Slick Service Letter

B. Secure the negative lead away from the negative terminal of the battery to prevent inadvertent contact. C. To prevent accidental firing of magnetos and possible engine operation, disconnect the ignition harness from the spark plugs. II. Remove starting vibrator A. If SlickSTART"" is installed to replace a conventional starting vibrator, disconnect the wires from the vibrator and ignition switch, and deactivate them by capping with an end connector Consult Airframe manufacturers manuals for correct wiring schematics to ensure only the vibrator wiring is deactivated. B. Unbolt and remove the starting Vibrator. The SlickSTART"" mounting hole diameters and spacing are identical to typical starting vibrators. REVISED ISSUED MO MO DAY YEAR DAY YEAR 24 09 10 31 96 09 ' CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road Liberty, South Carolina, U.s.A. 29657 G 5 of 34 02009 Champion Aerospace www.championaerospace.com ./ / SL2-96 " III. Install SlickSTARr'" (Refer to Figure 1.) WARNING: THE MAGNETO IS "0N'WHEN THE IGNITION SWITCH WIRE (P-LEAD) IS DETACHED FROM THE MAGNETO. NORMAL PRECAUTIONS MUST BE TAKEN TO PREVENT ACCIDENTAL ENGINE IGNITION. A. Select a suitable location to mount the SlickSTARr'". Be sure the mounting bracket will not interfere with or affect the aircraft structure. Minor rerouting of wiring or relocation ofthe accessories may be required. The SlickSTARr'" and associated wiring should be mounted away from heat sources, clear of the exhaust, engine control linkages, and any other systems critical to the airworthiness ofthe aircraft. JIMates With 5 in. .2'8 Dia. '/4 in. Female JSpade Terminal 0 '"\' ~ SlickSTART I I DANGER HIGH VOLTAGE '. ::) \1...----_~>-EJ ~ -r ~ ,'l8in. 'n.in~ 0 in. H,.938 ~ 210-1 Figure 1 ISSUED REVISED CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road MO DAY YEAR MO DAY YEAR Liberty, South Carolina, U.s.A. 29657 10 31 96 09 24 09 e 2009 Champion Aerospace 6 of 34 G \... www.championaerospace.com ./ r ""\ SL2-96 B. SlickSTART"" should be mounted vertically with the terminals facing downward. The two mounting holes will accommodate 3/16 inch bolts. IV. Connect SlickSTART"" according to the following appropriate section. (Refer to Table 2.) Table 2 If EXisting System Includes ... Go To Paragraph ... Starting Vibrator Without Relay A BendixlTCM PIN: 10-176487-121 10-176487-122 10-176487-241 10-176487-242 I When Converting from an Impulse Coupled A to a Retard Breaker Magneto Single Impulse Coupled Magneto B Dual Impulse Coupled Magneto B Twin Engine Impulse Coupled Magnetos B C Dual Retard Breaker Applications CHAMPION AEROSPACE LLC REVISION PAGE NO. REVISED ISSUED 1230 Old Norris Road YEAR MO DAY YEAR MO DAY Liberty, South Carolina, U.s.A. 29657 7 of 34 G co 2009 Champion Aerospace www.championaerospace.com 96 09 24 09 10 31 " /" SL2-96 A. To replace starting vibrators, which do not include a relay, or when converting from impulse coupled to retard breaker magnetos, when the engine will be started using only the left magneto on single engine applications only (refer to Figure 2): 1. Connect the SlickSTARr" terminal marked "VIN" to the switched positive terminal of the starter solenoid on the starter side, as close to the starter solenoid as possible, or equivalent electrical point. The SlickSTART™ should only receive power when the starter is engaged. Use the unshielded red wire, 5 ampere fuse, fuse holder, crimp splice connectors, appropriate ring terminal and 1/4 inch spade terminals supplied with each SlickSTARr". /" SlickSTART I I /1Connect to Ground on Left Magneto. Connect to Left Magneto Capacitor -D-AN-G-ER-HI-GH-Y-Ol-TA-G-E'1Terminal Stud. ~ Y G Connect to Positive Switched 1 2 3 I N (Starter) Side of Starter Solenoid. SF=~~N~D~fJr / Include a 5.0 Amp Inline Fuse as '~o ~ P,rto'W"'"g'"P"' Connect to Magneto Retard ~ BreakerTerminal. Figure 2 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR DAY YEAR MO MO Liberty, South Carolina, U.S.A. 29657 G 8 of 34 02009 Champion Aerospace www.championaerospace.com 10 31 96 09 24 09 \.. ./ / I I I ISSUED MO DAY YEAR 10 31 96 ' SL2-96 ""\ 2. Connect the terminal marked "GND" to the left magneto ground. a. Using the shielded wire bundle supplied with each SlickSTART"', connect the pre-crimped ring terminal of the black wire to the ground screw on Slick magneto. b. After routing the wire bundle to the SlickSTART"', cut and trim to the appropriate length. c. Using 1/4 inch spade terminals provided, connect the black wire to the SlickSTART™ terminals"GNDf~ The foil shielding and the bare silver wire in the wire bundle should be trimmed back to the cable jacket and left unconnected. 3. Use the red wire in the wire bundle to connect the SlickSTART™ terminal marked "l"to the left magneto capacitor stud terminal (P-lead),leaving the existing "P" lead wire attached. 4. 5. 6. MO 09 Disconnect the "LR" wire at the ignition switch, and cap, or remove. Disconnect the "BO" wire at the ignition switch, and cap, or remove. Connect the SlickSTART'" terminal marked "3" to the left magneto retard breaker terminal using locally sourced 18 gauge wire and ring terminal. REVISED CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road DAY YEAR Liberty, South Carolina, U.S.A. 29657 24 09 e 2009 Champion Aerospace 9 of 34 G www.championaerospace.com SL2-96 WARNING: DURING STEP 7, ENSURE THAT THE ELECTRICAL POWER SOURCE HAS BEEN REMOVED FROM ·rHE STARTER MOTOR AND INSULATED PRIOR TO ENGAGING THE START SWITCH. FAILURE TO DO SO MAY RESULT IN SERIOUS INJURY OR DEATH. 7. Verify that the right magneto is grounded when the start switch is in the start position. Most start switches automatically ground the right magneto P-Iead while starting. If the right magneto is not grounded with the start switch in the start position, verify that the jumper shown in Figure 3 is installed. If your aircraft is not equipped with this type of switch, it may be necessary to replace the existing switch(s) with a reM or equivalent combination ignition and starter switch in order to ground the right magneto during start. VerifyThatThis Jumper Is Installed If Your Aircraft Is Equipped With This Type Of Switch. These Diagrams Show The Most Common Switches. Refer To The Switch Manufacturer's Installation Instructions For Your Switch. ~T ~'1d> s R GRD lQJ LR CO (6?~ o 8 f9 PR 80 TCM/Bendix 10-357000 Series ACS/Gerdes Figure 3 8. Proceed to Section V. ISSUED REVISED MO DAY YEAR MO DAY YEAR 10 31 96 09 24 09 CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road liberty, South Carolina, U.S.A. 29657 e 2009 Champion Aerospace 10 of 34 G www.championaerospace.com / SL2-96 B. To connect SlickSTART'"" with an impulse coupled magneto when the engine will be started using only one SlickSTART'"" boosted magneto per engine (refer to Figure 4): NOTE: For dual impulse coupled applications, it is preferred to attach SlickSTART™ to the left magneto. If required for ease of installation or convenience, SlickSTART™ can be attached to the right magneto without any further modification. NOTE: Twin engine impulse coupling applications require two SlickSTART'"" units; one per engine. 1. Connect the SlickSTART'"" terminal marked "VIN" to the switched positive terminal of the starter solenoid on the starter side, as close to the starter solenoid as possible, or equivalent electrical point. The SlickSTART™ should only receive power when the starter is engaged. Use the red wire,S ampere fuse, fuse holder, crimp splice connectors, appropriate ring terminal and 1/4 inch spade terminals supplied with each SlickSTART'"". REVISED ISSUED MO YEAR MO YEAR DAY DAY 24 09 10 31 96 09 " CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road Liberty, South Carolina, U.S.A. 29657 G 11 of 34 () 2009 Champion Aerospace www.championaerospace.com ./ SL2-96 SlickSTART 1__1 viConnectTo Ground On Left Magneto. 1.....---------..,. DANGER HIGH VOLTAGE connectTo Left V G ConnectTo Positive Switched Magneto Capacitor 1 , 3 I N (Starter) Side Of Starter Solenoid. Terminal Stud. I _~JiF=~~N~D~~~ / Include A S.O Amp Inline -- "C.0 ~ Fuse As Part Of Wiring Input Leave Unconnected. Figure 4 2. Connect the terminal marked "GND"to the boosted magneto ground and the terminal marked "1" to the boosted magneto capacitor stud. a. Using the shielded wire bundle supplied with each SlickSTAR"P", connect the pre-crimped ring terminal of the black wire to the ground screw on Slick magneto. Connect the pre-crimped ring terminal of the red wire to the capacitor stud terminal, leaving the existing "P" lead wire attached. b. After routing the wire bundle to the SlickSTAR"P", cut and trim to the appropriate length. CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR YEAR MO MO DAY Liberty, South Carolina, U.S.A. 29657 12 of 34 G e 2009 Champion Aerospace 24 09 31 96 09 10 www.championaerospace.com \.. CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road YEAR MO DAY YEAR MO DAY Liberty, South Carolina, U.s.A. 29657 13 of 34 G e 2009 Champion Aerospace 96 24 09 10 31 09 www.championaerospace.com ./ " SL2-96 ' c. Using 1/4 inch spade terminals provided, connect the black and red wires to the SlickSTART"" terminals "GND" and "1" respectively. The foil shielding and the bare silver wire in the wire bundle should be trimmed back to the cable jacket and left unconnected. 3. Install insulated terminals, without attached wires, on remaining SlickSTART™ terminal "3': 4. For installations where the non-boosted magneto is not impulse-coupled and, therefore, not used for engine starting, verify that the non-boosted magneto is grounded when the start switch is in the start position. Most start switches automatically ground the non-boosted magneto P-Iead while starting. If the non-boosted magneto is not grounded with the start switch in the start position, verify that the jumper shown in Figure 3 is installed. If your aircraft is not equipped with this type of switch, it may be necessary to replace the existing switch(s) with a TeM or equivalent combination ignition and starter switch in order to ground the non-boosted magneto during start. 5. Proceed to Section V. / SL2-96 C. To replace starting vibrators when the engine will be started using two boosted retard breaker magnetos with two SlickSTARTs™ (refer to Figure 5): 1. Connect the SlickSTARrm terminal marked "VII'J"to the switched positive terminal of the starter solenoid on the starter side, as close to the starter solenoid as possible, or equivalent electrical point. The SlickSTART™ should only receive power when the starter is engaged. Use the red wire, 5 ampere fuse, fuse holder, crimp splice connectors, appropriate ring terminal and 1/4 inch spade terminals supplied with each SlickSTARrm. Connect To Ground On Magneto Being Boosted Connect To Magneto Capacitor Terminal Connect To Positive Switched SlickSTART 1'--__ 1 '...-O-A-NG-E.-H-,GH-V-OC-TA-GE......1v G '" /1 Stud Of Magneto I'-....... I N (Starter) Side Of Starter Solenoid. Being Boosted I ~_ ~JiF==iF=lFN=*°trfJ / Include A 5.0 Amp Inline L..---=:. -' .... ~0 ~ Fuse As Part Of Wiring Input ~ ConnectTo Magneto Retard BreakerTerminal Of Magneto Being Boosted. Figure 5 ISSUED REVISED MO DAY YEAR MO DAY YEAR 10 31 96 09 24 09 \... CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road Liberty, South Carolina, U.S.A. 29657 G 14 of 34 e 2009 Champion Aerospace www.championaerospace.com ./ I ISSUED MO DAY YEAR 10 31 96 \.. SL2-96 '\ 2. Connect the terminal marked IGND"to the left magneto ground and the terminal marked "1" to the left magneto capacitor stud. a. Using the shielded wire bundle supplied with each SlickSTART"', connect the pre-crimped ring terminal of the black wire to the ground screw on Slick magneto. Connect the pre-crimped ring terminal of the red wire to the capacitor stud terminal (P-Iead), leaVing the existing "P" lead wire attached. b. After routing the wire bundle to the SlickSTART"', cut and trim to the appropriate length. 3. Disconnect the "LR" wire at the ignition switch, and tape or cap. 4. Disconnect the "BO" wire at the ignition switch, and tape or cap. 5. Connect the SlickSTART'" terminal marked "3" to the magneto retard breaker terminal of the magneto being boosted. The existing wire can be used if serviceable and a new 1/4 inch spade terminal is installed. 6. Proceed to Section V. CHAMPION AEROSPACE LLC REVISION PAGE NO. REVISED 1230 Old Norris Road YEAR DAY MO Liberty, South Carolina, U.s.A. 29657 G «) 2009 Champion Aerospace 09 www.championaerospace.com 24 09 15 of 34 ./ / SL2-96 '\ V. Reconnect the Ignition HarnessTo the Spark Plugs. VI. Check SlickSTART'"'" Installation. A. Inspect all wiring connections for proper termination. B. Check all wiring for proper routing away from heat generating sources, mechanical stresses and abrasion. C. Check for removal of all installation tools. VII. Reconnect Aircraft Battery. A. Confirm that the aircraft ignition and master switches are in the off position. B. Reconnect the negative lead of the aircraft electrical system to the negative battery terminal. DOCUMENTATION: Make all appropriate logbook entries. SlickSTART'"'" is approved by STC. CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road MO DAY YEAR MO DAY YEAR Liberty, South Carolina, U.S.A. 29657 16 of 34 G e 2009 Champion Aerospace 10 31 09 24 09 96 www.championaerospace.com ./ " SL2-96 Q!lnit.rh §tnt.rz nf Am.rrirn 1Hrp-artmrnt of CITranzp-ortation- -lJi'rllrral Aviation Allminiztration §upp12m2utal crryp2 QJ2rtifirat2 f'~ 5A593CH ~ t:el&~ ~.0 Champion Aerospace LLC 1230 Old Norris Road Liberty, 5C 29657 ud~c/t'kt' t'~ "k~" en t'~ ~ ~~n.4~ t'~~t!ZU'??z;?' /!~"t' 'wet'£'t',,{; d'mit'at'ePn and""na'!:t'ePno t'k,~ ao Ff/d,,{;za,n nuet3 t'k aiUO<>';~e4:J",,?uizenu=t3 t}/!9fat' *,yt',,{; * ~udt&>no, &~ma/g~ --~ ~~ ~~l,' * * See Attached FAA Approved Model List (AML) No. ~~. * 5A593CH for list of approved engine models and Jtd!,f.' * applicable airworthiness regulations Install Champion 5IickSTART'" magneto booster system in accordance with Slick Installation Instructions as listed on AML No. 5A593CH or later FAA Approved revision. 1. Compatibility of this design change with previously approved modifications must be determined by the installer. 2. A copy of this Certificate and FAA Approved Model List (AML) No. 5A593CH, or later FAA approved revision, must be maintained as part of the permanent records for the modified aircraft. 3. 51ickSTART'" Model 551001 may only be used with Slick 4200,6200,4300,6300 series magnetos. 4. 51ickSTART'" Model 551002 may only be used with TCM/Bendix 5-20, 5-200, 5-1200 series magnetos. CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO Liberty, South Carolina, U.s.A. 29657 17 of 34 G e 2009 Champion Aerospace 96 09 24 09 10 31 www.championaerospace.com \. / SL2-96 5. Do not install 5IickSTART'" Model 551001 with Teledyne Continental Motors/Bendix 5-20, 5-200, and 5-1200 series mag netos. 6. If the holder agrees to permit another person to use this certificate to alter the product, the holder shall give the other person written evidence of that permission. §.u:,~~.. §.u:,~~ce .. December 18, 1995 January 24, 1997 §.u:, ~ February 10,2009 §.u:, ~ May 2,1997; March 9,1998, April 20, 2000; March 12, 2004 ~d~,y;k~dJaah~ Signed original on file at Champion ~n~J Thaddeus D. Krolicki, Jr. Manager, Propulsion Branch Chicago Aircraft Certification Office tI1iis certijUate may 6e tratuje"ea in accoraance witli '1'}f.~21.47 ISSUED REVISED CHAMPION AEROSPACE LLC PAGE NO. REVISION 1230 Old Norris Road MO DAY YEAR MO DAY YEAR Liberty, South Carolina, U.s.A. 29657 10 31 96 09 24 09 © 2009 Champion Aerospace 18 of 34 G \,. www.championaerospace.com ./ /' '\ SL2-96 FAA APPROVED MODEL LIST (AML) NO. SAS93CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 AIRCRAFT LINE AIRCRAFT MAK< MODEL 1 AD Aerospace Inc. T-11,T-211 AERMACCHIS.p.A. 5.205-1 B/F, S.20S-l8/R, S.20S-20/F, S.20S-20/R, S.205-22/R, 5.208, S.208A 3 2 AERMACCHIS.p.A. F.260, F.260B, F.26OC, F.260D Aero Resources J-2 (McCUlloch) 5 4 Aeracar Inc. I Aerodifusion,S.L. Jodel 0-11905 6 Aeromere 5.A. Falco F.8.L 7 AMT-l00, AMT-200 8 Aeromot Aeronautica Macchi AL 60, AL 60-B S.PA 10 9 6S-TC (Army L-3J), 6S-TAC (Army L-3E), YO-58 (Army L-3) 11 Aeronca Aeronca 6S-CA(L-3F),S-6S-CA Aerostar Aircraft 12 360,400 Aerostar Aircraft PA-60-6oo (Aero star 600), PA-60-601 (Aerostar 601), PA-60-601 P(Aerostar 601 P), PA-60-602P (Aerostar 602P), PA-60-700P (Aerostar 700P) 14 13 Air & Space America 18A A, A-2, A-3, A-4, A-5, A-ST, A-6, A-7, 15 Aircraft Parts & A-7T, A-9, A-9B Development ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUalONS 'AFM SUPP NO/OATF AML AMEND OATF CERTIFICATE N"MR<R FOR ALTERATION NlJMRFR 'REV. NO/DATE A-791 CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A9EU FAR 21.29 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 A10EU CAR 3 SL2-96 Rev.D 1/01/00 N/A 3112/04 H6WE FAR27 SL2-96 Rev. 0 1/01/00 N/A 3112/04 4A16 CAR3 SL2-96 Rev.D 1/01/00 N/A 3112/04 AlliN CARlO SL2-96 Rev. 0 1/01/00 N/A 3/12/04 7Al1 CARlO SL2-96 Rev.D 1/01/00 N/A 3112/04 TGOoo04AT FAR 21.29 JAR-22 SL2-96 Rev. 0 1/01/00 N/A 3/12/04 7A12 CAR 10 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3112/04 A-72B CAR4a SL2-96 Rev.D 1/01/00 N/A 3112/04 A-67S Aeronautic Bulletin 7-A SL2-96 Rev. 0 1/01/00 N/A 3112/04 A11WE FAR 23 SL2-96 Rev. 0 1/01/00 N/A 3112/04 A17WE FAR 23 SL2-96 Rev. 0 1/01/00 N/A 3112/04 1H17 CAR 6 SL2-96 Rev. 0 1/01/00 N/A 3112/04 A-7S8 CAR4a (CAR 8) SL2-96 Rev. 0 1/01/00 N/A 3112/04 CHAMPION AEROSPACE LLC REVISION REVISED PAGE NO. ISSUED 1230 Old Norris Road YEAR MO DAY YEAR MO DAY Liberty, South Carolina, U.s.A. 29657 19 of 34 G 02009 Champion Aerospace 31 96 09 24 09 10 www.chamoionaerosoace.com \.. / SL2-96 '\ FAA APPROVED MODEL LIST (AMLl NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART"" MAGNETO BOOSTER SYSTEM Date of Issuance January 24. 1997 AIRCRAFT MA<" LINE AIRCRAFT Mon", 16 A-9A Aircraft Parts & Development 14-19-2,14-19-3,14-19-3A 17-30, 17-31,17-31TC lB 17 Alexandria Aircraft 14-13,14-13-2,14-13-3,14-13-3W Alexandria Aircraft 17-30A,17-31A.17-31ATC 19 Alexandria Aircraft 20 All American Aircraft lOA H-2S0. H-29S (U-1 OD), HT-29S. H391 (YL-24), H391 B, H39S(L-2BA. or U-1 OB), H39SA. H-700, H-BOO 22 21 Helio A-60 American Blimp American Champion 7Ae, 7ACA,S7AC, 7BeM (L-16A), 23 Aircraft 7CCM(L-16B). S7CCM. 7DC, S7De, 7EC, S7EC, 7ECA, 7FC,7GC,7GCA, 7GCAA, 7GCB, 7GCBA, 7GCBC, 7HC, 7JC, 7KC, 7KCAB 24 American Champion BKCA B, BGCBC Aircraft l1AC,S11AC.llBC,S11BC American Champion 2S Aircraft American Champion llCC,S11CC Aircraft 27 26 American Champion 402 Aircraft 2B AA-S, AA-SA, AA-SB, AG-SB LLC 29 True Flight Holdings AA-1, AA-1A, AA-1B,AA-1C LLC 30 True Flight Holdings GA-7 SOCATA, SA. Grumman ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS 'AFM SUPP NOJDATE AML AMEND DATE CERTIFICATE NUMR"R FOR A'T"RAT'ON NUMBER 'REV. NOJDATE A4WE CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 1A3 CAR3 SL2-96 Rev.D 1/01/00 N/A 3112/04 A-773 CAR4a SL2-96 Rev.D 1/01/00 N/A 3112/04 AlBeE FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-792 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 lAB CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 AS1NM FAR 21.17(b) SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-7S9 CAR4a SL2-96 Rev.D 1/01/00 N/A 3112/04 A21CE FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-761 CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-796 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3112/04 A3CE CAR3 SL2-96 Rev.D 1/01/00 N/A 3112/04 A16EA FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 AllEA FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A17S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO Liberty, South Carolina, U.s.A. 29657 20 of 34 G e 2009 Champion Aerospace \.. 24 10 31 96 09 09 www.chamoionaerosoace.com --I /" '\ SL2-96 FAA APPROVED MODEL LIST (AML) NO. SAS93CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT AIRCRAFT MAKE MODEL 31 Anderson, 14 Greenwood 32 Anderson, Sl,SlA Greenwood 33 S-lA INTERSTATE 34 STOL Aviation LLC STOL Aviation LLC S-lB2 INTERSTATE 3S 21S0, 21 SOA, 2180 VARGA 36 Augustair Inc. D-140-B AvionJodel lS0 Avions Jodel 37 DR-l0S0 38 Avions Jodel D-l190 39 AVionJodel CAP lOB APEX Aircraft 40 APEX Aircraft R2160 41 R3OO0/160 42 APEX Aircraft HoneyBee (HB) Beecraft Associates 43 47, 47B, 47B3, 47D, 47Dl, 47E, 47G, Bell Helicopter 44 47G-2,47H-l 4S Textron 47G-3, 47G-2A, 47G-38, 47G-3B-l, Bell Helicopter 47G-2A-1, 47G-4, 47G-4A, 47G-S, 47G-3B-2, 47G-SA, 47G-3B-2A 46 Textron 47J, 47K, 47J-2,47J-2A Bell Helicopter Textron ORIGINAL TYPE CERTIFICATION BASIS INSfALLATION INSTRUCTIONS "AFM SUPP NOJDATE AML AMEND DATE CERTIFICATE NUMBER FOR ALTERATION NUMBER "REV. NOJDATE 4Al CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A11SW FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-737 CAR 4 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-7S4 CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12/04 4A19 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A31N CARlO SL2-96 Rev.D 1/01/00 N/A 3/12/04 A141N CARlO SL2-96 Rev.D 1/01/00 N/A 3/12/04 MIN CARlO SL2-96 Rev.D 1/01/00 N/A 3/12/04 AlOIN CAR 10 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A36EU FAR 21.29 SL2-96 Rev.D 1/01/00 N/A 3/12/04 M8EU FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A66EU FAR 23,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 4All CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 H-l CAR 6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 2H3 CAR 6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 2H1 CAR 6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO Liberty, South Carolina, U.s.A. 29657 21 of 34 G I) 2009 Champion Aerospace 24 09 10 31 96 09 ~ www.chamoionaerosoace.com \. /' \.. LINE AIRCRAFT MAK" 47 Seastar Corp. 4B DaimlerChrysler Aerospace AG 49 Brantly International 50 Brantly International 51 British Aerospace Scottish Division 52 B-N Group Ltd 53 B-N Group Ltd 54 C.ltoh 55 Cessna Aircraft 56 Cessna Aircraft 57 Cessna Aircraft 58 Cessna Aircraft 59 Cessna Aircraft ISSUED REVISED MO DAY YEAR MO DAY YEAR 10 31 96 09 24 09 FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM AIRCRAFT MODE TsC-1A, T5C-1A1, T5C-1A2 BolkowJr. B-2, B-2A, B-2B 305 Beagle B.206 Series 1 &2 BN-2A MK.lII, BN-2A MK.l1I2, BN-2AMKJII3 BN-2, BN-2A, BN-2A 2, BN-2A 3, BN-2A 6, BN-2A 8, BN-2A 9, BN-2A 20, BN-2A 21, BN-2A 26, BN-2A 27, BN-2B 20, BN-2B 21, BN-2B 26, BN-2B 27, BN-2T, BN-2T-4R N-62 120,140 140A 150, 150A, 150B, 15OC, 150D, 150E, 150F, 150G, 150H, 15QJ, 150K, A 150K, 150L,A150L,150M,A150M,152,A152 170, 170A, 170B 172, 172A 172B, 172C, 172D, 172E, 172F (T-41 A), 172G, 172H (1041 A), 1721, 172K, 172L,172M, 172N, 172P, 1720. 172R, 1725 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS ·AFM SUPP NOJDATE AML AMEND DATE CERTIFICATE NUMB"R FOR ALTERATION NUMO"R • REV. NOJDATE AlSEA FAR 23 5L2-96 Rev.D 1/01/00 N/A 3/12104 A1EU CARlO 5L2-96 Rev.D 1/01/00 N/A 3/12/04 2H2 CAR 6 5L2-96 Rev.D 1/01/00 N/A 3112/04 H35W CAR 6 5L2-96 Rev.D 1/01/00 N/A 3112/04 A11EU CAR 3 5L2-96 Rev.D 1/01/00 NlA 3112/04 A29EU FAR 21.29, 23 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A17EU FAR 21.29, 23 5L2-96 Rev.D 1/01/00 N/A 3112/04 A3PC CAR 10 5L2-96 Rev.D 1/01/00 N/A 3112/04 A-768 CAR4a 5L2-96 Rev.D 1/01/00 N/A 3112/04 5A2 CAR 3 (CAR 4a) 5L2-96 Rev.D 1/01/00 N/A 3/12/04 3A19 CAR 3 5L2-96 Rev.D 1/01/00 N/A 3112/04 A-799 CAR3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 3A12 CAR3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC 1230 Old Norris Road Liberty, South Carolina, U.s.A. 29657 e 2009 Champion Aerospace www.chamoionaerosoace.com SL2-96 " Date of Issuance January 24, 1997 PAGE NO. REVISION 22 of 34 G ~ / SL2-96 '\ FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 AIRCRAFT MAKE LINE AIRCRAFT MnDFI 60 172RG, Pl72D, Rl72E (T-41B, T-41C, T-41 D), Rl72F, Rl72G, Rl72H, R172J, Rl72K, 175, 17SA. 17sB, 17SC 61 Cessna Aircraft Cessna Aircraft 177, 177A, 177B Cessna Aircraft 177RG 62 Cessna Aircraft 180, 180A, 180B, 18OC, 180D, 180E, 180F, 18OG, 180H, 180J, 180K 64 63 Cessna Aircraft 182, 182A, 182B, 182C, 182D, 182E, 182F, 182G, 182H, 182J, 1821<, 182l, 182M, 182N, 182P. 1820. 182R, 1825, 182T, R182, T182, TR182 65 Cessna Aircraft 185, 18sA, 18sB, 18SC, 18sD, 18sE, A18sE,A18sF 66 Cessna Aircraft 188, 188A, 188B,Al88,A188A,A188B, T188C 67 Cessna Aircraft 206, 206H, P206A, B, C, D, E, TP206A, B, C, D, E, U206A, B, C, D, E, F, G, TU206A, B, C, D, E, F, G, U206, T206H 68 Cessna Aircraft 207, 207A, T207, U07A 69 Cessna Aircraft 210, 210A, 210B, 21OC, 210D, 210E, 210F, T210F, 21OG, T21OG, 210H, T210H, 21 OJ, T210J, 210K, T210K, 210l, T21OL, 210M, T210M, 210N, P210N, Ul0N, 210R, P210R, T210R, 210-5 (205), 210-sA (20sA) 70 Cessna Aircraft 1303 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS "AFM SUPP NOJDATE AMl AMEND DATE CERTIFICATE NIIMBEo FOR A JFRATlnN NUMBER "REV. NOJDATE 3A17 CAR 3 sl2-96 Rev.D 1/01100 N/A 3/12104 A13CE FAR 23 sl2-96 Rev.D 1/01/00 N/A 3/12/04 A20CE FAR 23 sL2-96 Rev.D 1/01/00 N/A 3/12/04 sA6 CAR3 sL2-96 Rev.D 1/01/00 N/A 3/12/04 3A13 CAR3 sL2-96 Rev.D 1/01/00 N/A 3/12104 3A24 CAR3 sL2-96 Rev.D 1/01/00 N/A 3/12104 A9CE FAR 21 sL2-96 Rev.D 1/01/00 N/A 3/12104 MCE CAR 3 sL2-96 Rev.D 1/01/00 N/A 3/12104 Al6CE FAR 23 sl2-96 Rev.D 1/01/00 N/A 3/12/04 3A21 CAR 3 Sl2-96 Rev.D 1/01/00 N/A 3/12/04 A34CE FAR 23 Sl2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY MO DAY YEAR MO YEAR Liberty, South Carolina, U.s.A. 29657 23 of 34 G e 2009 Champion Aerospace \. 09 24 09 10 31 96 www.chamoionaerosoace.com ./ /' ...... SL2-96 FAA APPROVED MODEL LIST (AML) NO. SAS93CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART"' MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT MAK. 71 Cessna Aircraft Cessna Aircraft 72 Cessna Aircraft 73 74 Cessna Aircraft 75 Great Lake Aircraft 76 Cirrus Design Corp 77 CPAC, Inc. Commonwealth Aircraft 78 79 Composite Aircraft Corp 80 Diamond Aircraft Diamond Aircraft 81 Domier-Werke G.M.b.H. 82 83 Domler-Werke G.M.b.H. 84 Dynac Aerospace Aero Commander ORIGINAL CERTIFICATION INSTALLATION AIRCRAFT TYPE CERTIFICATE BASIS FOR INSTRUCTIONS *AFM SUPP AML AMEND * REV. Mon., NUM··R A T.RATlnN I NUMBER NOJDATE NOJDATE DATE 310, 310A, 310B, 31OC, 3100, 310E, 3Al0 CAR3 SL2-96 Rev. 0 N/A 3112104 310F, 31OG, 310H, Bl0H, 3101,31OJ, 1/01/00 310J-1, E310J, 310K, 310L, 310N, 310P, 3100. T310Q310R,T310R 320A, B, C, 0, E, F, 320-1, 335, 340, 340A 3A25 CAR 3 SL2-95 Rev. 0 1/01/00 N/A 3/12/04 337, 337A(02B), 337B, 337C, 3370, A6CE FAR 23 SL2-95 Rev. 0 N/A 3112/04 337E, 337F, 337G, 337H, M337B (02A), 1/01/00 P337H, T337B, T337C, T337D, T337E, T337F, T337G, T337H, T337H-SP "'01,401 A, 401 B, 402, 402A, 402B, 402C A7CE CAR3,FAR23 SL2-96 Rev. 0 N/A 3112104 411, 411A,414, 414A,421,421A, 421B, 1/01/00 421C 2T-1A, 2T-1A-l, 2T-1A-2 A18EA AB-7 A, FAR 23 SL2-96 Rev. 0 1/01/00 N/A 3/12104 SR20,SR22 AOOOO9CH FAR 23,36 SL2-96 Rev. 0 1/01/00 N/A 3/12/04 112,112B,114B,114TC A12S0 FAR 23, 36 SL2-96 Rev. 0 1/01/00 N/A 3112/04 175, 180, 185 A-729 CAR4a SL2-95 Rev. 0 1/01/00 N/A 3/12/04 AC-7 A7SW FAR 23 SL2-95 Rev. 0 1/01/00 N/A 3112/04 DA2o-A 1, DA2o-C 1 TMCH FAR 21.29, 23, 36,JAR-VLA SL2-96 Rev. 0 1/01/00 N/A 3112/04 DA-40 M7CE 14 CFR 21, 23, 36,JAR23 SL2-95 Rev. 0 1/01/00 N/A 3/12/04 Do 27 Q-jj A81N CARlO SL2-96 Rev. 0 1/01/00 N/A 3/12/04 D028A-1,D028 B-1 7A13 CARlO SL-2-95 Rev. 0 1/01/00 N/A 3/12/04 (Volaire) 10, lOA (Aero Commander) 100, l00A, 100-180 1A21 Car 3 SL2-96 Rev. 0 1/01/00 N/A 3/12104 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR YEAR MO MO DAY Liberty, South Carolina, U.S.A. 29657 24 of 34 G e 2009 Champion Aerospace \... 10 31 96 09 24 09 www.chamoionaerosoace.com ./ , SL2-96 '" FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT MAKE BS Edward Scott Kearns Elzie Wright, Jr. B6 Falcon Enstrom Helicopter B7 Corp. 88 Micco Aircraft Co. King's Engineering 89 Fellowship (TKEF) 90 Extra FFT-GmbH 91 92 FFA Found Aircraft Development 94 93 Found Brothers Frontier-Aerospace 95 Fletcher 96 Fuji Heavy Industries 97 GENERAL AVIA GENERAL AVIA 98 Gippsland 99 Aeronautics Goodyear A 100 AIRCRAFT Mnn<1 ORIGINAL TYPE CERTIFICATE NI MR<R CERTIFICATION BASIS FOR UERATION INSTALLATION INSTRUGIONS "AFM SUPP NOJDATE AML AMEND DATE NUMBER • REV. NOJDATE TrojanA2 A·BOl CAR 3 SL2-96 Rev. 0 N/A 3112104 1/01/00 F-l A16S0 FAR 21, 23 SL2-96 Rev. 0 N/A 3/12104 1/01/00 F-28,280 HlCE CAR 6, FAR 21. 36 SL2-96 Rev. 0 N/A 3/12104 1/01/00 MAC-125C, MAC-145, 3Al 14CFR23,36 SL2-96 Rev. 0 N/A 3/12/04 MAC-145A, MAC-145B CAR 3 1/01/00 4500-300, A17CE FAR 23 SL2-96 Rev. 0 N/A 3/12/04 4500-300 Series II 1/01/00 EA-300, EA-300S A67EU FAR 23 SL2-96 Rev. 0 N/A 3/12/04 1/01100 SCOl B-160 A58EU FAR 21.29, 23 SL2-96 Rev. 0 N/A 3/12/04 1/01100 AS 202/15 'BRAVO' A34EU FAR 21.29, 23 SL2-96 Rev. 0 N/A 3/12104 AS 202l18A 'BRAVO' AS 202/18M '8RAVO' FBA-2C A7EA CAR3 SL2-96 Rev. 0 N/A 3112104 1/01/00 FBA Centennial '100' A13EA FAR 23 SL2-96 Rev. 0 N/A 3/12104 1/01/00 FU-24, FU-24A 4A12 CAR 3 SL2-96 Rev. 0 N/A 3112104 1/01/00 FA-2OQ-160, 180, 180AO MPC CARlO SL2-96 Rev. 0 N/A 3/12104 1/01/00 F.20 'Pegaso' A38EU FAR 21.29, 23 SL2-96 Rev. 0 N/A 3/12104 1/01/00 F22B A75EU FAR 23 SL2-96 Rev. 0 N/A 3112/04 ICAO Annex 16 1/01/00 GA200 AOOO01LA FAR 21,23 SL2-96 Rev. 0 N/A 3112/04 1/01/00 GA-2.GA-2B A-784 CAR4a SL2-96 Rev. 0 N/A 3112104 1/01/00 CHAMPION AEROSPACE LLC PAGE NO, REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO Liberty, South Carolina, U.s.A. 29657 G 25 of 34 02009 Champion Aerospace \.. 10 24 09 31 96 09 www.chamoionaerosoace.com ./ F SL2-96 '\ FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART"" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT AIRCRAFT MAKE MODEL 101 Goodyear Aircraft GA-22A 2T-1A,2T-1A 1,2T-1A2 102 Great Lake Aircraft 103 GROBG 109, Luft-und Raumfahrt Burkhart GROB GROBG 109B Gmbh 104 GllS, G1 lSA,GllSB,GllSC,GllSC2, G1 lSD, G11SD2,Gl 1SEG GROB-WERKE lOS Gulfstream 111 Aerospace Corp. 106 Helio Aircraft Corp. lSA,20 (Taylorcraft) 107 H-391 (YL-24), H-391 B, H-39S (L-2BA or Ul0B), H-39SA lOB Helio Aircraft Corp. UH-12,UH-12A Hiller Aviation Hiller Aviation UH-12B, UH-12C 109 UH-12D Hiller Aviation 110 UH-12E, UH-12E-L Hiller Aircraft 111 UH-12L, UH-12L4 Hiller Aviation 112 11 OO(OH-SA), FH- 11 00 Manufacturing Corp 114 FH-11oo 113 LC40-SS0FG, LC42-SS0FG Cessna Aircraft TZ-123OO0, GZ-19A, GZ- 19, GZ-20, GZ-20A 116 Lockheed Martin 11S 11A Aerospace Inc. Quartz Mountain ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS "AFM SUPP NO/DATE AML AMEND DATE CERTIFICATE NUMBER FOR ALTFRATION NIJMRER "'REV. NO/DATE lA12 CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 AlBEA Aero Bul.7A (FAR 23) SL2-96 Rev.D 1/01100 N/A 3/12/04 G43EU FAR 21.23, 21.29, 21.50 SL2-96 Rev.D 1/01/00 N/A 3/12/04 AS7EU FAR 21.23, 21.29 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A11S0 FAR 23, 21 SL2-96 Rev.D 1/01/00 N/A 3/12104 3A3 CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12/04 lAB CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 6Hl CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 6H2 CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 4H10 CAR6 SL2-96 Rev.D 1/01100 N/A 3/12/04 4H11 CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12104 H1WE CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 H2WE CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 Aoo003SE FAR 23,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 T.C.l Navy Approval 1935 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-B04 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road YEAR MO DAY YEAR MO DAY Liberty, South Carolina, U.S.A. 29657 26 of 34 G 02009 Champion Aerospace \.. 24 10 31 09 96 09 www.chamoionaerosoace.com ./ / SL2-96 " FAA APPROVED MODEL LIST (AML) NO. SAS93CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT AIRCRAFT MAKE MOOFI 117 The Don Luscombe 8, 8A, 8B, 8C, 8D, 8E, 8F, T-8F Aviation History Foundation Inc. Mael Aircraft BA-42 118 Maule Aerospace Bee Dee M-4, M-4, M-4C, M-4S, M-4T, M-4-18OC, M-4-180S, M-4-180T, M-4-210, M-4-210C, M-4-21 OS, M-4-210T, M-4-220, M-4-220C, M-4-220S, M-4-220T, M-5-18OC, M-5-200, M-5-210C, M-5-210TC, M-5-220C, M-5-235C, M-li-180, M-li-235 M-7-235, MX-7-235, MX-7-180, MX-7-420, MXT-71S0, MT-7-235, M-8-235, MX-7-160, MXT-7-160, MX-7-180A, MXT-7-180A, MX-7-180B, M-7-235B, M-7-235A, M-7-235C, MX-7-18OC, M-7-260, MT-7-260, M-7-260C, M-7-420AC, MX-7-16OC, MX-7-180AC, M-7-420A 120 119 BO-209-150 FV & RV Aerospace AG DaimlerChrysler BO-209 160 FV & RV BO-209-150 FF 121 Thomas H. McClish (Funk) B, B75L(UC-92), BS5C G-21C, G-21D Seaplanes LLC 123 Atlantic Coast 122 90AL-115 MonocQupe Corp. M20, M20A, M20B, M2OC, M20D, Company 124 Mooney Airplane M20E, M20F, M2OG, M20J, M20K, M20L,M20M ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS 'AFM SUPP NO/DATE AML AMEND DATF CERTIFICATE NUMBER FOR ALTERATION NUMBER 'REV. NOJDATF A-li94 CAR4a SL2-96 Rev.D N/A 3/12104 1/01/00 A6S0 FAR21, FAR23 SL2-96 Rev.D N/A 3/12104 1/01/00 3A23 CAR 3 SL2-96 Rev.D N/A 3/12104 1/01/00 A27EU FAR 21.29, 23 SL2-96 Rev.D N/A 3/12104 1/01/00 A-715 CAR4a SL2-96 Rev.D N/A 3/12104 1/1/00 4A24 CAR3 SL2-96 Rev.D N/A 3/12104 1/01/00 A-306 Aeronautics SL2-96 Rev.D N/A 3/12/04 Bulletin 7-A 1/01/00 CAR4a 2A3 CAR3 5L2-96 Rev.D N/A 3/12/04 1/01/00 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road YEAR MO DAY YEAR MO DAY Liberty, South Carolina, U.S.A. 29657 27 of 34 G e 2009 Champion Aerospace \.. 24 96 09 09 10 31 ~ www.chamoionaerosoace.com / ,SL2-96 FAA APPROVED MODEL LIST (AML) NO. SAS93CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTARr'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT MAK< AIRCRAFT MODEL 125 Mooney Mite Aircraft M-18C Corp. 126 Moravan ZLIN S26L Moravan a.s. 127 Z-242L 128 Morrisey Aviation 2000C FN-333 129 NARDIS.A. Navion (L-17A), Navion A (L-17B, Inc. (Navion) 130 Sierra Hotel Aero, L-17C), Navion B, Navion D, Navion E, Navion F, Navion G, Navion H EADS-PZL PZL-Koliber lS0A 131 "Warszawa~Okecie" P 68, P 68B, P 68C, P 68 ·Observer 2· 133 132 Vulcanair S.p.A. Piper Aircraft Inc. HC -40, J3C -SO, J3C-SOS, HC -65, J3C-6SS, PA-ll, PA-llS 134 Piper Aircraft Inc. J4, J4A, J4A-S JSA (L-4F), J5A-80, JS8 (L-4G), J5C, AE-l,HE-l 136 FS 2001 Corp. 135 L-14 FS 2000 Corp. PA-12,PA-12S 137 FS 2003 Corp. PA-14 138 FS 2002 Corp. PA-15 139 Piper Aircraft Inc. PA-16,PA-16S Piper Aircraft Inc. 140 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS 'AFM SUPP NOJDATF AML AMEND DATF CERTIFICATE N MR<R FOR AlTERATION NUMBER • REV. NOJDATE A-803 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A30EU FAR23,36 SL2-96 Rev.D 1/01/00 N/A 3/12104 A76EU FAR 21.29, 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 4A14 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 7AS CARlO SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-782 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A69EU FAR 23,36 SL2-96 Rev.D 1/01/00 N/A 3112/04 A31EU FAR 21.29, 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-691 CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12104 A-703 CAR4a SL2-96 Rev.D 1/01/00 N/A 3112104 A-725 CAR4a SL2-96 Rev.D 1/01/00 N/A 3112/04 760 CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-780 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-797 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-800 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3112/04 lAl CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION ISSUED REVISED 1230 Old Norris Road MO YEAR DAY YEAR MO DAY Liberty, South Carolina, U.s.A. 29657 28 of 34 G CJ 2009 Champion Aerospace 10 31 24 09 96 09 www.chamoionaerosoace.com ../ ' /" '\ SL2-96 FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT AIRCRAFT MAKE MOOFI 141 Piper Aircraft Inc. PA-17 142 Piper Aircraft Inc. PA·18, PA·18s, PA·18 "105", PA·18 "125" (L·21 A), PA·18AS "125", PA·18s"12s", PA·18 "135" (L-21 B), PA·18A "135", PA·l8As "13S~ PA·18s "135", PA-18 "150", PA·18A "ls0",PA·18As "lS0~ PA 185 "150", PA·19(L·18C), PA-19s 143 Piper Aircraft Inc. PA-18A (Restricted), PA·18A "135" (Restricted), PA-18A "1 SO" (Restricted) 144 Piper Aircraft Inc. PA·20, PA-20s, PA-20 "11 5", PA-20s "115", PA·20 "135", PA-20s "135" 145 PA'22, PA·22·1 08, PA·22·13S, PA·22s·13s, PA·22·1 SO, PA-22s-1 SO, PA·22·160, PA·22s·160 146 Piper Aircraft Inc. PA-23, PA·23·160, PA·23·23s, PA·23·2s0, PA·E23-2s0 147 Piper Aircraft Inc. Piper Aircraft Inc. PA-24, PA·24·2s0, PA·24·260, PA·24-400 148 PA-2s, PA·2s·23s, PA·2S·260 (Normal Category) 149 LAVIAs.A. PA·2s, PA-2S-23S, PA·2s·260 (Restricted Category) 150 LAViA SA PA·28·140, PA-28-1S0, PA·28-ls1, PA·28·160, PA·28·161, PA-28-180, PA·28-23S, PA-28s-160, PA·28R·180, PA·28s·180, PA·28·181, PA-28R·200, PA-28R-201, PA·28R·20lT, PA-28RT-201, PA·28RT·20lT, PA·28·20lT Piper Aircraft Inc. ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS ·AFM SUPP NOtOATF AML AMEND OATF CERTIFICATE NUMBER FOR ALTERATION NUMRFR • REV. NOtOATF A-80s CAR 3 sL2·96 Rev.D 1/01/00 N/A 3/12/04 lA2 CAR 3 sL2·96 Rev.D 1/01/00 N/A 3/12/04 AR-7 CAR8.10b sL2·96 Rev.D 1/01/00 N/A 3/12/04 lA4 CAR 3 sL2·96 Rev.D 1/01/00 N/A 3/12/04 lA6 CAR 3 sL2-96 Rev.D 1/01/00 N/A 3/12/04 lAl0 CAR 3 sL2-96 Rev.D 1/01/00 N/A 3/12/04 lAls CAR 3 sL2-96 Rev.D 1/01/00 N/A 3/12/04 2A8 CAR 3 sL2·96 Rev.D 1/01/00 N/A 3/12/04 2Al0 CAR8.10b sL2·96 Rev.D 1/01/00 N/A 3/12/04 2A13 CAR 3 sL2·96 Rev.D 1/01/00 N/A 3/12/04 REVISION ISSUED YEAR MO 96 09 REVISED CHAMPION AEROSPACE LLC 1230 Old Norris Road Liberty, South Carolina, U.S.A. 29657 " 2009 Champion Aerospace www.chamoionaerosoace.com YEAR 09 PAGE NO" DAY MO DAY 29 of 34 G 10 31 24 ~ \... / \. FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM AIRCRAFT MODCI PA-30, PA-39, PA-40 PA-31, PA-31-3oo, PA-31-3S0, PA-31-32S PA-31P, PA-3lT, PA-3lTl, PA-3lT2, PA-3lT3, PA-31 P-3S0 PA-32-260, PA-32-300, PA-32S-3oo, PA-32R-301(HP), PA-32-301, PA-32-30lT PA-34-200, PA-34-200T, PA-34-220T PA-36-2BS, PA-36-3oo, PA-36-37S (Normal Category) PA 36-2BS, PA-36-300, PA-36-37S (Restricted Category) PA-38-112 PA-44-180, PA-44-180T PA-46-310P, PA-46-3S0P Pirtle (Johnson) Rocket 18S 200, 2ooA, 200B, 20OC, 200D, 400 CP-6S 19A, B19, M 19A, 23, A23, A23A, A23 19, A23 24,823, C23, A24, A24R, 824R,C24R 3S, A3S, 83S, OS, D3S, E3S, F3S, G3S, 3SR SL2-96 '" Date of Issuance January 24, 1997 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS *AFM SUPP NO DATE AML AMEND DATC CERTIFICATE NUMRCR FOR AITCRATION NUMRCR "'REV. NO JnATc A1EA CAR 3, FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A20S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 ABEA FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 A3S0 CAR 3 SL2-96 Rev.D 1/01100 N/A 3/12/04 A7S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A9S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 AlOS0 FAR 23 SL2-96 Rev.D 1/01100 N/A 3/12/04 A18S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A19S0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 A2SS0 FAR 23 SL2-96 Rev.D 1/01/00 N/A 3112/04 n6 CAR4a SL2-96 Rev.D 1/01/00 N/A 3112/04 3A18 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-nO CAR4a SL2-96 Rev.D 1/01/00 N/A 3/12/04 A1CE CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-777 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3112/04 MO LINE lSl lS2 lS3 lS4 lSS lS6 lS7 lS8 lS9 160 161 162 163 164 16S AIRCRAFT MAKE Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Piper Aircraft Inc. Pirtle, J.e. Interceptor Aircraft Joe Rankin Hawker Beechcraft Hawker 8eechcraft ISSUED DAY 31 REVISED CHAMPION AEROSPACE LLC 1230 Old Norris Road YEAR MO DAY YEAR Liberty, South Carolina, U.S.A. 29657 96 09 24 09 e 2009 Champion Aerospace www.chamoionaerosoace.com PAGE NO. REVISION 30 of 34 G ~ 10 /" "\ SL2-96 FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT MAKF AIRCRAFT MODEL 166 5-33, 35-A33, 3S-B33, 35-C33, 35-C33A E33, E33A, E33C, F33, F33A, F33C, G33, H35, J35, K35, M3S, N3S, P35, 535, V35, V35A, V35B, 36, A36, A36TC, B36TC 167 Hawker Beechcraft 45(YT-34j, A45(T-34A, B-45), D4S(T-34B) 168 Hawker Beechcraft Hawker Beechcraft 50, B50, C50, D50, D50A, D50B, D50C, D50E, D50E-5990, ESO, FSO, G50, H50, J50 169 58P, 58PA, S8TC, S8TCA Hawker Beechcraft Hawker Beechcraft 60,A60, B60 170 65,6S-80,6S-88,65-A80, 65-ABO-88oo, 65-B8O 172 171 Hawker Beechcraft Hawker Beechcraft 76 95, B95, B95A, D95A, E95, 95 55, -ASS, -B55, -B55A, -BS5B (T-42Aj, -CS5, -C5SA, D55, D55A, E55, E55A, 56TC, 58, 58A 174 Hawker Beechcraft 173 77 Hawker Beechcraft F172D, F172E, Fl72F, Fl72G, Fl72H, F172K, Fl72L, Fl72M, Fl72N, Fl72P 176 Cessna Aircraft 175 F15OG, F150H, F150J, F150K, FA 150K, F150L, FA 150L, FRA 150L, Fl 50M, FRA150M, F152, FA152 177 Cessna Aircraft FRl72E, FRl72F, FRl 72G, FRl 72H, FR172J, FRl72K 178 Cessna Aircraft Cessna Aircraft F182p, F182Q FR182 Cessna Aircraft F177RG 179 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS "AFM SUPP NOJDATE AML AMEND DATE CERTIFICATE NUMBER FOR ALTERATION NUMBER "REV. NO.lDATE 3A1S CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 5A3 CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 5A4 CAR3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A23CE FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A12CE FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 3A20 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A29CE FAR 23 5L2-96 Rev.D 1/01/00 N/A 3'12/04 3A16 CAR 3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A30CE FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A4EU CARlO 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A13EU CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A18EU FAR21.29 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A42EU CAR 3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A26EU FAR 23 5L2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road YEAR YEAR MO DAY MO DAY liberty, South Carolina, U.s.A. 29657 31 of 34 G e 2009 Champion Aerospace \. 24 09 10 31 96 09 ./ www.chamnionaerosoace.com / SL2-96 FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART"" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 AIRCRAFT MAKF LINE AIRCRAFT MODFL lBO Revo, Inc. Colonial C-1, Colonial C-2 Lake LA-4, Lake LA-4A, Lake LA-4P, Lake LA-4-200, Lake Model 250 181 R22, R22 ALPHA, R22 BETA, R22MARINER 182 Robinson Robinson R44,R44 II Ruschmeyer R9O-230RG Luftfahrttechnik GmbH 184 lB3 Ryson Aviation Corp ST-100 ST-100 Ryson Aviation Corp 1BS Texas Bullet 205 Richard P.Schutze 186 269A, 269A-1, 269B, 269C, 269C-l, 269D, 188 187 Schweizer Aircraft RC-3 Sky Enterprises Inc. Sky Internationallne. 5-15, S-lT, 5-2, S-2A, 5-25, S-2B, S-2C 189 A-l,A-1A,A-1B 190 Sky Internationallne. T67M260, T67M260-T3A Ltd. 192 191 Slingsby Aviation MD3-160 SME Aero Inc. TB9, TB 200 AEROSPATIALE 194 SOCATA-Groupe 193 MS 892E-1 SO, Rallye 23SC, AEROSPATIALE SOCATA-Groupe MS893E, Rallye 23SE ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS "AFM SUPP NOInATE AML AMEND DATF CERTIFICATE NUMBER FOR AITFRATION NLJMRFR "REV. No/nATF lAB CAR 3 FAR 23,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 Hl0WE 14 CFR 27 SL2-96 Rev.D 1/01/00 N/A 3/12/04 HllNM 14CFR 27,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A77EU 14CFR21,23,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 G1NM AC21.231 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A7NM FAR 23, 36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 4A2 CAR 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 4H12 CAR6 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A-769 CAR3 SL2-96 Rev,D 1/01/00 N/A 3/12/04 A8SO FAR 23,36 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A22NM FAR 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A73EU FAR 21.29, 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 A6SEU Part 23 SL2-96 Rev.D 1/01/00 N/A 3/12/04 AS1EU FAR 21.29 SL2-96 Rev.D 1/01/00 N/A 3/12/04 7A14 CAR 10, 3 SL2-96 Rev.D 1/01/00 N/A 3/12/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION ISSUED REVISED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO Liberty, South Carolina, U.s.A. 29657 32 of 34 G e 2009 Champion Aerospace \.. 09 24 09 10 31 96 ./ www.chamoionaerosoace.com / SL2-96 '\ FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTART'" MAGNETO BOOSTER SYSTEM Date of Issuance January 24, 1997 LINE AIRCRAFT MAK" AIRCRAFT MODE 195 HW-75,10 Consolidated Vuitee Stinson Division, Aircraft Corp 196 5tits Aircraft Inc. 5A-9A (Twin-Bee) UC-l 197 5TOL Aircraft Corp. Sud-Aviation Gardan GY.80 150, GY.80-160 GY.80-180 199 198 Superior Aircraft LCA,LFA 200 Superior Aircraft V,V-2 Swift Museum GC-1A,GC-1B 201 Foundation Taylorcraft 2000, 19, F19, F21, F21A, F21 B, F22, F22A, LLC 202 F22B, F22C 203 Taylorcraft 2000, BC, BC5, BC-65, BC12-65, BC512-65, BC12-D, BC512-D, BC12-D 1, BC512-01, BC12D-85, BC512D-85, BC12D-4-B5, BC512D-4-85 204 T-35 (TE-18) William E. Quinn 44 205 King's Engineering Fellowship (TKEF) 206 PL-12fT- 300 Transfield Ply Ltd. 500, 500-A, 500-B, 5ao-U, 500-5, 520, Aircraft Corp. 207 Twin Commander 560, 560A, 560E 208 560-F,680FL(P) Aircraft Corp. 209 Twin Commander Twin Commander 700 Aircraft Corp. ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION IN5TRUalON5 'AFM 5UPP Ntl InAT" AML AMEND "AT< CERTIFICATE NUMR"R FOR A J"RATIClN N MR"R • REV. NCllnAT" A-709 CAR4a 5L2-96 Rev.D 1/01/00 N/A 3/12/04 4A31 CAR 3 5L2-96 Rev.D 1/01/00 N/A 3112/04 MEA CAR 3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A12IN CARlO 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A-730 CAR4a 5L2-96 Rev.D 1/01/00 N/A 3112/04 A-778 CAR 3 5L2-96 Rev. D 1/01/00 N/A 3/12/04 A-766 CAR4a 5L2-96 Rev.D 1/01/00 N/A 3/12/04 lA9 CAR 3 5L2-96 Rev. D 1/01/00 N/A 3/12/04 A-696 CAR 4 5L2-96 Rev.D 1/01/00 N/A 3112/04 AR20 CAR 8.30 5L2-96 Rev.D 1/01/00 N/A 3112/04 A2Wi FAR 23 FAR 36 5L2-96 Rev.D 1/01/00 N/A 3112/04 Al7NM FAR 23 5L2-96 Rev.D 1/01/00 N/A 3112/04 6Al CAR 3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 2M CAR 3 5L2-96 Rev.D 1/01/00 N/A 3/12/04 A125W FAR 23, 25 5L2-96 Rev.D 1/01/00 N/A 3112/04 CHAMPION AEROSPACE LLC PAGE NO. REVISION REVISED ISSUED 1230 Old Norris Road DAY YEAR MO DAY YEAR MO liberty, South Carolina, U.s.A. 29657 33 of 34 G e 2009 Champion Aerospace 24 09 10 31 96 09 \.. www.chamoionaerosoace.com ./ AIRCRAFT MAKf' Univair Aircraft Corp Univair Aircraft Corp Univalr Aircraft Corp Emerald Enterprises LTD. WSK PZL Mielec and OBR SK Mielec Zenair Ltd. /" LINE 210 211 212 213 214 215 • Or later FAA approved revision CHAMPION AEROSPACE LLC 96 09 09 REVISION PAGE NO. REVISED ISSUED 1230 Old Norris Road MO DAY YEAR MO DAY YEAR Liberty, South Carolina, U.S.A. 29657 ~ 2009 Champion Aerospace 34 of 34 G 24 10 31 www.championaerospace.com ..) \.. SL2-96 "' FAA APPROVED MODEL LIST (AML) NO. SA593CH CHAMPION AEROSPACE LLC FOR INSTALLING SlickSTARTTM MAGNETO BOOSTER SYSTEM Dale of Issuance January 24, 1997 AIRCRAFT Mnnf'1 108,108-1,-2,-3 (ERCDl 41 SoC, (ERCDl 415-CD A 2,A2-A,G, E,415D F-1,F-1A,M10 Model 0-1 PZLM2003 CH2000 ORIGINAL TYPE CERTIFICATION BASIS INSTALLATION INSTRUCTIONS ·AFM SUPP NO.lDATE AML AMEND DATE CERTIFICATE NIIMRf'R FOR AI Tf'RATlnN NIIMBf'R • REV. Nn.lnATE A-767 CAR3 SL2-96 Rev. 0 1/01/00 N/A 3112104 A-718 CAR4a SL2-96 Rev. 0 1/01/00 N/A 3112/04 A-787 CAR 3 SL2-96 Rev. 0 1/01/00 N/A 3112/04 A9WE CAR 3, FAR 23 SL2-96 Rev. 0 1/01/00 N/A 3112/04 A68EU FAR 23,36 SL2-96 Rev. 0 1/01/00 N/A 3/12/04 TASCH FAR21.29,23 SL2-96 Rev. 0 1/01/00 N/A 3/12/04 FAA Approved: Signed original on file at Champion Aerospace LLC Thaddeus D. Krolicki, Jr. Manager, Propulsion Branch Chicago Aircraft Certification Office Date Reissued: February 10, 2009 Date Amended: May 12, 1997, March 9,1998, April 20, 2000 March 12, 2004