS. ARM: 32.4 in. AFT DATUM 9. Circuit Breaker Placards: “PUMP PWR”, “PUMP RELAYS”, “GR. ADV. ELEC.” ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 15 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 3. EMERGENCY PROCEDURES: Emergency procedures in the FAA approved airplane placards and/or Flight Manual generally apply except for airspeeds which may be different. Emergency landings on water should be done with water rudders up, aircraft slightly tail low on touchdown, and control wheel held full aft as the floatplane decelerates on the water. Emergency landings on land should be done with water rudders up, aircraft in a level attitude on touchdown, and the control wheel full aft after contact. If damage occurs to the floats causing compartments to flood, aggressively shift the weight (people & baggage) in the opposite direction of damage in order to balance the aircraft over the buoyant compartments. EMERGENCY OPERATIONAL CHECKLISTS ENGINE FAILURE ENGINE FAILURE DURING TAKEOFF RUN (ON WATER) 1. Throttle -- IDLE. 2. Control Wheel -- FULL AFT. 3. Mixture -- IDLE CUT-OFF. 4. Ignition Switch -- OFF. 5. Master Switch -- OFF. ENGINE FAILURE DURING TAKEOFF RUN (ON LAND) 1. Throttle -- IDLE. 2. Brakes -- APPLY. 3. Wing Flaps -- RETRACT. 4. Mixture -- IDLE CUT-OFF. 5. Ignition Switch -- OFF. 6. Master Switch -- OFF. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 16 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E FORCED LANDINGS EMERGENCY LANDING ON WATER WITHOUT ENGINE POWER 1. Landing Gear -- UP. 2. Airspeed -- 79 KIAS (flaps UP) 72 KIAS (flaps DOWN). 3. Mixture -- IDLE CUT-OFF. 4. Fuel Shutoff Valve -- OFF. 5. Ignition Switch -- OFF. 6. Master Switch -- OFF. 7. Water Rudders -- UP. 8. Wing Flaps -- AS REQUIRED. 9. Doors -- UNLATCH PRIOR TO TOUCHDOWN. 10. Touchdown -- SLIGHTLY TAIL LOW. 11. Control Wheel -- HOLD FULL AFT as amphibian decelerates. EMERGENCY LANDING ON LAND WITHOUT ENGINE POWER 1. Landing Gear -- UP on soft or rough ground. DOWN on firm and smooth ground. 2. Airspeed -- 79 KIAS (flaps UP) 72 KIAS (flaps DOWN). 3. Mixture -- IDLE CUT-OFF. 4. Fuel Shutoff Valve -- OFF. 5. Ignition Switch -- OFF. 6. Master Switch -- OFF. 7. Water Rudders -- UP. 8. Wing Flaps -- AS REQUIRED (30° recommended). 9. Doors -- UNLATCH PRIOR TO TOUCHDOWN. 10. Touchdown -- LEVEL ATTITUDE (if gear is up). SLIGHTLY TAIL LOW (if gear is down). 11. Control Wheel -- FULL AFT (after contact if gear is up). 12. Brakes -- APPLY HEAVILY (if gear is down). ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 17 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E LANDING GEAR MALFUNCTION PROCEDURES LANDING GEAR FAILS TO RETRACT 1. Master Switch -- ON. 2. Landing Gear Handle -- CHECK (handle full up). 3. Landing Gear Motor Circuit Breaker -- IN. 4. Emergency Hand Pump Selector Valve -- CHECK (in off position – toward pilot seat). 5. Gear Relay Circuit Breaker -- IN. 6. Gear Advisory Circuit Breaker -- IN. 7. Gear Up Lights -- CHECK bulb operation (press-to-test). 8. Main Gear Visual Indicators -- VISUALLY CHECK (at float inspection openings). 9. Landing Gear Handle -- RECYCLE. 10. Landing Gear Motor -- CHECK operation (motor indicator light, ammeter and noise). 11. Cycle the Emergency Hand Pump Selector Valve to UP position and back to OFF (this reduces pressure in the system allowing the pressure switches to sense low pressure allowing the pump to cycle). If the landing gear still does not retract and a water landing is desired: 12. Landing Gear Motor Circuit Breaker -- PULL. 13. Landing Gear Handle -- UP. 14. Emergency Hand Pump Selector Valve -- ROTATE (to UP position – clockwise 90 deg.). 15. Emergency Hand Pump -- PUMP (up and down until gear is in UP position - approximately 165 strokes -- there should be significant force on the pump handle with the final stroke). 16. Gear Up Lights -- CHECK ILLUMINATED. 17. Main Gear Visual Indicators -- VISUALLY CHECK (at float inspection openings). Nose gear -- VISUALLY CHECK (gear is nested in the bow of the float). ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 18 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E LANDING GEAR MALFUNCTION PROCEDURES LANDING GEAR FAILS TO EXTEND 1. Master Switch -- ON. 2. Landing Gear Handle -- CHECK (handle full down). 3. Emergency Hand Pump Selector Valve -- CHECK (in off position – toward pilot seat) 4. Landing Gear Motor Circuit Breaker -- IN. 5. Gear Relay Circuit Breaker -- IN. 6. Gear Advisory Circuit Breaker -- IN. 7. Gear Down Lights -- CHECK bulb operation (press-to-test). 8. Main Gear Visual Indicators -- VISUALLY CHECK (at float inspection openings). 9. Landing Gear Handle -- RECYCLE. 10. Landing Gear Motor -- CHECK operation (motor indicator light, ammeter and noise). 11. Cycle the Emergency Hand Pump Selector Valve to DOWN position and back to OFF (this reduces pressure in the system allowing the pressure switches to sense low pressure allowing the pump to cycle). If the landing gear still does not extend and a wheels-down landing is desired: 12. Landing Gear Motor Circuit Breaker -- PULL. 13. Landing Gear Handle -- DOWN. 14. Emergency Hand Pump Selector Valve -- ROTATE (to DOWN position – counterclockwise 90 deg.). 15. Emergency Hand Pump -- PUMP (up and down until gear is in DOWN position - approximately 230 strokes -- there should be significant force on the pump handle with the final stroke). 16. Gear Down Lights -- CHECK ILLUMINATED. 17. Main & Nose Gear Visuals -- VISUALLY CHECK (with mirrors & note that the up indicators on the mains are not visible at the float inspection openings). ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 19 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E GEAR UP LANDING (ON LAND) 1. Landing Gear -- CHECK UP (indicator lights and main gear latch fittings). 2. Runway -- SELECT longest smooth ground or grass surface available. 3. Wing Flaps -- 30° (on final approach). 4. Airspeed -- 72 KIAS. 5. Master Switch -- OFF. 6. Doors -- UNLATCH PRIOR TO TOUCHDOWN. 7. Touchdown -- LEVEL ATTITUDE. 8. Control Wheel -- FULL AFT (after contact). 9. Mixture -- IDLE CUT-OFF. 10. Fuel Shutoff Valve -- OFF. 11. Ignition Switch -- OFF. AMPLIFIED PROCEDURES MECHANICAL FAILURE If it is ascertained that a mechanical failure has occurred and the gear will not achieve either a gear up or a gear down position with visual confirmation, the best course of action will be dependent upon the nature of the failure and the choices of landing surfaces available. In the unlikely event that a landing gear has failed in an intermediate position, and cannot be moved to either a Gear Up or Gear Down position, the amphibian should be landed on land only. WARNING: DO NOT land in the water with the wheels either partially or fully extended. If the landing MUST be accomplished on water and the gear is partially or fully extended, it is suggested that a power-on full stall landing with full flaps (30°) would be the best procedure. Unlatch cabin doors prior to touchdown except for the rear cargo door on the co-pilots side. Flaps must be deployed prior to unlatching the rear cargo door otherwise the flaps will not move with the door unlatched. During deceleration after touchdown, with the gear extended, the float bows will submerge and there is a high probability of flipping the amphibian onto its back causing either fatal or serious injury. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 20 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 4. NORMAL PROCEDURES: (NOTE: THESE ITEMS SUPPLEMENT THE CESSNA NORMAL PROCEDURES - BE SURE TO FOLLOW THE CESSNA PROCEDURES EXCEPT AS NOTED BELOW) BEFORE ENTERING FLOATPLANE 1. Inspect the floats and attachment for dents, cracks, punctures, etc. 2. Remove rubber plugs (which serve as stoppers on the standpipe in each float compartment) and pump out any accumulation of water. Reinstall rubber stoppers with enough pressure for a snug fit. (If there is an excess of water, investigate the leakage - if there is red hydraulic fluid in any water, investigate fittings and lines in that bay before proceeding). 3. Landing Gear -- INSPECT. Check the main wheel oleo struts for proper inflation; check the tires for cuts, bruises and proper inflation. 4. Inspect locker door latches – DETENTS ENGAGED, LATCHES TURNED CLOCKWISE TO STOPS. WARNING: It is up to the pilot to determine whether the floats have taken on water, which could adversely affect CG. Pump both floats before every flight. NOTE: Refer to placards on the main wheel oleo struts for strut inflation procedures. Proper tire inflation for 6.00-6 main wheel tires is 55 psi; tire inflation for the 10-3.50 nose wheel tires is 70 psi. NOTE: An un-latched locker bay door will cause a howl and may bang against the float struts during flight. Aircraft should be returned to field in normal fashion to avoid potential damage, and to assess any possible problems. However, as with any situation, “FLY THE AIRCRAFT!” rather than make a rash decision. It is likely that little or no damage will occur to locker door. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 21 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E BEFORE STARTING ENGINE 1. Landing Gear Handle – DOWN (amphibian on land), or UP (amphibian on water) 2. Water Rudder Operation – CHECK VISUALLY 3. Water Rudders – DOWN FOR TAXIING ON WATER – UP FOR TAXIING ON LAND 4. Water Rudders – CHECK FREEDOM OF MOVEMENT & SECURITY BEFORE TAKEOFF TAKEOFF TAKEOFF ON WATER 1. Landing Gear – UP 2. Landing Gear Blue Indicator Lights – CHECK ILLUMINATED 3. Water Rudders – UP (retraction handle aft) 4. Wing Flaps – 20 DEGREES" (second notch) 5. Control Wheel – HOLD FAR AFT INITIALLY 6. Power – FULL THROTTLE & MAX RPM (advance slowly) 7. Mixture – LEAN FOR HIGH DENSITY ALTITUDE 8. Control Wheel – MOVE FORWARD TO ATTAIN PLANING ATTITUDE 9. Control Wheel – APPLY LIGHT BACK PRESSURE TO LIFT OFF 10. Wing Flaps – UP AFTER OBSTACLES ARE CLEARED WARNING: It is up to the pilot to determine whether the floats have taken on water, which could adversely affect CG. Pump both floats before every flight. WARNING: Never attempt a takeoff without all four blue indicator lamps illuminated – any gear hanging down will drag the aircraft dangerously into an arc, compromising takeoff distances, and endangering the occupants. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 22 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E TAKEOFF ON LAND 1. Landing Gear – DOWN 2. Landing Gear Amber Indicator Lights – CHECK ILLUMINATED 3. Water Rudders – UP (retraction handle aft) 4. Wing Flaps – 20 DEGREES (second notch) 5. Power – FULL THROTTLE & MAX RPM (advance slowly) 6. Mixture – LEAN FOR HIGH DENSITY ALTITUDE 7. Control Wheel – APPLY LIGHT BACK PRESSURE TO LIFT OFF 8. Wing Flaps – UP AFTER OBSTACLES ARE CLEARED 9. Landing Gear – UP BEFORE LANDING BEFORE LANDING ON WATER 1. Landing Gear -- UP. 2. Landing Gear Blue Indicator Lights -- CHECK ILLUMINATED. 3. Visually check that nose gear are UP 4. Water Rudders -- UP. 5. Wing Flaps -- 30°. BEFORE LANDING ON LAND 1. Landing Gear -- DOWN. 2. Landing Gear Amber Indicator Lights -- CHECK ILLUMINATED. 3. Water Rudders -- UP. 4. Wing Flaps -- 30°. WARNING During deceleration after a water touchdown, with the gear extended, the float bows will submerge and there is a high probability of flipping the amphibian onto its back causing either fatal or serious injury. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 23 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E LANDING LANDING ON WATER 1. Touchdown -- SLIGHTLY TAIL LOW. 2. Control Wheel -- HOLD FULL AFT as amphibian decelerates to taxi speed. 3. After landing – WATER RUDDERS DOWN LANDING ON LAND 1. Touchdown -- SLIGHTLY TAIL LOW. 2. Control Wheel -- EASE FORWARD to lower wheels gently to runway. 3. Braking -- MINIMUM REQUIRED BALKED LANDING "RETRACT FLAPS TO 20 DEG. IMMEDIATELY AFTER APPLYING FULL POWER FOR GO-AROUND" SECURING AIRPLANE "FUEL SELECTOR TO RIGHT OR LEFT TANK POSITION TO PREVENT CROSSFEEDING" ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 24 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E This page intentionally left blank. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 25 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 5. PERFORMANCE: ALL MODELS EXCEPT T206H Airspeed Calibration - Essentially unchanged STALL SPEEDS POWER OFF, FORWARD CG, 3744 LBS FLAPS UP: 61 KCAS 70 MPH CAS FLAPS DOWN (30 Deg.): 54 KCAS 62 MPH CAS NOTE ALTITUDE LOSS DURING STALL RECOVERY MAY BE AS MUCH AS 200 FEET. CLIMB RATE EXCEEDS 550 FPM (CAR 3.85a) MODEL T206H The following information is valid for model T206H which has a turbocharged Lycoming engine (310 hp). GLIDE In the event of engine failure enroute with propeller wind milling, landing gear up, flaps up. 95 MPH CAS RECCOMENDED GLIDE SPEED 83 KCAS Maximum horizontal distance traveled in still air 1.5 NM PER 1,000 FT ALTITUED LOST SINK RATE 1,000 FPM ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 26 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E FLAPS UP KIAS 60 70 80 90 100 110 120 130 140 150 160 170 180 KCAS 61 70 78 87 96 106 115 125 135 146 157 168 179 FLAPS 20° KIAS 50 60 70 80 90 100 --- --- --- --- --- --- --- KCAS 52 60 69 79 89 100 --- --- --- --- --- --- --- FLAPS 30° KIAS 50 60 70 80 90 100 --- --- --- --- --- --- --- KCAS 54 61 70 80 91 104 --- --- --- --- --- --- --- AIRSPEED CALIBRATION NORMAL STATIC SOURCE CONDITIONS: Power Off WEIGHT FLAP 0 ° 30 ° 45 ° 60 ° LBS DEFLECTION KIAS KCAS KIAS KCAS KIAS KCAS KIAS KCAS 3744 UP 59 60 64 64 70 71 84 84 20° 54 55 57 59 64 65 76 77 30° 49 53 52 57 58 64 69 76 NOTES: 1. Altitude loss during a stall recovery may be as much as 360 feet. 2. KIAS values are approximate. STALL SPEEDS MOST FORWARD CENTER OF GRAVITY ANGLE OF BANK ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 27 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E CONDITIONS: Landing Gear Down, Flaps 20° 2500 RPM, 39 inHg Manifold Pressure Paved, Level, Dry Runway Zero Wind Liftoff Speed: 57 KIAS (approximately) Speed at 50 Ft: 69 KIAS Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Press Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Alt Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear In 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft Feet Obstacle Obstacle Obstacle Obstacle Obstacle Obstacle S.L. 1523 2324 1611 2442 1703 2565 1798 2692 1896 2824 1997 2960 1000 1596 2449 1691 2576 1788 2709 1889 2846 1994 2988 2102 3134 2000 1676 2584 1776 2722 1880 2864 1988 3012 2100 3165 2215 3323 3000 1761 2731 1868 2879 1979 3033 2094 3193 2214 3357 2337 3527 4000 1852 2890 1967 3050 2086 3217 2209 3389 2337 3566 2469 3750 5000 1951 3063 2074 3236 2201 3416 2333 3601 2469 3794 2611 3992 6000 2058 3251 2189 3438 2325 3632 2466 3833 2612 4041 2764 4256 7000 2174 3455 2314 3658 2459 3868 2610 4085 2767 4310 2930 4543 8000 2298 3678 2448 3897 2604 4124 2766 4124 2935 4604 3109 4856 9000 2433 3920 2594 4158 2761 4404 2935 4659 3116 4924 3303 5198 10000 2579 4185 2752 4443 2932 4710 3119 4987 3313 5274 3514 5572 NOTES: 1. Obstacle takeoff technique as described in Section 4. 2. If brakes are not held, distances are from point where takeoff power is reached. 3. Decrease distances 10% for each 15 knots headwind. For operation in tailwinds up to 10 knots, increase distances by 10% for each 3 knots. 4. For operation on dry, grass, hard runway, increase distances by 15% of the "ground roll" figure. 5. For operation in air colder than this table provides, use the coldest (leftmost) data for takeoff distances. 6. For operation in air warmer than this table provides, use extreme caution. 7. In grey shaded areas total takeoff distances over a 50 foot obstacle are predicted to exceed 1 mile. Use caution! OBSTACLE TAKEOFF DISTANCE FROM GROUND 3735 POUNDS 40°C 50°C 0°C 10°C 20°C 30°C MAXIMUM TAKEOFF WEIGHT ON GROUND ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 28 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E CONDITIONS: Landing Gear Up, Flaps 20° 2500 RPM, 39 inHg Manifold Pressure Rippled Water Zero Wind Liftoff Speed: 65 KIAS (approximately) Speed at 50 Ft: 69 KIAS Water Total Water Total Water Total Water Total Water Total Water Total Press Run Ft To Run Ft To Run Ft To Run Ft To Run Ft To Run Ft To Alt Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear In 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft Feet Obstacle Obstacle Obstacle Obstacle Obstacle Obstacle S.L. 2301 3160 2434 3325 2572 3497 2716 3675 2864 3859 3017 4049 1000 2412 3334 2554 3513 2701 3698 2854 3890 3012 4088 3176 4293 2000 2531 3523 2683 3716 2840 3916 3003 4123 3172 4336 3347 4557 3000 2660 3728 2821 3936 2989 4152 3164 4375 3344 4606 3531 4845 4000 2798 3951 2971 4176 3151 4408 3337 4650 3530 4899 3729 5157 5000 2948 4193 3133 4436 3324 4687 3524 4948 3730 5217 3943 5496 6000 3109 4456 3307 4719 3512 4991 3725 5273 3946 5564 4175 5866 7000 3283 4743 3495 5026 3715 5321 3943 5626 4180 5942 4425 6269 8000 3472 5055 3698 5362 3934 5681 4179 6012 4433 6355 4696 6709 9000 3675 5395 3918 5728 4171 6074 4434 6433 4707 6805 4990 7190 10000 3896 5766 4157 6128 4428 6503 4711 6893 5004 7298 5308 7717 NOTES: 1. Obstacle takeoff technique as described in Section 4. 2. Distances are from point where takeoff power is reached. 3. Decrease distances 10% for each 16 knots headwind. For operation in tailwinds up to 10 knots, increase distances by 10% for each 2 knots. 4. For operation in air colder than this table provides, use the coldest (leftmost) data for takeoff distances. Be aware of icing potential. 5. For operation in air warmer than this table provides, use extreme caution. 6. In grey shaded areas total takeoff distances over a 50 foot obstacle are predicted to exceed 1 mile. Use caution! 7. In dark grey shaded areas water run takeoff distances are predicted to exceed 1 mile. Use extreme caution! OBSTACLE TAKEOFF DISTANCE FROM WATER 3744 POUNDS 40°C 50°C 0°C 10°C 20°C 30°C ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 29 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E CONDITIONS: Flaps 20°, Gear Down 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB RATE OF CLIMB - FPM LBS ALT TEMP. SPEED FT °C KIAS 3735 S.L. 15 70 1334 1149 993 861 748 651 2000 11 70 1266 1093 947 824 718 628 4000 7 70 1188 1026 891 777 680 597 6000 3 70 1113 963 838 732 643 568 8000 -1 70 1041 902 787 691 610 542 10000 -5 70 973 845 739 652 579 518 CONDITIONS: Flaps 20°, Gear Down 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB CLIMB GRADIENT - ft/nm LBS ALT TEMP. SPEED FT °C KIAS 3735 S.L. 15 70 1262 1036 859 716 601 507 2000 11 70 1152 948 788 660 556 471 4000 7 70 1038 856 713 599 507 431 6000 3 70 934 772 645 544 462 395 8000 -1 70 839 696 583 494 421 363 10000 -5 70 753 626 527 448 385 333 TAKEOFF RATE OF CLIMB TAKEOFF CLIMB GRADIENT @ 1.2Vs1 -40°C -20°C 0°C 20°C 40°C 60°C 3735 POUNDS MAXIMUM WEIGHT FOR TAKEOFF FROM GROUND 3735 POUNDS -40°C -20°C 0°C 20°C 40°C 60°C MAXIMUM WEIGHT FOR TAKEOFF FROM GROUND ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 30 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E ENROUTE RATE OF CLIMB @ 1.3Vs1 CONDITIONS: Flaps Up, Gear Up 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB RATE OF CLIMB - FPM LBS ALT TEMP. SPEED FT °C KIAS 3744 S.L. 15 90 1329 1144 989 857 744 647 2000 11 90 1261 1088 942 819 714 624 4000 7 90 1183 1021 886 772 675 593 6000 3 90 1108 958 833 728 639 564 8000 -1 90 1036 898 783 687 606 538 10000 -5 90 968 840 735 648 575 514 ENROUTE CLIMB GRADIENT @ 1.3Vs1 CONDITIONS: Flaps Up, Gear Up 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB CLIMB GRADIENT - ft/nm LBS ALT TEMP. SPEED FT °C KIAS 3744 S.L. 15 90 1032 849 704 588 493 416 2000 11 90 943 777 647 542 456 386 4000 7 90 850 702 585 492 416 353 6000 3 90 766 634 530 446 379 324 8000 -1 90 688 571 479 405 346 297 10000 -5 90 618 514 432 368 315 273 3744 POUNDS 3744 POUNDS -40°C -20°C 0°C 20°C 40°C 60°C -40°C -20°C 0°C 20°C 40°C 60°C ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 31 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E BALKED LANDING RATE OF CLIMB @ 1.3V s0 CONDITIONS: Flaps 30°, Gear Down 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB RATE OF CLIMB - FPM LBS ALT TEMP. SPEED FT °C KIAS 3550 S.L. 15 85 927 734 571 433 316 215 2000 11 85 857 676 524 395 286 192 4000 7 85 776 607 466 347 246 160 6000 3 85 698 542 411 302 210 132 8000 -1 85 624 480 360 260 176 106 10000 -5 85 553 420 311 221 145 82 BALKED LANDING CLIMB GRADIENT @ 1.3V s0 CONDITIONS: Flaps 30°, Gear Down 2500 RPM 39 inHg Mixture - Placard Cowl Flaps Open WEIGHT PRESS STD. CLIMB CLIMB GRADIENT - ft/nm LBS ALT TEMP. SPEED FT °C KIAS 3550 S.L. 15 85 732 554 415 303 214 141 2000 11 85 652 492 366 267 186 121 4000 7 85 568 425 314 226 155 98 6000 3 85 492 365 267 189 127 77 8000 -1 85 423 311 225 157 103 60 10000 -5 85 360 262 187 128 82 45 60°C -40°C -20°C 0°C 20°C 40°C 3550 POUNDS 3550 POUNDS -40°C -20°C 0°C 20°C 40°C 60°C MAXIMUM WEIGHT FOR LANDING ON GROUND ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 32 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E CONDITIONS: Gear Down, Flaps 30° Propeller Lever - Maximum Power for 3° Descent to Obstacle, Then Gradual Reduction to Idle at Touchdown, Idle After Landing Maximum Braking Paved, Level, Dry Runway Zero Wind Speed at 50 Ft: 67 KIAS 0°C 10°C 20°C 30°C 50°C Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Press Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Alt Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear In 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft Feet Obstacle Obstacle Obstacle Obstacle Obstacle Obstacle S.L. 778 1644 806 1679 835 1715 863 1752 892 1788 920 1825 1000 801 1698 830 1736 859 1774 889 1812 918 1851 947 1891 2000 824 1755 854 1795 884 1835 914 1876 945 1917 975 1959 3000 848 1815 880 1857 911 1900 942 1943 973 1987 1004 2031 4000 873 1878 905 1923 937 1968 969 2014 1001 2061 1033 2108 5000 900 1945 933 1992 966 2041 998 2089 1031 2139 1064 2188 6000 927 2015 961 2065 995 2117 1029 2168 1063 2221 1097 2273 7000 955 2089 990 2143 1025 2197 1060 2252 1095 2308 1130 2364 8000 984 2168 1020 2225 1056 2283 1092 2341 1128 2400 1164 2459 9000 1015 2251 1052 2312 1089 2373 1126 2435 1163 2497 1200 2560 10000 1046 2339 1084 2404 1122 2469 1160 2534 1199 2600 1237 2667 NOTES: 1. Obstacle landing technique as described in Section 4. 2. Decrease distances 10% for each 16 knots headwind. For operation in tailwinds up to 10 knots, increase distances by 10% for each 2 knots. 3. For operation in air colder than this table provides, use the coldest (leftmost) data for takeoff distances. 4. For operation in air warmer than this table provides, use extreme caution. 5. For operation on a dry, grass runway, lncrease distances by 40% of the "ground roll" figure. OBSTACLE LANDING DISTANCE ON GROUND 3550 POUNDS 40°C MAXIMUM LANDING WEIGHT ON GROUND ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 33 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E CONDITIONS: Gear Up, Flaps 30° Propeller Lever - Maximum Power for 3° Descent to Obstacle, Then Gradual Reduction to Idle at Touchdown, Idle After Landing Rippled Water Zero Wind Speed at 50 Ft: 67 KIAS 0°C 10°C 20°C 30°C 50°C Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Grnd Total Press Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Roll Ft To Alt Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear Ft Clear In 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft 50 Ft Feet Obstacle Obstacle Obstacle Obstacle Obstacle Obstacle S.L. 1080 2531 1119 2574 1159 2618 1198 2662 1238 2707 1277 2751 1000 1111 2603 1152 2649 1193 2695 1233 2742 1274 2789 1315 2836 2000 1143 2678 1185 2726 1227 2775 1269 2824 1311 2874 1353 2923 3000 1177 2756 1220 2808 1264 2859 1307 2911 1350 2963 1393 3016 4000 1212 2839 1256 2893 1301 2947 1345 3002 1389 3058 1434 3113 5000 1248 2925 1294 2983 1340 3040 1385 3098 1431 3157 1477 3215 6000 1286 3015 1333 3076 1381 3137 1428 3198 1475 3260 1522 3322 7000 1326 3111 1374 3174 1423 3239 1471 3304 1520 3369 1568 3435 8000 1366 3211 1416 3278 1466 3346 1516 3415 1566 3484 1616 3554 9000 1408 3315 1460 3387 1511 3459 1563 3531 1614 3604 1666 3678 10000 1451 3426 1504 3502 1557 3578 1610 3655 1663 3732 1717 3543 NOTES: 1. Obstacle landing technique as described in Section 4. 2. Decrease distances 10% for each 16 knots headwind. For operation in tailwinds up to 10 knots, increase distances by 10% for each 2 knots. 3. For operation in air colder than this table provides, use the coldest (leftmost) data for takeoff distances. 4. For operation in air warmer than this table provides, use extreme caution. OBSTACLE LANDING DISTANCE ON WATER 3661 POUNDS 40°C MAXIMUM LANDING WEIGHT ON WATER ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 34 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E This page intentionally left blank. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 35 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 6. WEIGHT AND BALANCE: The airplane equipped with Aerocet 3400 amphibious seaplane floats must be loaded in accordance with the limitations in Section 2. These are shown as an aircraft weight/moment envelope or an aircraft weight versus c.g. location chart. Arm Weight Moment Arm Weight Moment Inches Pounds lb.-ins./1000 Inches Pounds lb.-ins./1000 (1) Basic Empty Weight 38.94 2660 103.58 (2) OIL -20.8 17 -0.35 (3) Usable Fuel (MAX 65) 47 gallons 48 283 13.58 (4) Pilot and Copilot (STA. 34 TO 48) 37 340 12.58 (5) PASSENGERS + BAGGAGE CENTER Row Passengers (STA. 69 TO 79) 70 340 23.80 AFT Row Passengers (STA. 92 TO 100) 100 0 0.00 AFT BAGGAGE (STA. 109 TO 145; 120LBS MAX ) 127 50 6.35 (6) NO SEATS CARGO AREAS CARGO "A" (STA. 10 TO 50) 37 0 0.00 CARGO "B" (STA. 50 TO 84) 78 0 0.00 CARGO "C" (STA. 84 TO 109) 105 0 0.00 CARGO "D" (STA. 109 TO 145) 127 0 0.00 (7) OPTIONAL CARGO POD (STA. 10 TO 85) 47 0 0.00 (300 LBS. MAX) (8) FLOAT CARGO LOCKERS (STA. 15 TO 51) 32.4 50 1.62 (100LBS. MAX EACH SIDE) (9) Ramp CG, Weight And Moment 43.1 3740 161.2 (10) Available useful Load @ 3744 GW 4 (11) Located the (9) point (3740 @ 161.2) on the Center of Gravity Moment Envelope, and since this point falls within the evelope, the loading is acceptable. * Maximum allowable cargo loads will be determined by the type and number of tie-downs used, as well as by the airplane weight and C.G. limitation. Floor loading must not exceed 200lbs. per square foot. SAMPLE AIRPLANE YOUR AIRPLANE SAMPLE LOADING PROBLEM CESSNA 206 WITH AEROCET AMPHIBIOUS 3400 SERIES FLOATS NOTE: It is the responsibility of the airplane owner and pilot to insure that the airplane is loaded properly. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 36 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 37 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 7. AIRPLANE AND SYSTEMS DESCRIPTIONS: In addition to the Aerocet 3400 amphibious seaplane float installation the aircraft must incorporate the Cessna approved seaplane kit and an approved three blade propeller according to the STC. As a result of these installations, the floatplane is identical to the landplane with the following exceptions: CHANGE FROM LANDPLANE TO AMPHIBIOUS SEAPLANE Installation of Aerocet amphibious floats include the following modifications or additions to a landplane. This is an overview. The complete information resides in Cessna manuals, Aerocet drawings and the STC. CESSNA FLOAT KIT MODIFICATIONS TO AIRPLANE 1. Fuselage strengthening installed at factory. 2. V-brace. Hoisting rings. (installed at factory or later) 3. Aileron Fences. (also available from Aerocet) 4. Empennage changes: Vertical fin and beacon modified, ventral fin, rudder, fairings, stinger, dual tail tie-down rings. 5. Rudder trim bungee replaced with softer. 6. Water rudder bellcranks. 7. Cowl flap rod extensions on models A through G. 8. Exhaust extensions on models A through G. AEROCET FLOAT INSTALLATION 9. Float undercarriage: float hulls, spreader bars, struts, flying wires, boarding steps, water rudder rigging, retractable landing gear system. 10. Hydraulic lines, reservoir and pump with associated electrical wiring for landing gear operation. 11. Propeller listed in Section 1 of this AFMS. 12. Exhaust pipe modification on H-model 13. Wing mounted mirrors. 14. In cockpit: - Gear selector with light and audio advisories - Placards - Emergency hand pump handle - Water rudder retraction handle ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 38 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E ADJUSTMENTS FOR SEAPLANE 15. Elevator trim rigging changed 16. Flap travel limited to 30 deg ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 39 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E AMPHIBIOUS FLOATS REMOVED FOR LANDPLANE OPERATIONS When the floats (item 9 above) are replaced with landplane landing gear the following items need to be changed. Other items listed above, including the propeller and the H-models exhaust extension, can remain on the airplane. 4. Ventral fin removed. 5. Rudder trim bungee replaced. 6. Water rudder bellcranks removed. 7. Cowl flap rod extensions removed on models A through G. 8. Exhaust extensions removed on models A through G. 15. Elevator trim rigging adjusted to landplane. 16. Flap travel maximum set to 40 deg. AMPHIBIOUS LANDING GEAR SYSTEM The landing gear incorporated within the amphibious floats on this airplane is a retractable, quadricycle type with two full swiveling nose (or bow) wheels and two main wheels. Shock absorption is provided by air oil shock struts for the main gear and composite leaf springs for the bow gear. Each main wheel is equipped with a hydraulically-actuated disc-type brake. Normal landing gear extension and retraction accomplished by hydraulic actuators for each gear. The hydraulic system is powered by a reversible, electrically-driven hydraulic pump located just forward of fuselage station 166.4. Hydraulic system fluid level should be checked every 25 hours of flight time by viewing the reservoir or its sight glass on the side of the pump. Fill to fill-line of reservoir or to within ½” of the top of the sight glass by removing the plug and using MIL-H-5606 hydraulic fluid. Hydraulic pump operation is initiated by moving the landing gear switch on the gear control unit to either the up or down position. The landing gear will travel to the position selected, cycling the electrically-driven hydraulic pump. The pump is shut off by pressure switches. When the pressure switch senses a certain amount of pressure in the hydraulic line, which the electric pump is forcing fluid through, it will send a signal to the motor relay shutting down the pump. The pressure increases at the end of operation when all the actuators have traveled to the end of their stroke. Eight position-indicator lights (four gear up and four gear down) are provided to show landing gear position. An additional indicator light shows that the landing gear pump motor is in operation. The landing gear system is also equipped with an emergency hand pump with a selector valve. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 40 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E G600 LANDING GEAR ADVISORY UNIT LANDING GEAR HANDLE The landing gear handle is an electrical switch mounted within a control unit on the instrument panel, and has two positions (UP for gear up and DOWN for gear down) which give a mechanical indication of the gear position selected. From either position, the handle must be pulled out to clear a detent before it can be repositioned. Moving the handle to UP or DOWN will start the reversible, electrically-driven hydraulic pump in the selected direction of gear travel. Operation of the landing gear system will not begin until repositioning of the handle is complete. INDICATOR LIGHTS Eight indicator lights are mounted on the Landing Gear Advisory Unit adjacent to the landing gear handle. The four blue indicator lights, labeled WATER, (positioned respective to their location on the float, i.e. top left – front left gear) show by their illumination that the landing gear is up. The four amber indicator lights, labeled LAND, illuminate when the landing gear is down. Neither set of lights is illuminated when the landing gear is in transit. The single red indicator light, labeled PUMP, comes on when current is being supplied to the landing gear pump motor. If the motor continues running during flight or goes on and off repeatedly, the motor should be shut ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 41 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E off by pulling the LANDING GEAR MOTOR circuit breaker, since continual running of the motor can result in premature motor failure. Prior to landing, the circuit breaker should be pushed in to reactivate the circuit. If an indicator light should fail to come on when pressed for testing check wiring and gear position. Beyond this, reference the service manual for the gear advisory, document A-10037. The WATER, LAND, and PUMP light circuits are protected by the Landing Gear Advisory circuit breaker, and are therefore independent of the landing gear motor circuit and will function when using the emergency hand pump. AUDIO ADVISORY OPERATION The Landing Gear Advisory Unit, GC600, includes an audio output that is connected to an audio output source (i.e. radio or audio panel) for verbal pilot information regarding gear position. A static and pitot pressure source is connected to the Unit which determines airspeed. The Landing Gear Advisory Unit has an arming speed set by the factory and a trigger point set at approximately 80 knots. Refer to section 2.3 of the Gear Advisory Service Manual A-10037 for further information. The GC600 audio announcements are dependent on airspeed “ARM” and “TRIGGER” settings, which are factory pre-set for the aircraft type. The GC600 is armed by the aircraft exceeding the pre-set airspeed. As the aircraft begins its approach, it slows its airspeed passing through the pre-set trigger speed, and sounding an audio announcement to indicate the gear position. If the gear is not in a fully retracted or a fully deployed position, then a gear unsafe announcement will sound. With all blue lights on, the announcement will sound, “Water landing, gear is up for water landing”. This announcement will continue to repeat and complete the phrase, until the upper “CANCEL” button is pushed, or the aircraft speed is increased above the trigger airspeed setting. NOTE: The pilot should always visually check the nose gear before attempting a water landing to assure that it is up regardless of lights. If the pull ram mechanically fails, it could travel and show a light but not be connected to the nose gear itself leaving the nose gear in the down position. During deceleration after a water touchdown, with the gear extended, the float bows will submerge and there is a high probability of flipping the amphibian onto its back causing either fatal or serious injury. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 42 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E With all amber lights on, the announcement will sound, “Runway landing, gear is down for runway landing”. This announcement will continue to repeat and complete the phrase, until the lower “CANCEL” button is pushed, or the aircraft speed is increased above the trigger airspeed setting. If the condition exists where any indicator light within the WATER quadrant, or RUNWAY quadrant, fails to illuminate, then the announcement will sound, “Gear is unsafe, check gear”. This announcement will continue to repeat and complete the phrase, until either upper or lower Cancel button is pushed to de-activate. The “TEST” button in the center left position of the face, when depressed, will sound an audible announcement indicating the current position of the gear. One of three announcements listed above, will repeat as long as the button is depressed. This announcement will continue to repeat and complete the phrase, until the button is released. LANDING GEAR OPERATION To retract or extend the landing gear, pull out on the landing gear handle and move it to the desired position. When the handle is positioned, electrical power is directed to one of two solenoid relays, which energize the reversible electric motor. The Emergency Hand Pump lever must be in the OFF position (which points the end of the handle toward the pilot seat.) in order for the electric pump to pump fluid. The electric motor powers the hydraulic pump and actuates two hydraulic gear actuators in each float in the appropriate direction. During operation of the landing gear motor, the “PUMP” indicator light is illuminated. When the hydraulic rams have enough resistance on them, typically by achieving full travel of the ram, pressure will build NOTE: It should be clearly noted that the audio advisory side of the Landing Gear Advisory Unit by Aerocet, Inc. does not alleviate the pilot’s responsibility to visually check the location of the landing gear prior to landing, especially to assure the gear is up when making a water landing. Audio systems may be turned down or fail. NOTE: The pilot should always visually check the nose gear before attempting a water landing to assure that it is up regardless of audio indication. If the pull ram mechanically fails, it could travel and show a light or give an audio indication but not be connected to the nose gear itself leaving the nose gear in the down position. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 43 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E triggering the electric pressure switches that in turn activate the relays to turn the pump off. Proximity sensors are located on all four gear, feeding appropriate gear position to the Landing Gear Advisory Unit illuminating the appropriate (WATER or LAND) lights. Again, the pressure in the system turns the pump on and off, not the proximity sensors. EMERGENCY HAND PUMP SELECTOR VALVE AND HAND PUMP A three-position emergency hand pump selector valve combined with a single action hand pump is located between the crew seats and is for use in the event the normal hydraulic system fails. The selector valve has three positions, labeled UP, DOWN, and OFF which points the end of the handle toward the pilot seat. To select gear position with the emergency hand pump selector, rotate the handle to UP (clockwise 90 degrees) or DOWN (counterclockwise 90 degrees). NOTE: The emergency hand pump selector valve must be rotated to the OFF position (in a detent with the end of the handle pointing toward the pilot seat) during normal system operation. If the selector valve is in any other position, it provides a by-pass for hydraulic pressure and the landing gear may not function properly. During deceleration after a water touchdown, with the gear extended, the float bows will submerge and there is a high probability of flipping the amphibian onto its back causing either fatal or serious injury. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 44 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E EMERGENCY HAND PUMP SELECTOR VALVE AND HAND PUMP (Cont’d) Prior to utilizing the emergency hand pump, pull the LANDING GEAR MOTOR circuit breaker to ensure deactivation of the electric hydraulic pump, then rotate the hand pump selector valve to the desired position (UP or DOWN). Actuate the hand pump up and down (approximately 230 strokes for extension and 165 strokes for retraction) until the landing gear reaches the selected position. When the gear reaches the selected position, the appropriate gear position indicator lights will illuminate and the hand pump should be pumped until there is significant force on the pump handle with the final stroke. For complete emergency procedures, refer to Section 3 of this supplement. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 45 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SECTION 8. AIRPLANE HANDLING, SERVICE, AND MAINTENANCE INTRODUCTION Airplane handling, service, and maintenance in the basic handbook applies, in general, to the amphibian. The following recommended procedures apply specifically to amphibian operation. (Cleaning, servicing and maintenance of the amphibious floats should be accomplished as suggested in the Aerocet, Inc. 3400 amphibian Service and Maintenance Manual.) MOORING Proper securing of the amphibian can vary considerably, depending on the type of operation involved and the facilities available. Each operator should use the method most appropriate for his operation. Some of the most common mooring alternatives are as follows: 1. The amphibian can be moored to a buoy, using a yoke tied to the forward float cleats, so that it will freely weathervane into the wind. 2. The amphibian can be secured to a dock using the fore and aft cleats of one float, although this method is generally not recommended unless the water is calm and the amphibian is attended. 3. The amphibian may be removed from the water (by use of a special lift under the spreader bars) and secured by using the wing tie-down rings and float cleats. If conditions permit the amphibian to be beached (with the landing gear retracted), ensure that the shoreline is free of rocks or abrasive material that may damage the floats. 4. The amphibian may be taxied from the water onto land if a hard surface ramp is available by extending the landing gear just prior to reaching the ramp area. The amphibian should then be tied down using procedures similar to the landplane. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 46 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E BEACHING – HEELING IN (stern of the floats on the beach) or NOSING INTO SHALLOW GRADIENT WATER The amphibian may be heeled into a beach, but with caution. Also use caution when beaching, nose in, at shallow shore gradients. The wheel well area can scoop sand, mud, rocks, or clay. A rock (deflector) shield is provided to help prevent the debris from collecting underneath the main gear truck. If the plane is secured with the step area embedded in the sand, wave action can wash sand into the wheel well area. Clay or mud can also stick in this area posing a problem. This can reduce clearances, because of debris buildup, preventing the main gear truck from extending to the full gear down position. The main landing gear has tremendous leverage as it travels into its over-center position, and can damage the float and gear truck if there is a restriction. A method (no guarantees) of cleansing this area is proposed. With the gear still retracted, after leaving the beach, aggressively plow the floats to flush this area. This puts the plane at a high angle of attack and introduces water for flushing. Do this a couple of times and even go up on the step for a moment. After washing the area and the airplane is at idle power lower the gear. Assure that all the amber lights illuminate, indicating gear down position is achieved. If a main gear light does not illuminate, proceed to inspect the problem. Ideally, finding a float dolly which will lift the floats out of the water with the gear retracted, will give opportunity to investigate the problem. WARNING Water operations with landing gear extended may be hazardous in shallow water or in areas where submerged obstacles exist. High speed water operations with landing gear extended is never safe. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 47 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E SERVICING Service the airplane in accordance with the basic handbook. Special attention should be given to engine oil and landing gear servicing of the amphibian. Some of the following service information is contained in the basic handbook, and is repeated here for your convenience. AMPHIBIOUS LANDING GEAR NOSE WHEEL TIRE PRESSURE: 70 PSI on 10-3.50, 4-Ply Rated Tires. MAIN WHEEL TIRE PRESSURE: 55 PSI on 6.00-6, 8-Ply Rated Tires. MAIN GEAR SHOCK STRUTS: Keep filled with MIL-H-5606 hydraulic fluid and inflated with nitrogen to 495 PSI for main gear shock struts with no load. HYDRAULIC FLUID RESERVOIR: Check and service with MIL-H-5606 hydraulic fluid every 25 hours of flight time. Fill to fill-line of reservoir or to within ½” of the top of the sight glass by removing the plug and using MIL-H-5606 hydraulic fluid. CAUTION: When servicing the landing gear system, the procedures and precautions contained in the Service and Maintenance Manual for Aerocet 3400 Amphibious Floats must be followed. ISSUE DATE: PO Box 2119 265 Shannon Lane Priest River ID 83856 Page 48 of 48 8/23/10 INCORPORATED FILE NO. REVISION DATE TITLE: Supplemental Airplane Flight Manual A-10060 2/10/2020 SUBTITLE: Cessna 206 on Model 3400 Floats REVISION: E -END-