PARTS MANUAL FOR WIPLINE MODEL 3450 FLOATS ON CESSNA 206

to the installation drawing package provided with the STC at the time of float installation. Additional drawing copies are available for purchase through the Wipaire Customer Service Department. P/N 1002174 Page 7 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 All references in this manual to LEFT and RIGHT are from the perspective of the pilot's seat with the floats fully installed and ready for floatplane operation. The following is a list of abbreviations that may appear in the description nomenclature fields of this manual: AB Afterbody Inbd. Inboard Amphib. Amphibious Lg. Large AR As Required Lt. Left Assy. Assembly Lwr. Lower Brkt. Bracket Opt. Optional Btm. Bottom Otbd. Outboard Bulk. Bulkhead Reinf. Reinforcement Ctr. Center Rr. Rear Cyl. Cylinder Rt. Right Ft. Front Sm. Small Ftg. Fitting SN Serial Number Fus. Fuselage Spr. Spreader Fwd Forward Upr. Upper Horiz. Horizontal Vert. Vertical Hyd. Hydraulic W.W. Wheel Well INTRODUCTION PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 8 P/N 1002174 USING THIS PARTS MANUAL COVERAGE Parts information is provided in this manual for the hulls and all "deck down" parts. For information on strut package parts and other aircraft installation items, refer to the installation drawing package provided with the STC at the time of float installation. Additional drawing copies are available for purchase through Wipaire Customer Service Department. ITEM QTY PART NO. PART DESCRIPTION - 1 1008815 ASSEMBLY BULKHEAD #1, 10000 1 1 1008797 PANEL, BULKHEAD #1 2 1 13A01156-085 DOUBLER #1 BULKHEAD 3 1 13A01357-049 CLEAT, SISTER KEEL ATTACH #1 BULKHEAD 4 1 13A01357-050 CLEAT, SISTER KEEL ATTACH #1 BULKHEAD 5 1 6A01156-054 ANGLE – TOP RAIL 6 1 6A01156-055 ANGLE – TOP RAIL 7 17 MS21047L4 NUT PLATE, SELF LOCKING To order an individual part, order the part number associated with item number. BULKHEAD #1 Name of main part in the section. Example: This part is showing the components made up in Bulkhead #1. Items with a (-) instead of a number represent the main part as an assembly. Other parts represent the parts included in the assembly. Main part image. If the image has numbers associated with it, then those numbers are item numbers shown in the table below. 7 4 5 2 1 3 6 P/N 1002174 Page 9 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 1 HULL BULKHEAD ASSEMBLIES CONTENTS HULL ASSEMBLY ..................................................................................................................................................10 BULKHEAD #1 .......................................................................................................................................................13 BULKHEAD #3 .......................................................................................................................................................14 BULKHEAD #4 .......................................................................................................................................................15 BULKHEAD #5 .......................................................................................................................................................16 BULKHEAD #6 .......................................................................................................................................................17 BULKHEAD #7 .......................................................................................................................................................18 BULKHEAD #8 .......................................................................................................................................................19 BULKHEAD #8 .......................................................................................................................................................20 BULKHEAD #9 .......................................................................................................................................................21 BULKHEAD #10 .....................................................................................................................................................22 BULKHEAD #11 .....................................................................................................................................................23 BULKHEAD #12 .....................................................................................................................................................24 BULKHEAD #13 .....................................................................................................................................................25 BULKHEAD #15 .....................................................................................................................................................26 BULKHEAD #16 .....................................................................................................................................................27 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 10 P/N 1002174 HULL ASSEMBLY P/N 1002174 Page 11 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 30A01000-329 ASSEMBLY, BULKHEAD 1, NOSE 2 1 30A01000-330 ASSEMBLY, BULKHEAD 3 3 1 30A01000-331 ASSEMBLY, BULKHEAD 4 4 1 30A01000-336 ASSEMBLY, BULKHEAD 5 5 1 30A01000-332 ASSEMBLY, BULKHEAD 6 6 1 30A01000-333 ASSEMBLY, BULKHEAD 7 7 1 34A01000-357 ASSEMBLY, BULKHEAD 8 8 1 1004914 ASSEMBLY, BULKHEAD 8, COMP 9 1 1004888 ASSEMBLY, BULKHEAD 9 10 1 30A01000-339 ASSEMBLY, BULKHEAD 10 11 1 30A01000-340 ASSEMBLY, BULKHEAD 11 12 1 30A01000-341 ASSEMBLY, BULKHEAD 12 13 1 30A01000-342 ASSEMBLY, BULKHEAD 13 14 1 34A01000-356 ASSEMBLY, BULKHEAD 15 15 1 34A01000-355 ASSEMBLY, BULKHEAD 16 16 1 30A01000-354 PANEL SPREADER BAR FWD. ASSY. 1 30A01155-031 PANEL – SPR. BAR 1 30A01352-039 ANGLE – SIDE L. 1 30A01352-040 ANGLE – SIDE R. 2 6A01359-004 ANGLE 1 AN4-5A BOLT 1 NAS1149F0463P WASHER 1 MS21044N4 NUT 17 1 30A01000-353 PANEL SPREADER BAR AFT. ASSY. 1 30A01155-031 PANEL – SPR. BAR 1 30A01352-033 ANGLE – SIDE L. 1 30A01352-034 ANGLE – SIDE R. 2 30A01156-125 ANGLE 1 AN4-5A BOLT 1 NAS1149F0463P WASHER 1 MS21044N4 NUT 18 1 30A01000-365 NOSE BUMPER (AMPHIBIAN) 1 30S01739-001 NOSE BUMPER (SEAPLANE) 2 30A01359-225 ANGLE, ATTACH NOSE BUMPER (AMPHIBIAN) 1 30S01326-034 ANGLE (SEAPLANE) 2 AN526-1032R10 SCREW (SEAPLANE) 19 1 30A03319-001 TUBE – SPR. BAR MOUNTING R. 1 30A03319-002 TUBE – SPR. BAR MOUNTING L. 6 AN5-24A BOLT 6 NAS1149D0532J WASHER 12 NAS1149D0563J WASHER PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 12 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 6 MS21044N5 NUT 20 2 34A01005-385 BAGGAGE REINFORCEMENT 4 34A01340-173 ANGLE 4 34A01340-174 ANGLE 21 2 34A01005-384 BAGGAGE REINFORCEMENT 4 34A01340-173 ANGLE 4 34A01340-174 ANGLE 22 2 34A01005-383 BAGGAGE REINFORCEMENT 4 34A01340-173 ANGLE 4 34A01340-174 ANGLE 23 1 34A01162-049 GUNWALL CAP (OUTBRD L) (NOT SHOWN) 1 34A01162-050 GUNWALL CAP (OUTBRD R) (NOT SHOWN) P/N 1002174 Page 13 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-329 ASSEMBLY, BULKHEAD, NOSE 1 1 30A01155-029 BULKHEAD #1 2 8 MS21078-4 NUT PLATE 3 1 30S01158-263 COVER – BULKHEAD SEAPLANE (NOT SHOWN) BULKHEAD #1 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 14 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-330 ASSEMBLY, BULKHEAD 3 1 1 30A01158-208 PANEL, BULKHEAD 3 2 2 30A01163-072 ANGLE, SHIM, BULKHEAD #3 3 1 30A01326-020 ANGLE, NOSE BOX, BULK 3 4 1 30A01326-021 ANGLE NOSE BOX, BULK #3 5 1 30A01359-211 ANGLE, BULKHEAD 3 6 1 30A01359-212 ANGLE, BULKHEAD 3 7 1 30A01359-213 ANGLE, BULKHEAD 3 8 1 30A01359-214 ANGLE, BULKHEAD 3 9 1 30S01158-264 COVER – BULKHEAD SEAPLANE (NOT SHOWN) BULKHEAD #3 P/N 1002174 Page 15 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-331 ASSEMBLY, BULKHEAD 4 1 1 30A01158-209 BULKHEAD #4, LH 2 1 30A01158-210 BULKHEAD #4, RH 3 1 30A01158-222 SUPPORT - BULKHEAD #4 4 1 30A01359-223 ANGLE, BULKHEAD #4, RH 5 1 30A01359-224 ANGLE, BULKHEAD #4, LT 6 2 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #4 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 16 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-336 ASSEMBLY, BULKHEAD 5 1 1 30A01155-032 PANEL, SPREADER BAR, BH 5 & 10 2 1 30A01158-211 BULKHEAD #5 - LH - FORMED 3 1 30A01158-212 BULKHEAD #5 - RH - FORMED 4 1 30A01158-223 SUPPORT - BULKHEAD #5 5 1 30A01352-037 ANGLE, SIDE, BULKHEAD 5 6 1 30A01352-038 ANGLE, SIDE, BULKHEAD 5 7 1 30A01359-221 ANGLE, BULKHEAD STN. #5 8 1 30A01359-222 ANGLE, BULKHEAD STN. #5 9 2 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #5 P/N 1002174 Page 17 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-332 ASSEMBLY, BULKHEAD 6 1 1 30A01158-213 BULKHEAD #6 - LH - FORMED 2 1 30A01158-214 BULKHEAD #6 - RH - FORMED 3 1 30A01158-224 SUPPORT - BULKHEAD #6 4 6 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #6 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 18 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-333 BULKHEAD ASSEMBLY #7 1 2 1001110 DOUBLER - SUPPORT - LH/RH BULKHEAD #7 2 1 30A01158-215 BULKHEAD - #7, LH 3 1 30A01158-216 BULKHEAD - #7, RH 4 1 30A01158-225 SUPPORT - BULKHEAD #7 5 1 30A01326-036 ANGLE - BULKHEAD #7 6 1 30A01326-037 ANGLE - BULKHEAD #7 BULKHEAD #7 P/N 1002174 Page 19 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 34A01000-357 BULKHEAD STATION #8 ASSY 1 1 34A01158-239 BULKHEAD #8 2 1 34A01158-240 BULKHEAD #8 3 1 34A01158-241 SUPPORT - BULKHEAD, #8 4 4 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #8 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 20 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1004914 ASSEMBLY, BULKHEAD 8, 3000 3450 COMP 1 1 1004912 BULKHEAD, #8, LH, 3000 3450 2 1 1004913 BULKHEAD, #8, RH, 3000 3450 3 1 1004915 SUPPORT, BULKHEAD #8, 3000 3450 4 4 6A01359-004 ANGLE - SUPPORT BULKHEAD #8 P/N 1002174 Page 21 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 1004888 ASS'Y BULKHEAD #9 1 1 1004889 BULKHEAD, #9, RIGHT, 3000 3450 2 1 1004890 SUPPORT, RH, BULKHEAD #9 3 1 1004891 BULKHEAD, #9, LEFT, 3000 3450 4 1 1005519 ATTACH, ANGLE, TOP RAIL 5 1 1005581 ANGLE, ATTACH AFT 6 1 1005582 ANGLE, ATTACH AFT 7 1 1005611 ATTACH, ANGLE, TOP RAIL BULKHEAD #9 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 22 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-339 ASSEMBLY, BULKHEAD 10 (AMPHIB) - 1 30S01000-408 ASS’Y. BULKHEAD #10 (SEAPLANE ONLY) 1 1 30A01155-032 PANEL, SPREADER BAR, BH 5 & 10 2 1 30A01158-221 BULKHEAD #10 3 1 30A01352-035 ANGLE, SIDE, BULKHEAD 10 4 1 30A01352-036 ANGLE, SIDE, BULKHEAD 10 5 4 6A01359-004 ANGLE (SEAPLANE ONLY NOT SHOWN) 6 2 30S01340-180 ANGLE (SEAPLANE ONLY NOT SHOWN) BULKHEAD #10 P/N 1002174 Page 23 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-340 BULKHEAD STAION #11 ASSY 1 1 30A01359-216 ANGLE - BULKHEAD #11 & #12 2 1 30A01359-217 ANGLE - BULKHEAD #11 & #12 3 2 6A01359-004 ANGLE, ATTACH, TOP RAIL 4 1 30A01158-204 BULKHEAD #11 BULKHEAD #11 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 24 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-341 30A01000-341 1 1 30A01158-205 BULKHEAD #12 2 1 30A01359-216 ANGLE - BULKHEAD #11 & #12 3 1 30A01359-217 ANGLE - BULKHEAD #11 & #12 4 2 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #12 P/N 1002174 Page 25 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 30A01000-342 BULKHEAD STATION #13 ASSY 1 1 30A01359-218 ANGLE - BULKHEAD #13 2 2 6A01359-004 ANGLE, ATTACH, TOP RAIL 3 1 30A01359-219 ANGLE - BULKHEAD #13 4 1 30A01158-206 BULKHEAD #13 BULKHEAD #13 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 26 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 34A01000-356 BULKHEAD STN #15 ASSY 1 1 30A01359-215 ANGLE, BULKHEAD #15 2 1 30A01359-220 ANGLE, BULKHEAD #15 3 1 34A01158-242 BULKHEAD #15 4 2 6A01359-004 ANGLE - SUPPORT BULKHEAD #15 P/N 1002174 Page 27 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 34A01000-355 ASSY, BULKHEAD STN, #16 1 1 30A01359-209 ANGLE, BULKHEAD #14, UPPER 2 1 34A01158-238 PANEL, BULKHEAD 16 3 1 4A01000-301 ASSEMBLY, MOUNT, PIVOT, WATER RUDDER 4 4 6A01359-004 ANGLE, ATTACH, TOP RAIL BULKHEAD #16 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 28 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 29 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 2 WHEEL WELL ASSEMBLY CONTENTS WHEEL WELL AREA .............................................................................................................................................30 WHEEL WELL ASSEMBLY - AMPHIBIAN ...........................................................................................................32 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 30 P/N 1002174 WHEEL WELL AREA P/N 1002174 Page 31 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 1005530 ASSEMBLY, WHEEL WELL, CENTERED, 3450 1 1 1004888 ASS'Y BULKHEAD #9 2 1 1004893 ASSEMBLY, PANEL, MAIN GEAR 3 1 1004894 ASSEMBLY, PANEL, MAIN GEAR 4 1 1004914 ASSEMBLY, BULKHEAD 8, 3450 COMP 5 2 1005520 SPACER, ATTACH, ANGLE, TOP RAIL 6 1 1005523 ASSEMBLY, CARRY THRU STRAP, RIGHT 7 1 1005524 ASSEMBLY, CARRY THRU STRAP, LEFT 8 1 1005531 GUSSET, WHEEL WELL 9 1 1005532 GUSSET, WHEEL WELL 10 1 1005542 GUSSET, WHEEL WELL, REAR 11 1 1005543 GUSSET, WHEEL WELL, REAR 12 2 1005550 SPACER, GUSSET, CARRY-THRU 13 2 1005557 SPACER, ANGLE, PANEL, MAIN GEAR 14 1 30A01000-339 ASS'Y BULKHEAD #10 15 1 30A01000-348 ASSEMBLY, PANEL, SIDE, WHEEL WELL, RH 16 1 30A01000-349 ASSEMBLY, PANEL, SIDE, WHEEL WELL, LH 17 4 6A01359-004 ANGLE, ATTACH, TOP RAIL 18 2 1005724 SWITCH, PROXIMITY PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 32 P/N 1002174 WHEEL WELL ASSEMBLY - AMPHIBIAN P/N 1002174 Page 33 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 LT. 1 30A01000-349 ASS’Y. WHEELWELL HALF L. 1 30A01158-235 PANEL – FORMED L. 1 13A01156-124 RING – COVER REINFORCEMENT 1 21A01004-101 COVER 28 AN526-632R6 SCREW 1 RT. 1 30A01000-348 ASS’Y. WHEELWELL HALF R. 1 30A01158-234 PANEL – FORMED R. 1 13A01156-124 RING – COVER REINFORCEMENT 1 21A01004-101 COVER 28 AN526-632R6 SCREW 2 1 30A01000-345 ASS’Y. WHEELWELL PANEL – OUTBR’D L. 1 30A01000-350 ASS’Y. WHEELWELL PANEL – OUTBR’D R. 3 1 30A01000-347 ASS’Y. WHEELWELL PANEL – INBR’D L. 1 30A01000-346 ASS’Y. WHEELWELL PANEL – INBR’D R. 4 1 30A01156-139 CARRY-THRU STRAP OUTBR’D L. 1 30A01156-142 CARRY-THRU STRAP OUTBR’D R. 5 1 30A01156-141 CARRY-THRU STRAP INBR’D L. 1 30A01156-140 CARRY-THRU STRAP INBR’D R. 6 1 30A01156-143 CARRY-THRU STRAP INBR’D L. 1 30A01156-138 CARRY-THRU STRAP INBR’D R. 1 30A01156-145 ANGLE – ATTACH AFT L. 1 30A01156-150 ANGLE – ATTACH AFT R. 1 30A01160-035 SHIM 2 21A01326-015 ANGLE – ATTACH FWD 7 1 30A01000-287 SAND GUARD (NOT SHOWN) L. 1 30A01000-288 SAND GUARD (NOT SHOWN) R. 8 AN526-1032R8 SCREW 4 MS21078-3 NUT PLATE 8 1 30A01569-002 MUD FLAP (NOT SHOWN) 1 30A01150-141 REINFORCEMENT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 34 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 35 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 3 SKINS, STIFFENERS, & PADDLE CONTENTS STIFFENERS .........................................................................................................................................................36 BOTTOM SKINS, DOUBLERS, & PADDLE - AMPHIBIAN .................................................................................38 BOTTOM SKINS, DOUBLERS, & PADDLE - SEAPLANE ..................................................................................40 RIGHT FLOAT SIDE SKINS..................................................................................................................................42 LEFT FLOAT SIDE SKINS ....................................................................................................................................43 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 36 P/N 1002174 STIFFENERS *Glued stiffeners were discontinued after Service Letter 211. Riveted stiffeners are compatible with floats made prior to the service letter. P/N 1002174 Page 37 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1011150 STIFFENER, SIDE SKIN, LH 2 1 1011151 STIFFENER, SIDE SKIN, RH 3 1 1011152 STIFFENER, SIDE SKIN, LH 4 1 1011153 STIFFENER, SIDE SKIN, RH 5 1 1011154 STIFFENER, SIDE SKIN, LH 6 1 1011155 STIFFENER, SIDE SKIN, RH 7 1 1011156 STIFFENER, SIDE SKIN, LH 8 1 1011157 STIFFENER, SIDE SKIN, RH 9 1 1011158 STIFFENER, SIDE SKIN, LH 10 1 1011159 STIFFENER, SIDE SKIN, RH 11 1 1011160 STIFFENER, SIDE SKIN, LH 12 1 1011161 STIFFENER, SIDE SKIN, RH 13 1 1011162 STIFFENER, SIDE SKIN, LH 14 1 1011163 STIFFENER, SIDE SKIN, RH 15 1 1011164 STIFFENER, SIDE SKIN, LH 16 1 1011165 STIFFENER, SIDE SKIN, RH 17 1 1011166 STIFFENER, SIDE SKIN, LH 18 1 1011167 STIFFENER, SIDE SKIN, RH 19 1 1011168 STIFFENER, SIDE SKIN, LH 20 1 1011169 STIFFENER, SIDE SKIN, RH 21 1 1011170 STIFFENER, SIDE SKIN, LH 22 1 1011171 STIFFENER, SIDE SKIN, RH 23 1 1011172 STIFFENER, SIDE SKIN, LH 24 1 1011173 STIFFENER, SIDE SKIN, RH 25 1 1011174 STIFFENER, SIDE SKIN, LH 26 1 1011175 STIFFENER, SIDE SKIN, RH 27 1 1011176 STIFFENER, SIDE SKIN, LH 28 1 1011177 STIFFENER, SIDE SKIN, RH 29 1 1011178 STIFFENER, SIDE SKIN, LH 30 1 1011179 STIFFENER, SIDE SKIN, RH PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 38 P/N 1002174 BOTTOM SKINS, DOUBLERS, & PADDLE - AMPHIBIAN P/N 1002174 Page 39 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 30A01000-358 STEP – BOARDING 2 2 30A01156-144 REINFORCEMENT – COVER 3 2 21A01000-427 ASSY, COVER – INSP. 2 21A01567-012 GASKET 56 AN526-632R6 SCREW – ATTACH 4 1 30A01151-103 BOTTOM SKIN FWD L. 1 30A01151-102 BOTTOM SKIN FWD R. 2 34A01150-145 BOTTOM SKIN SPLICE – AFT 5 1 34A01148-039 BOTTOM SKIN AFTERBODY L. 1 34A01148-040 BOTTOM SKIN AFTERBODY R. 1 34A01150-147 DOUBLER, AFT, BOTTOM SKIN (NOT SHOWN) 1 34A01150-148 DOUBLER, AFT, BOTTOM SKIN (NOT SHOWN) 1 1005715 DOUBLER, WHEELWELL, AFT, BTM SKN (NOT SHOWN) 1 1005716 DOUBLER, WHEELWELL, AFT, BTM SKN (NOT SHOWN) 6 1 34A01162-054 DOUBLER – GUNWALL AFT L. 1 34A01162-055 DOUBLER – GUNWALL AFT R 7 1 30A01162-045 DOUBLER – GUNWALL FWD L. 1 30A01162-046 DOUBLER – GUNWALL FWD R. 8 1 3A01158-093 BRACKET, CANOE PADDLE (NOT SHOWN) 1 3A01503-001 CLIP (NOT SHOWN) 1 6A01156-059 BRACKET, CANOE PADDLE STOP, LH (NOT SHOWN) 1 6A01156-058 BRACKET, CANOE PADDLE STOP, RH (NOT SHOWN) 2 0238-0068 PADDLE, 5-1/2 FT, BEAVER BRAND (NOT SHOWN) PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 40 P/N 1002174 BOTTOM SKINS, DOUBLERS, & PADDLE - SEAPLANE P/N 1002174 Page 41 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 30A01151-103 BOTTOM SKIN FWD L. 1 30A01151-102 BOTTOM SKIN FWD R. 2 34A01150-145 BOTTOM SKIN SPLICE – AFT 2 1 34S01148-041 BOTTOM SKIN AFTERBODY L. 1 34S01148-042 BOTTOM SKIN AFTERBODY R. 3 1 34A01162-054 DOUBLER – GUNWALL AFT L. 1 34A01162-055 DOUBLER – GUNWALL AFT R. 4 1 30A01162-045 DOUBLER – GUNWALL FWD L. 1 30A01162-046 DOUBLER – GUNWALL FWD R. 5 1 3A01158-093 BRACKET, CANOE PADDLE (NOT SHOWN) 1 3A01503-001 CLIP (NOT SHOWN) 1 6A01156-059 BRACKET, CANOE PADDLE STOP, LH (NOT SHOWN) 1 6A01156-058 BRACKET, CANOE PADDLE STOP, RH (NOT SHOWN) 2 0238-0068 PADDLE, 5-1/2 FT, BEAVER BRAND (NOT SHOWN) PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 42 P/N 1002174 RIGHT FLOAT SIDE SKINS ITEM QTY PART NO. PART DESCRIPTION 1 1 1011180 SKIN, SIDE, FWD, LH 2 1 1011181 SKIN, SIDE, FWD, RH 3 1 1011182 SKIN, SIDE, MID, INBRD, RH 4 1 1011185 SKIN, SIDE, MID, OUTBRD, RH 5 1 1011186 SKIN, SIDE, MID, INBRD, RH 6 1 1011189 SKIN, SIDE, MID, OUTBRD, RH 7 1 1011190 SKIN, SIDE, AFT, INBRD, RH 8 1 1011193 SKIN, SIDE, AFT, OUTBRD, RH 9 1 1011331 SKIN, SIDE, MID, OUTBRD, RH 10 1 1011332 SKIN, SIDE, MID, INBRD, RH P/N 1002174 Page 43 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 LEFT FLOAT SIDE SKINS ITEM QTY PART NO. PART DESCRIPTION 1 1 1011180 SKIN, SIDE, FWD, LH 2 1 1011181 SKIN, SIDE, FWD, RH 3 1 1011183 SKIN, SIDE, MID, INBRD, LH 4 1 1011184 SKIN, SIDE, MID, OUTBRD, LH 5 1 1011187 SKIN, SIDE, MID, INBRD, LH 6 1 1011188 SKIN, SIDE, MID, OUTBRD, LH 7 1 1011191 SKIN, SIDE, AFT, INBRD, LH 8 1 1011192 SKIN, SIDE, AFT, OUTBRD, LH 9 1 1011330 SKIN, SIDE, MID, OUTBRD, LH 10 1 1011333 SKIN, SIDE, MID, INBRD, LH PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 44 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 45 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 4 TOP DECK ASSEMBLY CONTENTS TOP DECK - AMPHIBIAN .....................................................................................................................................46 TOP DECK - SEAPLANE ......................................................................................................................................49 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 46 P/N 1002174 TOP DECK - AMPHIBIAN P/N 1002174 Page 47 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A01148-015 SKIN – FWD SECTION L. 1 1005565 SKIN – FWD SECTION L. (ALUM. GEAR) 1 34A01148-016 SKIN – FWD SECTION R. 1 1005566 SKIN – FWD SECTION R. (ALUM. GEAR) 2 1 34A01148-017 SKIN – AFT SECTION L. 1 34A01148-018 SKIN – AFT SECTION R. 3 1 21A01002-131 SUPPORT – INSP. COVER – SMALL A/R 1002481 NUT – TINNERMAN & INSULATOR 4 7 21A01000-258 INSP. COVER – LARGE - W/ ANGLE & GASKETS A/R SS TATP 8 X 5/8 SCREW – ATTACH 7 1001437 SEAL – GASKET ONLY 5 2 21A01000-284 INSP. COVER – SMALL & GASKETS A/R SS TATP 8 X 5/8 SCREW – ATTACH 2 1001728 SEAL – GASKET ONLY 6 1 30A01002-203 COVER – GEAR INDICATOR L. 1 1005561 COVER – GEAR INDICATOR L. (ALUM. GEAR) 1 30A01002-202 COVER – GEAR INDICATOR R. 1 1005560 COVER – GEAR INDICATOR R. (ALUM. GEAR) 1 10A3-6338-1 PLACARD – DOWN - LAND 1 10A3-6338-2 PLACARD – UP - WATER 2 2600-3 SCREW – CAM - LOK 4 1126000-5 SCREW – CAM – LOK 6 212-12N RECEPTACLE – CAM – LOK 7 1 30A01162-042 JAMB – BAGGAGE DOOR 1 1001573 JAMB – BAGGAGE DOOR, HINGE SIDE 8 1 30A01000-324 ASSY – BAGGAGE DOOR 1 30A01162-041 COVER - SKIN 1 30A01741-006 HINGE 1 30A01004-145 STIFFENER – DOOR 2 30A01004-144 STIFFENER - DOOR 2 4A01004-049 STIFFENER ENDS 2 3A01206-001 RETAINER - LOCK 2 3A01273-004 LOCK PIN 2 3A01702-004 CATCH – LATCH 2 3A01525-003 LOCK SPRING 2 1002663 RING – OPENING 1 1001499 SEAL – GASKET (NOT SHOWN) 1 30A01741-007 HINGE 1 1002186 HINGE PIN 2.04 18 01692-0410 POP RIVET 2 SS 10/32 X ½ INCH SCREW PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 48 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 9 1 34A01326-031 TOP RAIL – FWD L. 1 34A01326-032 TOP RAIL – FWD R. 10 1 34A01326-033 TOP RAIL – AFT L. 1 34A01326-034 TOP RAIL – AFT R. 11 1 30A01340-175 STIFFENER 12 1 30A01340-176 STIFFENER 13 1 30A01340-177 STIFFENER 14 2 30A01326-032 STIFFENER 15 A/R 30A01326-022 STIFFENER 16 2 30A01326-030 STIFFENER – BAGGAGE DOOR 17 2 30A01213-007 CLEAT – TIE DOWN 4 AN4-7A BOLT 4 NAS1149D0463J WASHER 4 MS21083N4 NUT 18 1 30A01000-359 INSP. COVER – LRG. W/ ANGLE, & GASKET LEFT 1 30A01000-360 INSP. COVER – LRG. W/ ANGLE, & GASKET RT. A/R SS TATP 8 X 5/8 SCREW – ATTACH 1 1001437 GASKET ONLY P/N 1002174 Page 49 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 TOP DECK - SEAPLANE PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 50 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A01148-015 SKIN – FWD SECTION L. 1 34A01148-016 SKIN – FWD SECTION R. 2 1 34S01148-043 SKIN – AFT SECTION L. 1 34S01148-044 SKIN – AFT SECTION R. 3 1 21A01002-131 SUPPORT – INSP. COVER – SMALL A/R 1002481 NUT – TINNERMAN & INSULATOR 4 8 21A01000-258 INSP. COVER – LARGE - W/ ANGLE & GASKETS A/R SS TATP 8 X 5/8 SCREW – ATTACH 8 1001437 SEAL – GASKET ONLY 1 21A01340-103 STIFFENERS – ANGLE 5 2 21A01000-284 INSP. COVER – SMALL & GASKETS A/R SS TATP 8 X 5/8 SCREW – ATTACH 2 1001728 SEAL – GASKET ONLY 6 1 30A01162-042 JAMB – BAGGAGE DOOR 1 1002065 JAMB – BAGAGE DOOR, HINGE SIDE 7 1 30A01000-324 ASSY – BAGGAGE DOOR 1 30A01162-041 COVER - SKIN 1 30A01741-006 HINGE 1 30A01740-007 HINGE 1 30A01004-145 STIFFENER – DOOR 2 30A01004-144 STIFFENER - DOOR 2 4A01004-049 STIFFENER ENDS 2 3A01206-001 RETAINER - LOCK 2 3A01273-004 LOCK PIN 2 3A01702-004 CATCH – LATCH 2 3A01525-003 LOCK SPRING 2 1002663 RING – OPENING 1 1001499 SEAL – GASKET (NOT SHOWN) 1 1002186 HINGE PIN 2.04 18 01692-0410 POP RIVET 8 2 SS 10/32 X ½ INCH SCREW 1 34A01326-032 TOP RAIL – FWD R. 9 1 34A01326-033 TOP RAIL – AFT L. 1 34A01326-034 TOP RAIL – AFT R. 10 1 30A01340-175 STIFFENER 11 1 30A01340-176 STIFFENER 12 1 30A01340-177 STIFFENER 13 2 30A01326-032 STIFFENER 14 A/R 30A01326-022 STIFFENER 15 2 30A01326-030 STIFFENER – BAGGAGE DOOR 16 2 30A01213-007 CLEAT – TIE DOWN P/N 1002174 Page 51 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 4 NAS1149D0463J WASHER 4 MS21083N4 NUT 17 1 21S01000-399 INSP. COVER – MED. W/ GASKET A/R SS TATP 8 X 5/8 SCREW ATTACH 1 21S01567-013 GASKET ONLY 18 1 30A01000-360 INSP. COVER – LRG. W/ ANGLE & GASKET LEFT 1 30A01000-359 INSP. COVER – LRG. W/ ANGLE & GASKET RIGHT A/R SS TATP 8 X 5/8 SCREW ATTACH 1 1001437 GASKET PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 52 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 53 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 5 EXTRUSIONS CONTENTS HULL EXTRUSIONS - AMPHIBIAN .....................................................................................................................54 HULL EXTRUSIONS - SEAPLANE ......................................................................................................................56 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 54 P/N 1002174 HULL EXTRUSIONS - AMPHIBIAN P/N 1002174 Page 55 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A01324-007 GUNWALL – L. INBOARD 1 34A01324-008 GUNWALL – R. INBOARD 1 34A01324-009 GUNWALL – L. OUTBOARD 1 34A01324-010 GUNWALL – R. OUTBOARD 2 1 34A01394-145 CHINE - FWD L. 1 34A01394-146 CHINE – FWD R. 3 1 34A01395-003 CHINE – AFTERBODY L. 1 34A01395-004 CHINE – AFTERBODY R. 4 1 34A01377-002 KEEL - MAIN 1 3A01200-001 STRIP, WEAR 5 1 34A01425-002 KEEL - AFTERBODY 6 1 34A01361-041 SISTER KEEL – FWD L. 1 34A01361-042 SISTER KEEL – FWD R. 7 1 34A01361-043 SISTER KEEL – AFT L. 1 34A01361-044 SISTER KEEL – AFT R. 8 1 34A01342-011 SISTER KEEL – OUTER L. 1 34A01342-012 SISTER KEEL – OUTER R. PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 56 P/N 1002174 HULL EXTRUSIONS - SEAPLANE P/N 1002174 Page 57 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A01324-007 GUNWALL – L. INBOARD 1 34A01324-008 GUNWALL – R. INBOARD 1 34A01324-009 GUNWALL – L. OUTBOARD 1 34A01324-010 GUNWALL – R. OUTBOARD 2 1 34A01394-145 CHINE - FWD L. 1 34A01394-146 CHINE – FWD R. 3 1 34A01395-003 CHINE – AFTERBODY L. 1 34A01395-004 CHINE – AFTERBODY R. 4 1 34A01377-002 KEEL - MAIN 1 3A01200-001 STRIP, WEAR 5 1 34S01425-002 KEEL - AFTERBODY 6 1 34A01361-041 SISTER KEEL – FWD L. 1 34A01361-042 SISTER KEEL – FWD R. 7 1 34S01361-045 SISTER KEEL – AFT L. 1 34S01361-046 SISTER KEEL – AFT R. 8 1 34A01342-011 SISTER KEEL – OUTER L. 1 34A01342-012 SISTER KEEL – OUTER R. 9 1 30S01163-085 ANGLE SUPPORT – AFTERBODY L. 1 30S01163-086 ANGLE SUPPORT – AFTERBODY R. PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 58 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 59 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 6 PUMPER TUBE INSTALLATION CONTENTS PUMPER TUBE .....................................................................................................................................................60 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 60 P/N 1002174 PUMPER TUBE ITEM QTY PART NO. PART DESCRIPTION 1 1 1011004 ASSEMBLY, CUP, PUMPOUT, DUCKBILL 1 4A01749-001 CUP – PUMPOUT ALUM. 1 1011808 RETAINER, VALVE, DUCKBILL, PUMPOUT PLUG 2 1 57134 CLAMP – UPPER END 3 1 3A01158-003 CLAMP – LOWER END 4 1 1011870 VALVE, DUCKBILL (NEW VERSION) 1 2111 STOPPER – PUMPER TUBE 5 1 30A01618-064 PUMPOUT TUBE 18.5 IN. 1 30A01618-065 PUMPOUT TUBE 24.5 1 30A01618-066 PUMPOUT TUBE 26.5 1 30A01618-067 PUMPOUT TUBE 29.0 1 30A01618-068 PUMPOUT TUBE 23.0 1 30A01618-069 PUMPOUT TUBE 26.5 1 30A01618-070 PUMPOUT TUBE 22.0 1 30A01618-071 PUMPOUT TUBE 18.0 1 30A01618-072 PUMPOUT TUBE 15.5 1 30A01618-073 PUMPOUT TUBE 12.5 1 30A01618-074 PUMPOUT TUBE 25.0 P/N 1002174 Page 61 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 7 WATER RUDDER, STEERING, AND RETRACT CABLES CONTENTS WATER RUDDER INSTALLATION.......................................................................................................................62 STEERING CABLES .............................................................................................................................................64 RETRACT CABLES ...............................................................................................................................................65 STEERING & RETRACT SYSTEM INSTALLATION ...........................................................................................66 RETRACT HANDLE ASSEMBLY .........................................................................................................................68 ELECTRO-HYDRAULIC WATER RUDDER RETRACTION SYSTEM (T206H) ...............................................70 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 62 P/N 1002174 WATER RUDDER INSTALLATION P/N 1002174 Page 63 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 4A08000-094 ASS’Y - BLADE 1 4A08000-062 BLADE 2 1 4A08197-009 ARM – BLADE – L.H. 1 4A08197-008 ARM – BLADE – R.H. 3 2 AN4-10A BOLT – ARM ATTACH A/R NAS1149D0463J WASHER 2 NAS679A4W NUT 4 2 4A08205-003 RUDDER STOP - UP 2 4A08205-004 STOP, WATER RUDDER (SOLOY ONLY) 4 AN526-1032R10 SCREW 4 MS35333-39 WASHER - LOCK 5 1 4A08000-097 ASS’Y – WATER RUDDER PIVOT 6 2 3A08525-001 SPRING, RUDDER RETRACT 7 1 AN6C34A BOLT – WATER RUDDER HINGE A/R NAS1149D0663J WASHER 1 MS21083N6 NUT 8 2 3A08606-001 ROLLER – RETRACT CABLE - LOWER 2 3A08502-001 BUSHING - ROLLER 2 AN3C10A BOLT – ROLLER (HEX HD. S.S.) 6 NAS679A3W NUT 9 1 3A08650-001 BOOT – WATER RUDDER 10 1 3A08605-001 GUIDE – WATER RUDDER CABLE 11 4 03DU-04 BEARING 12 2 AN3C10A BOLT – RUDDER POST HINGE A/R NAS1149D0363J WASHER 2 NAS679A3W NUT 13 1 4A01000-301 CASTING – PIVOT – WATER RUDDER 14 1 AN3-6A BOLT – RUDDER TO ARM ATTACH A/R NAS1149D0363J WASHER 1 MS21044N3 NUT 15 2 AN526-428R16 SCREW – SPRING ATTACH A/R NAS1149D0363J WASHER 4 NAS679A3W NUT 16 1 MS20392-2C11 PIN - CLEVIS A/R NAS1149D0316J WASHER 1 MS24665-151 COTTER PIN 17 1 AN526-1032R16 SCREW – RUDDER STOP - DOWN 1 NAS679A3W NUT 18 1 34A08000-161 ASS’Y – CABLE – RETRACT 19 4 06DU08 BEARING – NYLINER 20 1 1032 X 2” SS BOLT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 64 P/N 1002174 STEERING CABLES ITEM QTY PART NO. PART DESCRIPTION 1 2 34A08000-160 CABLE ASSY. STEERING 2 1 1003106 ASSEMBLY - CABLE, 80.25 INCHES 3 1 34A08000-158 CABLE ASSY. BALANCE RT. 4 1 34A08000-159 CABLE ASSY. BALANCE LT. P/N 1002174 Page 65 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 RETRACT CABLES ITEM QTY PART NO. PART DESCRIPTION 1 1 21A08000-137 ASSEMBLY, RETRACT CABLE 2 2 4A08000-075 CABLE ASSY, RETRACT, FUSELAGE 3 2 34A08000-161 CABLE ASSY. RETRACT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 66 P/N 1002174 STEERING & RETRACT SYSTEM INSTALLATION P/N 1002174 Page 67 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 3A08151-046 PULLEY BRACKET 2 4 AN526-1032-8 SCREW 4 MS3533-38 WASHER 4 MS27130A14 RIVNUT 3 1 MS20219-2 PULLEY 1 AN4-7A BOLT 1 NAS1149D0463J WASHER 1 MS21044N4 NUT 4 A/R MS21251B3S TURNBUCKLE BARREL 5 1 NAS1149F0332P WASHER 1 AN381-2-8 COTTER PIN 1 MS20392-2-15 CLEVIS PIN 6 4 4A08151-093 PULLEY BRACKET 4 MS29219-2 PULLEY 4 AN4-7A BOLT 4 NAS1149D0463J WASHER 4 MS21044N4 NUT 7 4 AN3-25A BOLT 4 NAS1149F0363P WASHER 4 MS21044N3 NUT 8 8 AN42B4A EYE BOLT 8 NAS1149F0363P WASHER 8 MS21044N3 NUT 9 1 4A08340-032 ANGLE 10 2 4A08205-003 STOP (NOT REQUIRED FOR 206H) 2 4A08205-004 STOP (SOLOY MKI ONLY) 2 1003822 STOP (SOLOY MKII ONLY) 11 8 AN526-1032-10 SCREW 8 NAS1149F0332P WASHER 8 MS21044N3 NUT 12 2 0742016-1 SPRING (CESSNA) ALT. FOR FACTORY SWEDGING OF CABLE ENDS A/R MS21252-3RS FORKS A/R MS21255-3LS OR -3RS EYES A/R AN100-3 THIMBLES A/R MS51844-43 NICOPRESS A/R MS20115-3 SHACKLES A/R RM690 CABLES - STAINLESS STEEL AIRCRAFT 3/32 X 7 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 68 P/N 1002174 RETRACT HANDLE ASSEMBLY P/N 1002174 Page 69 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 23A08000-162 ASSEMBLY, RETRACT HANDLE 1 1 21A08000-137 ASSEMBLY, RETRACT CABLE 2 1 3A08003-015 BRACKET - SIDE, WATER RETRACT, LH 3 1 3A08003-016 BRACKET - SIDE, WATER RETRACT, RH 4 2 3A08613-001 PLASTIC TUBE 5 2 3A08702-006 PIVOT PIN 6 1 3A3-1115-1 PLACARD, WATER RUDDER RETRACT 7 1 3A3-1115-2 PLACARD, WATER RUDDER RETRACT 8 1 3A3-1115-3 PLACARD, WATER RUDDER RETRACT 9 1 4A08414-003 HANDLE, WATER RUDDER RETRACT 10 1 4A08506-002 SWIVEL, RETRACT CABLE HANDLE 11 2 AN3-10A BOLT 12 1 AN4-10A BOLT 13 1 MS20219-2 PULLEY 14 2 MS20470AD4 RIVET, UNIVERSAL HEAD 15 1 MS24665-285 COTTER PIN 16 8 NAS1149F0332P WASHER 17 2 NAS1149F0432P WASHER 18 2 NAS1149F0463P WASHER 19 4 NAS679-A3W KAYNAR NUT 20 1 NAS679-A4W KAYNAR NUT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 70 P/N 1002174 ELECTRO-HYDRAULIC WATER RUDDER RETRACTION SYSTEM (T206H) P/N 1002174 Page 71 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 4 1006668 SOLENOID, 2 WAY, 2 POSITION 2 2 1006672 MOUNT, CYL, HYD. WATER RUDDER RETRACT 3 2 1006673 SUPPORT, CYL. MOUNT, HYD, WATER RUDDER RETRACT 4 1 1006674 ASSY, HYDRAULIC LINE, SOLENOID TO SOLENOID 5 1 1006675 ASSY, HYDRAULIC LINE SOLENOID TO CYL 6 2 1006676 ASSY, HYDRAULIC LINE, SOLENOID TO SOLENOID 7 1 1006677 ASSY, HYDRAULIC LINE, SOLENOID TO SOLENOID 8 1 1006678 ASSY, HYDRAULIC LINE, SOLENOID TO CYL. 9 1 4-140 4 LUG TERMINAL BLOCK 10 2 7D-7 CLIPPARD CYLINDER 11 2 AN3-3 BOLT 12 2 AN4-7A BOLT 13 4 AN5-26A BOLT 14 2 AN526C632R8 SCREW, MACHINE, TRUSS HEAD 15 8 AN526C832R8 SCREW, MACHINE, TRUSS HEAD 16 2 AN816-2D NIPPLE, FLARED TUBE AND PIPE THREAD 17 1 AN816-3D NIPPLE, FLARED TUBE AND PIPE THREAD 18 3 AN822-3D ELBOW 19 2 AN911-1D NIPPLE 20 6 AN914-1D ELBOW 90, INTERNAL EXTERNAL 21 2 AN917-1D TEE, INTERNAL PIPE THREAD 22 1 JSV-2FFF VALVE, SWIVEL 23 6 MS20826-3D FITTING TEE 24 2 MS20826-4D FITTING, TEE 25 2 MS21044N06 NUT 26 2 MS21044N3 NUT 27 2 MS21044N4 NUT 28 4 MS21044N5 NUT 29 8 MS35333-39 STAR WASHER 30 4 NAS1149F0332P WASHER 31 4 NAS1149F0432P WASHER 32 8 NAS1149F0563P WASHER 33 2 46105K61 CHECK VALVE 34 2 AN910-1D COUPLING, PIPE THREAD 35 2 MS35489-14 GROMMET 36 1 AN824-2D FITTING, TEE 37 2 1006669-3 ASSEMBLY, HYD. HOSE 38 2 1006669-4 ASSEMBLY, HYD. HOSE 39 1 1006669-5 ASSEMBLY, HYD. HOSE 40 1 1006669-6 ASSEMBLY, HYD. HOSE 41 1 1006669-7 ASSEMBLY, HYD. HOSE PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 72 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 42 1 1006669-8 ASSEMBLY, HYD. HOSE 43 1 10066671 PLACARD, WATER RUDDER CONTROL 44 1 29C2739 SWITCH, TOGGLE 45 A/R 22759-16-20-9 WIRE, 20 AWG, WHITE 46 3 MS21919WDG14 CLAMP P/N 1002174 Page 73 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 8 LANDING GEAR CONTENTS NOSE GEAR RETRACTION ASSEMBLY............................................................................................................74 NOSE GEAR LOWER ASSEMBLY ......................................................................................................................76 NOSE WHEEL ASSEMBLY (GROVE)..................................................................................................................78 NOSE WHEEL ASSEMBLY (PARKER) ................................................................................................................80 MAIN GEAR INSTALLATION ................................................................................................................................82 MAIN GEAR RETRACTION ..................................................................................................................................84 MAIN GEAR HYDRAULIC INSTALLATION .........................................................................................................86 MAIN GEAR WHEEL ASSEMBLY ........................................................................................................................88 MAIN GEAR SHOCK ASSEMBLY ........................................................................................................................91 MAIN GEAR WITHOUT WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34315A & 34316A AND LATER ............................................................................................................................................................93 MAIN GEAR WITHOUT WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34313A & 34314A AND PRIOR............................................................................................................................................................95 MAIN GEAR WITH WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34315A & 34316A AND LATER.....................................................................................................................................................................97 MAIN GEAR WITH WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34313A & 34314A AND PRIOR.....................................................................................................................................................................99 MAIN GEAR ASSEMBLY ....................................................................................................................................101 MAIN GEAR ROTARY ACTUATOR ASSEMBLY ...............................................................................................103 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 74 P/N 1002174 NOSE GEAR RETRACTION ASSEMBLY P/N 1002174 Page 75 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - - 30A07000-017 ASSEMBLY, NOSE BOX, 3000/3450 1 1 1002572 CYLINDER, NOSE GEAR, 3000/3450 2 1 1005837 END, NOSE GEAR TRACK LEFT 3 1 1005838 END, NOSE GEAR TRACK, RIGHT 4 1 1005857 NOSE BOX, 3000 FLOAT 5 1 21A07032-005 LINK - TROLLEY, NOSE GEAR 6 1 21A07094-002 END - ROD, CYLINDER, NOSE GEAR 7 1 21A07187-009 TROLLEY - NOSE GEAR 8 1 21A07237-002 END CAP, NOSE BOX 9 1 21A07359-194 EXTRUSION, ANGLE 10 1 21A07509-007 AXLE, TROLLEY LINK 11 1 30A07567-011 GASKET, COVER, NOSE BOX, 2100 AND 3000 12 2 34A07509-008 AXLE, TROLLEY 13 2 3A07530-001 BEARING - TROLLEY, NOSE GEAR 14 4 3A07604-001 BLOCK, SLIDE, TROLLEY, NOSE GEAR 15 2 5100-46-H SNAP RING 16 1 8A01008-080 COVER, BULKHEAD HYD CYL. HOLE 17 1 AN316-5R NUT 18 2 AN4-53A BOLT 19 8 AN4-5A BOLT 20 2 AN4-6A BOLT 21 4 AN526-1032R4 SCREW, MACHINE, TRUSS HEAD 22 1 AN816-4D NIPPLE, FLARED TUBE AND PIPE THREAD 23 1 MS20822-4D ELBOW 24 10 MS21044N4 NUT 25 2 MS21078-4 NUT PLATE 26 4 MS35333-39 STAR WASHER 27 12 NAS1149D0416J WASHER 28 12 NAS1149D0463J WASHER 29 2 NAS679-A4W KAYNAR NUT 30 10 AN4-5A BOLT (NOT SHOWN) 10 NAS1149D0416J WASHER (NOT SHOWN) 10 MS21044N4 NUT (NOT SHOWN) 31 1 34A06656-001 NOSE SPRING (NOT SHOWN) 32 1 MS35489-23 GROMMIT (NOT SHOWN) 33 2 3A07005-178 CLIP, SWITCH, NOSE & MAIN PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 76 P/N 1002174 NOSE GEAR LOWER ASSEMBLY P/N 1002174 Page 77 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1095K41 COMMON GREASEZERK 2 1 21A06160-053 PRESSURE PLATE 3 1 21A06194-005 BLOCK - SPRING 4 1 21A06213-006 TOW HOOK NOSE GEAR 5 1 21A06237-001 BEARING PLATE, LOWER, NOSE GEAR 6 1 21A06318-005 BLOCK - PIVOT, NOSE GEAR 7 1 21A06475-006 FRICTION CUP 8 1 3A06476-001 PIN, ANTIROTATION 9 1 21A06605-002 PLUNGER- NOSE WHEEL, 21, 23, 3, 34 10 1 34A06656-001 SPRING NOSE GEAR 11 1 21A06705-005 PRESSURE SPRING 12 1 30A06000-024 ASSEMBLY, - PIVOT AND FORK, NOSE GEAR 13 1 30A06702-016 BOLT - MODIFIED, PIVOT BLOCK 14 1 3A06602-001 THRUST WASHER 15 1 9528K15 1/4" CHROME BALL BEARING 16 2 AN5-15A BOLT 17 2 AN5-17A BOLT 18 1 MS28775-111 O-RING 19 1 M62-350 SPRING 20 1 MS16997-60 BOLT 21 1 MS21044N4 NUT 22 4 MS21044N5 NUT 23 4 MS35333-39 STAR WASHER 24 1 MS35649-2252 NUT 25 2 NAS1149D0463J WASHER 26 4 NAS1149F0532P WASHER 27 4 NAS1149F0563P WASHER 28 4 NAS1352-3-18P BOLT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 78 P/N 1002174 NOSE WHEEL ASSEMBLY (GROVE) P/N 1002174 Page 79 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1005927 BOLT, MODIFIED, AXLE, NOSE GEAR 2 2 1005928 SPACER 3 1 1006679 ASSEMBLY, NOSE WHEEL 3.1 1 49-12AF-001 WHEEL ASSEMBLY, GROVE 3.1.1 1 010-019 GREASE RETAINER 3.1.2 2 471570 SEAL, TIMKEN (EQUIVALENT TO GROVE OEM P/N 010-026) 3.1.3 1 015-020A WHEEL HALF INNER 3.1.4 1 016-020AF WHEEL HALF OUTER 3.1.5 2 A4050 BEARING CORE 3.1.6 2 A4138 BEARING CONE 3.1.7 3 AN4-23A BOLT 3.1.8 3 MS21044N-4 NUT 3.1.9 2 MS28775-029 O-RING 3.1.10 6 NAS1149F0416 WASHER 3.2 1 XA1AB* TUBE 3.3 1 AD1B2* TIRE 4 1 1095K41 COMMON GREASEZERK 5 1 3A06702-003 MODIFIED WASHER 6 1 MS21083N8 NUT 7 1 NAS1149D0863J WASHER * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 80 P/N 1002174 NOSE WHEEL ASSEMBLY (PARKER) P/N 1002174 Page 81 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1095K41 COMMON GREASEZERK 2 2 3A06259-001 SPACER - NOSE WHEEL - SMALL FLOAT 3 1 3A06702-002 BOLT, MODIFIED, AXLE, NOSE GEAR 4 1 3A06702-003 MODIFIED WASHER 5 1 30A06000-025 NOSE WHEEL ASSEMBLY 5.1 1 D-30380 PARKER WHEEL ASSEMBLY 5.1.1 1 068-30373 GASKET 5.1.2 2 161-30382 WHEEL HALF 5.1.3 3 AN4-7A BOLT 5.1.4 3 MS21044N4 NUT 5.1.5 6 NAS1149F0432P WASHER 5.2 1 AD1B2* TIRE 5.3 1 XA1AB* TUBE 5.4 2 A4050 BEARING CORE 5.5 2 A4138 BEARING CONE 6 1 MS21083N8 NUT 7 1 NAS1149D0863J WASHER * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 82 P/N 1002174 MAIN GEAR INSTALLATION P/N 1002174 Page 83 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 30A05114-008 TRACK - MAIN GEAR - RIGHT 2 1 30A05003-085 SPACING PLATE 3 1 30A05000-039 ASS’Y. ARM RETRACT 4 2 NAS6204-17 BOLT 5 4 NAS1149F0432P WASHER 6 2 MS21083N4 NUT 7 4 AN3-5A BOLT 8 4 NAS1149D0316J WASHER 9 4 MS21044N3 NUT 10 2 10DU12 BUSHING 11 2 12DU12 BUSHING 12 1 30A05114-007 TRACK - MAIN GEAR - LEFT 13 1 30A05000-027 ASS'Y - ARM - GEAR INDICATOR 14 1 30A05000-038 MAIN GEAR BOLT ASS'Y - LOWER 14.1 1 30A05558-001 MODIFIED BOLT - DRAG LINK ATTACH (OLD STYLE NON REBUILDABLE HYDRAULIC ACTUATORS) 1 1005973 MODIFIED BOLT, DRAG LINK ATTACH (NEW STYLE HYDRAULIC ACTUATOR - MUST BE USED PER SERVICE LETTER 97) 14.2 1 30A04574-001 COUPLING - MAIN GEAR 15 8 AN3-6A BOLT 16 8 NAS1149D0316J WASHER 17 8 NAS1149D0363J WASHER 18 8 MS21044N3 NUT 19 2 NAS1149D1016J WASHER 20 2 93783A033 SEALING WASHER 21 1 MS21025-24 NUT, AXLE 22 1 MS24665-351 COTTER PIN 23 1 30A05702-020 BOLT PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 84 P/N 1002174 MAIN GEAR RETRACTION P/N 1002174 Page 85 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 30A05000-042 ASS’Y. ARM RETRACT - DRAG LINK 1.1 1 30A05000-041 ASS’Y. ARM RETRACT - DRAG LINK 1.2 1 3A05701-001 CYLINDERICAL MAGNET 1.3 1 1032 NFX 3/16 SET SCREW, 10-32 X 3/16 S.S. CP 1.4 1 30A05214-007 PROX. SWITCH HOLDER 1.5 2 1095K41 COMMON GREASEZERK 2 NAS1149F0463P WASHER 2 1 30A04000-100 ASS’Y. SHOCK STRUT 2.1 1 30A04000-093 ASSEMBLY - END SHOCK STRUT - UPPER 2.2 1 30A04000-120 ASSEMBLY - END SHOCK STRUT - LOWER 2.3 1 1002090 DUAL BUSHING ASSEMBLY 2.4 1 1001103 BUSHING ASSEMBLY 2.5 1 MS24665-151 COTTER PIN 2.6 1 30A04476-004 PIN - RETAINING, SHOCK STRUT 2.7 1 30A04459-002 SLEEVE - SHOCK STRUT RETAINER 2.8 2 1095K41 COMMON GREASEZERK 2.9 2 NAS1149D0416J WASHER 2.10 2 NAS1149D0463J WASHER 3 1 30A04000-091 DRAG LINK - MAIN GEAR 3.1 2 10FDU10 BUSHING 3.2 1 30A04000-091 ASS’Y. DRAG LINK, MAIN GEAR 4 1 30A04454-007 SHAFT - AXLE - SHOCK STRUT 5 2 21A05520-003 ROLLER, SHOCK STRUT - RETRACT 6 1 30A05702-016 BOLT - DRAG LINK 7 1 NAS1149F1063P WASHER 8 1 MS21083N10 NUT 9 2 1095K41 COMMON GREASEZERK 10 1 30A04475-006 BUSHING 11 1 6A04263-003 INSERT GREASE WHEEL 2 MS28775-214 "O" RING 1 1095K41 COMMON GREASEZERK PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 86 P/N 1002174 MAIN GEAR HYDRAULIC INSTALLATION P/N 1002174 Page 87 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1002573* CYLINDER-MAIN GEAR, 3000-3450 2 1 21A05000-016 WELDMENT, ARM RETRACT, RIGHT 3 1 21A05525-008 SPRING - GEAR 4 1 30A05252-001 SPACER - HYDRAULIC CYLINDER 5 1 30A05460-001 CLEVIS - RETRACT ARM, MAIN GEAR, (3000/3450) 6 1 30A05558-001 MODIFIED BOLT - DRAG LINK ATTACH (OLD STYLE NON REBUILDABLE HYDRAULIC ACTUATORS) 1 1005973 MODIFIED BOLT, DRAG LINK ATTACH (NEW STYLE HYDRAULIC ACTUATOR - MUST BE USED PER SERVICE LETTER 97) 7 1 AN316-5R NUT 8 1 AN42-4A EYE BOLT 9 4 AN515-4R6 SCREW, MACHINE 10 1 AN6-13A BOLT 11 1 AN665-46RS TERMINAL, FLY WIRE 12 1 AN970-3 WASHER 13 2 HAMLIN 59135-20 HAMLIN MAGNETIC SWITCH 14 1 MS20002C6 WASHER - COUNTER SUNK 15 1 MS20392-4C25 CLEVIS PIN 16 1 MS20392-4C29 CLEVIS PIN 17 2 MS20822-4-4D ELBOW 18 4 MS21044N04 NUT 19 1 MS21044N3 NUT 20 2 MS24665-283 COTTER PIN 21 1 NAS1149D0363J WASHER 22 1 NAS1149F0532P WASHER 23 2 NAS1149F0563P WASHER 24 2 NAS1149F0632P WASHER * If this style actuator is replacing the old style non rebuildable cylinder, reference Service Letter 97 for replacement and the correct drag link attach modified bolt. PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 88 P/N 1002174 MAIN GEAR WHEEL ASSEMBLY P/N 1002174 Page 89 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 8A04000-031 WHEEL ASS’Y. (W/ TIRE & TUBE) 2 1 40-418-3 WHEEL ASS’Y. (BOTH HALVES) (NAMEPLATE READS "40-418B", INCLUDES ITEMS 3-10) 1 40-418 (ALT) WHEEL ASS’Y. (ALTERNATE, INCLUDES ITEMS 3-10) 3 1 067-14700 SPACER – GREASE DAM 4 1 164-24501 DISC – BRAKE, CHROME (ORIG EQUIP FOR 40-418-3) 1 164-24500 DISC – BRAKE, NON-CHROME (ORIG EQUIP FOR 40-418) 5 2 13836 CUP – BEARING, NON-CHROME (ORIG EQUIP FOR 40-418-3) 2 13836CP CUP – BEARING, CHROME (ORIG EQUIP FOR 40-418) 2 13889 CONE – BEARING, NON-CHROME (ORIG EQUIP FOR 40-418-3) 2 13889CP CONE– BEARING, CHROME (ORIG EQUIP FOR 40-418) 6 1 473232 SEAL, INBOARD 7 1 472439 SEAL, OUTBOARD (#50 HOLE REQUIRED BEFORE INST.) 8 2 155-14300 RING - SNAP 9 6 AN5-35A BOLT 6 NAS1149F0563P WASHER 6 MS21042-5 NUT 10 1 166-20000 NAMEPLATE – “WARNING” (NOT SHOWN) 1 166-19700 NAMEPLATE (NOT SHOWN) 11 1 AA1E6* TIRE 1 XA1AD* TUBE 12 1 30A04000-103 ASSEMBLY, BRAKE CALIPER, LH, 3000/3450 1 30A04000-102 ASSEMBLY, BRAKE CALIPER, RH, 3000/3450 1 6A04561-001 FILM, BRAKE CALIPER SURFACE PROTECTOR 13 2 062-10700 PISTON 1 MS28775-222 0-RING 14 1 063-01100 PLATE - PRESSURE 15 2 066-10500 LINING - BRAKE 16 1 064-01500 PLATE – BACK 17 1 075-20700 PLATE - TORQUE 4 AN5-6A BOLT (NOT SHOWN) 8 NAS1149F0532P WASHER (NOT SHOWN) 4 MS21044N5 NUT (NOT SHOWN) 18 1 30A04523-002 BUSHING 19 2 069-03100 BOLT - ANCHOR 2 NAS1149F0463P WASHER 2 MS21044N4 NUT 20 1 081-00200 SEAT - BLEEDER 1 MS28775-012 O-RING 1 079-00300 SCREW – BLEEDER 1 183-00100 CAP – BLEEDER PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 90 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 21 4 MS21250H04026 BOLT 4 MS20002C4 WASHER A/R MS20995-C32 LOCKWIRE 22 1 104-04700 FITTING 1 MS28775-012 O-RING 23 4 105-00200 RIVET * Any alternate tire (tube type) which is TSO-approved, matches the listed tire's dimensions, and meets its speed/ load/ply ratings may be used. Equivalent tubes may also be used. P/N 1002174 Page 91 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR SHOCK ASSEMBLY PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 92 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 2 1004286-04 ASS’Y. SHOCK, HEAVY DUTY, MAIN GEAR (185) 1 1 1001103 BUSHING ASS’Y., SHOCK STRUT 2 1 1002090 BUSHING ASS’Y., DUAL, SHOCK STRUT 3 1 1004267 TUBE, STRUT, MAIN 4 1 1004268 SHOCK SPACER, MAIN 5 1 1004269 STRUT END CAP, MAIN 6 1 1005765 ASS’Y., UPPER SHOCK STRUT, MAIN 7 1 1005766 ASS’Y., LOWER SHOCK STRUT, MAIN 8 1 AN6-52A BOLT 9 1 MS21044N6 NUT 10 1 NAS1149F0663P WASHER P/N 1002174 Page 93 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR WITHOUT WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34315A & 34316A AND LATER
   
                 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 94 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1005746 ASS’Y., PIVOT, RH, MAIN GEAR W/O WHEEL - 1 1005747 ASS’Y., PIVOT, LH, MAIN GEAR W/O WHEEL 1 1 1004274 LINK ARM, OUTBRD, RT FLOAT 1 1005370 LINK ARM, OUTBRD, LT FLOAT 2 1 1004275 LINK ARM, INBRD, RT FLOAT 1 1005369 LINK ARM, INBRD, LT FLOAT 3 1 1005744 ASSY, CENTER LINK, RH, MAIN GEAR 1 1005745 ASSY, CENTER LINK, LH, MAIN GEAR 4 3 AN6-11A BOLT 5 2 AN6-14A BOLT 6 3 AN6-15A BOLT 7 2 AN6-16A BOLT 8 7 MS21044N6 NUT 9 3 MS21083N6 NUT 10 20 NAS1149D0663J WASHER P/N 1002174 Page 95 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR WITHOUT WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34313A & 34314A AND PRIOR PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 96 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1005746 ASS’Y., PIVOT, RH, MAIN GEAR W/O WHEEL - 1 1005747 ASS’Y., PIVOT, LH, MAIN GEAR W/O WHEEL 1 1 1004274 LINK ARM, OUTBRD, RT FLOAT 1 1005370 LINK ARM, OUTBRD, LT FLOAT 2 1 1004275 LINK ARM, INBRD, RT FLOAT 1 1005369 LINK ARM, INBRD, LT FLOAT 3 1 1005387 GREASE COVER, MAIN GEAR, 3000 3450 4 1 1005744 ASSY, CENTER LINK, RH, MAIN GEAR 1 1005745 ASSY, CENTER LINK, LH, MAIN GEAR 5 3 AN6-11A BOLT 6 2 AN6-14A BOLT 7 3 AN6-15A BOLT 8 2 AN6-16A BOLT 9 3 MS20426-4 RIVET-FLAT HEAD 10 7 MS21044N6 NUT 11 3 MS21083N6 NUT 12 20 NAS1149D0663J WASHER P/N 1002174 Page 97 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR WITH WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34315A & 34316A AND LATER
                               PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 98 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1004288 ASS’Y., PIVOT, RH, MAIN GEAR - 1 1005377 ASS’Y., PIVOT, LH, MAIN GEAR 1 1 075-20700 TORQUE PLATE 2 1 1004281 LOCKING HUB, MAIN 3 1 1004283 AXLE, MAIN GEAR 4 1 1005374 BOLT - 7/16-20 UNF-3A, 8.20 GRIP 5 1 1005378 HUB, AXLE 6 1 1005389 HUB, AXLE 7 1 1005746 ASS’Y., PIVOT, RH, MAIN GEAR W/O WHEEL 1 1005747 ASS’Y., PIVOT, LH, MAIN GEAR W/O WHEEL 8 1 1005844 BRAKE ASSEMBLY COMPLETE, RH 1 1005775 BRAKE ASSEMBLY COMPLETE, LH 4 AN4H21A BOLT 2 MS21083N4 NUT 6 NAS1149F0463P WASHER 2 069-03100 BOLT - ANCHOR 9 1 1005855 ASSY, BRACKET, ANTI ROTATION, MAIN, 3000 3450 10 1 1095K41 COMMON GREASEZERK 11 3 30A04523-002 BUSHING, TORQUE PLATE 12 1 6A04093-002 AXLE SPACER, MAIN WHEEL 13 1 8A04000-031 MAIN WHEEL ASSEMBLY 14 1 AN310-7 NUT, HEX, CASTLE, 7/16-20 UNF 15 4 AN5-11A BOLT 16 2 AN5-13A BOLT 17 1 MS21025-24 NUT, AXLE 18 6 MS21044N5 NUT 19 1 MS24665-302 COTTER PIN 20 2 NAS1149F0532P WASHER 21 12 NAS1149F0563P WASHER 22 2 NAS1149F0732P WASHER P/N 1002174 Page 99 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR WITH WHEEL PIVOT ASSEMBLY FOR FLOAT SERIAL NUMBERS 34313A & 34314A AND PRIOR PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 100 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1004288 ASS’Y., PIVOT, RH, MAIN GEAR - 1 1005377 ASS’Y., PIVOT, LH, MAIN GEAR 1 1 075-20700 TORQUE PLATE 2 1 1004281 LOCKING HUB, MAIN 3 1 1004283 AXLE, MAIN GEAR 4 1 1005374 BOLT - 7/16-20 UNF-3A, 8.20 GRIP 5 1 1005378 HUB, AXLE 6 1 1005389 HUB, AXLE 7 1 1005746 ASS’Y., PIVOT, RH, MAIN GEAR W/O WHEEL 1 1005747 ASS’Y., PIVOT, LH, MAIN GEAR W/O WHEEL 8 1 1005844 BRAKE ASSEMBLY COMPLETE, RH 1 1005775 BRAKE ASSEMBLY COMPLETE, LH 8a 4 AN4H21A BOLT 8b 2 MS21083N4 NUT 8c 6 NAS1149F0463P WASHER 8d 2 069-03100 BOLT - ANCHOR 9 1 1005855 ASSY, BRACKET, ANTI ROTATION, MAIN, 3000 3450 10 1 1095K41 COMMON GREASEZERK 11 3 30A04523-002 BUSHING, TORQUE PLATE 12 1 6A04093-002 AXLE SPACER, MAIN WHEEL 13 1 8A04000-031 MAIN WHEEL ASSEMBLY 14 1 AN310-7 NUT, HEX, CASTLE, 7/16-20 UNF 15 4 AN5-11A BOLT 16 2 AN5-13A BOLT 17 1 MS21025-24 NUT, AXLE 18 6 MS21044N5 NUT 19 1 MS24665-302 COTTER PIN 20 2 NAS1149F0532P WASHER 21 12 NAS1149F0563P WASHER 22 2 NAS1149F0732P WASHER P/N 1002174 Page 101 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR ASSEMBLY PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 102 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1004291-04 ASS'Y, MAIN GEAR, RIGHT, HEAVY DUTY, 3450 - 1 1004251-04 ASS'Y, MAIN GEAR, LEFT, 3450 1 2 1004263 RETAINER, MAIN 2 1 1004286-04 ASS'Y., SHOCK, LIGHT DUTY, MAIN GEAR 6 1 1004287 ASS'Y., PIVOT PIN, SHOCK, UPPER, MAIN 7 1 1004288 ASSY, PIVOT, RH, MAIN GEAR 1 1005377 ASS’Y., PIVOT, LH, MAIN GEAR 8 1 1004289 ASS'Y., UPPER SHOCK LINK 9 1 1004882 ASS’Y., SIDE SUPPORT, LH, MAIN 10 1 1005375 ASS’Y., SIDE SUPPORT, RH, MAIN 11 1 1005733 ASSEMBLY, SHAFT, UPPER SHOCK, MAIN GEAR 12 2 1005734 ASSEMBLY, BOLT, MODIFIED, LOWER PIVOT 13 1 1005735 ASSEMBLY, SUPPORT, PIVOT, LOWER, MAIN GEAR 14 1 1005750 ASS'Y., PIVOT PIN, SHOCK, LOWER, MAIN 15 4 1095K41 COMMON GREASEZERK 16 1 1095K42 COMMON GREASEZERK 17 1 59915K273 BALL JOINT ROD END, 5/16" BALL ID, MALE 18 1 59915K483 BALL JOINT END, 5/16" BALL ID, FEMALE 19 4 93781A035 SEALING WASHER 20 2 93783A046 SEALING WASHER 21 1 AN316-4R NUT 22 2 AN320-14 NUT, HEX, SLOTTED, 7/8-14 UNF 23 6 AN4-7A BOLT 24 1 AN-16A BOLT 25 2 MS21044N10 NUT 26 6 MS21044N4 NUT 27 1 MS21083N6 NUT 28 2 MS24665-304 COTTER PIN 20 12 NAS1149F0463P WASHER 30 2 NAS1149F0632P WASHER 31 2 NAS561P6-12 COTTER PIN 32 1 NAS1149F0663P WASHER THICK P/N 1002174 Page 103 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 MAIN GEAR ROTARY ACTUATOR ASSEMBLY PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 104 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1005271 ASSMEBLY, ROTARY ACUTATOR, MAIN GEAR 1 2 1005272 CYLINDER, ROTARY ACTUATOR, MAIN GEAR 2 2 1005273 CYLINDER CAP, ROTARY ACTUATOR, MAIN GEAR 3 1 1005274 HOUSING TOP, ROTARY ACTUATOR, MAIN GEAR 4 1 1005275 HOUSING, ROTARY ACTUATOR, MAIN GEAR 5 2 1005276 PISTON, ROTARY ACTUATOR, MAIN GEAR 6 1 1005277 SHAFT, ROTARY ACTUATER, MAIN GEAR 7 1 1005280 ARM, GEAR ACTUATOR, 3000 3450 8 1 1005282 SPUR GEAR, PDIA 2.00 BORE .625 MODIFIED 9 2 1005283 BOLT, 5/16-24 UNF X 1.5, W/ 1/8 DRIVE, SST, MODIFIED 10 1 1005284 RACK, MOD, ROTARY ACTUATOR, MAIN GEAR 11 4 1005285 SEAL, U-CUP, .156 C/S, .937 ID, 1.250 OD, 90 DURO, 12 1 1095K41 GREASE ZERK 13 2 5018T168 5018T168 14 1 98870A330 KEY, 3/16 X 3/16 X .75 LG, 1018 STL, .002 OVER SIZED 15 1 98870A570 KEY, 3/16 X 3/16 X .75 LG, 1018 STL, .002 OVER SIZED 16 2 AN316C5R NUT 17 1 AN4-10A BOLT 18 2 AN526C832R8 SCREW, MACHINE, TRUSS HEAD 19 2 MS20822-4D ELBOW 20 2 MS28775-024 "O" RING 21 2 MS28775-121 "O" RING 22 2 NAS1149C0563R WASHER 23 2 NAS1149CN832R WASHER 24 1 NAS1149D0416J WASHER 25 2 MS16625-4125 RETAINING RING, INTERNAL 26 2 MS16625-4131 RETAINING RING, INTERNAL 27 2 10FDU10 FLANGED BUSHING 28 1 1095K11 GREASE ZERK 29 1 MS21044N4 NUT P/N 1002174 Page 105 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 9 STRUTS, WIRES, STEPS, AND SPREADER BARS CONTENTS STRUTS, WIRES, AND SPREADER BARS ......................................................................................................106 STEPS INSTALLATION.......................................................................................................................................109 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 106 P/N 1002174 STRUTS, WIRES, AND SPREADER BARS P/N 1002174 Page 107 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A02000-218 FWD RH STRUT 2 1 34A02000-197 FWD LH STRUT 3 2 30A02000-235 DRAG WIRE - FRONT 1 AN665-80LAS * TERMINAL L.H. 1 AN316-C6L CHECK NUT 1 AN665-80RAS * TERMINAL R.H. 1 AN316-C6R CHECK NUT 2 MS20392-5C21 CLEVIS PIN 2 MS24665-301 COTTER PIN 4 2 34A02000-198 DIAG. STRUT 5 2 34A02000-199 REAR STRUT 6 2 34A02000-209 DRAG WIRE - REAR 1 AN665-115LS * TERMINAL L.H. 1 AN316-C7L CHECK NUT 1 AN665-115RS * TERMINAL R.H. 1 AN316-C7R CHECK NUT 2 MS20392-6C25 CLEVIS PIN 2 MS24665-370 COTTER PIN 7 2 30A03000-031 SPREADER BAR 8 2 21A04000-080 BRAKE LINE 2 63-1906000-3 STRAIGHT FITTING 9 1 34A02204-013 FITTING – FWD LOWER LH 1 34A02204-012 FITTING – FWD LOWER RH 10 8 AN7-22A BOLT (SERIAL #’S 34079, 34080, 34093 AND UP) 8 AN7-20A BOLT (ALL OTHER SERIAL #’S) 16 NAS1149F0763P WASHER 8 MS20365-720A NUT 11 2 AN6-43A BOLT – DRAG WIRE LUG 4 NAS1149F0663P WASHER 2 MS21044N6 NUT 12 12 AN6-30A BOLT – SPREADER BAR ATTACH 24 NAS1149D0663J WASHER 12 MS21044N6 NUT 13 2 1004807 LUG – DRAG WIRE 14 1 30A03319-001 TUBE – SPR. FLOAT LH 1 30A03319-002 TUBE – SPR. FLOAT RH 15 2 AN7-33A BOLT – LOWER STRUT ATTACH 4 NAS1149F0763P WASHER 2 MS21044N7 NUT 16 2 AN8-20A BOLT 4 NAS1149F0863P WASHER PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 108 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 2 MS21044N8 NUT 17 2 34A02229-005 FITTING – FWD UPPER STRUT 18 2 4A02078-001 FITTING – FWD FUSELAGE 19 2 AN7-43A BOLT – DRAG WIRE LUG ATTACH 2 NAS1149F0563P WASHER 2 MS21044N5 NUT 20 2 34A02496-003 LUG – DRAG WIRE ATTACH 21 2 4A02000-073 ASS’Y – FITTING – DRAGWIRE LH 2 4A02000-074 ASS’Y – FITTING – DRAGWIRE RH 22 2 AN8-22A BOLT (SERIAL #’S 34079, 34080, 34093 AND UP) - FWD 2 AN8-20A BOLT (ALL OTHER SERIAL #’S) 2 NAS1149F0863P WASHER 23 2 AN8-22A BOLT (SERIAL #’S 34079, 34080, 34093 AND UP) - AFT 2 AN8-20A BOLT (ALL OTHER SERIAL #’S) 4 NAS1149F0863P WASHER 2 MS21044N8 NUT 24 1 34A02062-013 TONGUE – LH 1 34A02062-012 TONGUE – RH 25 2 AN7-30A BOLT – REAR STRUT ATTACH 4 NAS1149F0763P WASHER 2 MS21044N7 NUT 26 2 34A02204-014 FITTING – AFT LOWER STRUT 27 4 AN6-41A BOLT – ITEM 28 ATTACH 8 NAS1149F0663P WASHER 4 MS21044N6 NUT 28 2 30A02219-003 FITTING – FLOAT DECK 29 1 3A02005-030 GEAR OPENING COVER RT 1 3A02005-031 GEAR OPENING COVER LT "S" DENOTES STAINLESS STEEL P/N 1002174 Page 109 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 STEPS INSTALLATION PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 110 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A02369-048 STEP – R.H. 2 1 4A02369-009 STEP – L.H. 3 1 34A02000-212 ASS’Y STRUT 1 34A02334-045 STRUT 1 8A02053-007 FITTING – UPPER 1 8A02053-005 FITTING - LOWER A/R MS24694S145 SCREW – FITTING ATTACH 4 1 AN44-5A EYE BOLT – UPPER ATTACH 2 NAS1149F0563P WASHER 1 MS21044N5 NUT 5 1 8A02273-007 FITTING - SLIDE 1 AN44-5A EYE BOLT (FLOAT) 1 NAS1149F0532P WASHER 1 MS21044N5 NUT 1 AN4-12A BOLT – SLIDE TO EYE BOLT 1 NAS1149F0463P WASHER 1 MS21083N4 NUT 6 4 AN3-21A BOLT – ATTACH F & R STRUT 2 AN3-24A BOLT – ATTACH CENTER STRUT 1 AN3-24A BOLT – ATTACH 14 NAS1149F0332P WASHER 7 MS21044N3 BOLT 7 4 6A02273-006 SPACER (BETWEEN STEP & STRUT – NOT SHOWN) 8 6 BPF HOLE PLUGS (WHITE) P/N 1002174 Page 111 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 10 HYDRAULIC SYSTEM CONTENTS HYDRAULIC PUMP (FWD NOSE WHEEL WELL) INSTALLATION POST SERVICE LETTER 241 ............ 112 HYDRAULIC PUMP (FWD NOSE WHEEL WELL) ASSEMBLY POST SERVICE LETTER 241 ................... 114 ELECTRONIC SIDE PLATE (FWD NOSE WHEEL WELL) ASSEMBLY POST SERVICE LETTER 241 ...... 117 HYDRAULIC SYSTEM INSTALLATION POST SERVICE LETTER 221 .........................................................120 HYDRAULIC SYSTEM INSTALLATION PRE SERVICE LETTER 221 ...........................................................122 HYDRAULIC PUMP ASSEMBLY POST SERVICE LETTER 221 ....................................................................124 HYDRAULIC PUMP ASSEMBLY SUPPORT PLATE 24V POST SERVICE LETTER 221 .............................127 HYDRAULIC PUMP ASSEMBLY PRE SERVICE LETTER 221 .......................................................................129 HYDRAULIC PUMP FIREWALL (SOLOY ONLY) INSTALLATION POST SERVICE LETTER 242...............132 HYDRAULIC PUMP FIREWALL (SOLOY ONLY) ASSEMBLY POST SERVICE LETTER 242 .....................134 ASSEMBLY SUPPORT PLATE FIREWALL (SOLOY ONLY) POST SERVICE LETTER 242 ........................137 HYDRAULIC PUMP OVERVIEW POST SERVICE LETTER 221 ....................................................................139 HYDRAULIC PUMP OVERVIEW PRE SERVICE LETTER 221 ......................................................................141 HYDRAULIC PUMP SCHEMATIC ......................................................................................................................143 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 112 P/N 1002174 HYDRAULIC PUMP (FWD NOSE WHEEL WELL) INSTALLATION POST SERVICE LETTER 241 P/N 1002174 Page 113 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1006582 BRACKET, HYDRAULIC POWER PACK, C-206, FWD MOUNT 2 1 1006583 DOUBLER, HYDRAULIC POWER PACK, C-206, FWD MOUNT 3 (12V) 1 1011938 ASSEMBLY, HYDRAULIC POWER PACK, 12V 3 (24V) 1 1011939 ASSEMBLY, HYDRAULIC POWER PACK, 24V 4 4 AN3-4A BOLT, 10-32, 0.125 GRIP, UNDRILLED, STEEL 5 2 AN4-4A BOLT, 1/4-28, 0.0625 GRIP, UNDRILLED, STEEL 6 2 AN4-5A BOLT, 1/4-28, 0.1875 GRIP, UNDRILLED, STEEL 7 2 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 8 2 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 9 2 MS21047L3 NUT PLATE, FIXED, STEEL, PLAIN, 10-32 10 2 MS21047L4 NUT PLATE, FIXED, STEEL, PLAIN, 1/4-28 11 6 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 12 6 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 114 P/N 1002174 HYDRAULIC PUMP (FWD NOSE WHEEL WELL) ASSEMBLY POST SERVICE LETTER 241 P/N 1002174 Page 115 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 116 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011938 ASSEMBLY, HYDRAULIC POWER PACK, 12V - 1 1011939 ASSEMBLY, HYDRAULIC POWER PACK, 24V 1 4 02-09-2118 PIN, CRIMP MALE, 1/8" DIA 2 2 03-09-2022 CONNECTOR PLUG, FEMALE 3 1 1009428 ASSEMBLY, SENSOR, FLUID LEVEL 4 2 1011062 ASSEMBLY, PLUG, PRESSURE SWITCH PORT 5 (12V) 1 1011932 ASSEMBLY, ELECTRONIC SIDE PLATE, 12V 5 (24V) 1 1011933 ASSEMBLY, ELECTROINC SIDE PLATE, 24V 6 1 1011935 ASSEMBLY, HYDRAULIC RESERVOIR 6.1 1 1EJT7 BREATHER VENT 6.2 1 1011848 PLACARD, OIL LEVEL 6.3 1 AN816-4D NIPPLE, FLARED TUBE AND PIPE THREAD 6.4 1 LSP151-04-01 LIQUID LEVEL SIGHT PLUG 7 1 1011936 SPACER 8 1 1011937 MOUNTING BRACKET, HYDRAULIC PUMP 9 2 20PS001EB 700W500W PRESSURE SWITCH 10 1 4061T199 SQUARE PROFILE, O-RING, 3.5" I.D., .094 THK 11 1 93786A200 PRESSURE-SEALING WASHER, M12 12 2 AN3-16A BOLT, 10-32, 1.375 GRIP, UNDRILLED, STEEL 13 2 AN3-17A BOLT, 10-32, 1.5 GRIP, UNDRILLED, STEEL 14 2 AN3-5A BOLT, 10-32, 0.25 GRIP, UNDRILLED, STEEL 15 1 AN914-1D ELBOW,90°, INTERNAL EXTERNAL PIPE 16 2 AN919-3D FITTING, REDUCER 17 2 MS16997-99 SCREW, CAP, SOCKET HEAD 18 6 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 19 2 MS25036-157 RING TERMINAL, 1/4 STUD, 10-12 AWG, YELLOW 20 2 MS28775-013 "O" RING, HYDRAULIC 21 2 MS35338-46 WASHER, SPLIT 22 4 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 23 8 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 24 2 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL 25 (12V) 1 YBZS- C0.63W1T100K/ UVZOT2 HYDRAULIC POWER PACK, 12VDC, .64 PUMP 25 (24V) 1 YBZS- C0.63W2T100K/ UVZOT2 HYDRAULIC POWER PACK, 24 VDC, .64 PUMP P/N 1002174 Page 117 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ELECTRONIC SIDE PLATE (FWD NOSE WHEEL WELL) ASSEMBLY POST SERVICE LETTER 241 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 118 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011932 ASSEMBLY, ELECTRONIC SIDE PLATE, 12V - 1 1011933 ASSEMBLY, ELECTRONIC SIDE PLATE, 24V 1 4 02-09-1104 CRIMP TERMINAL, FEMALE, 20-14 2 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 3 14 1-901-355-917 TERMINAL 4 1 1004949 CABLE, DIODE ADAPTER 5 (12V) 1 1005042 TIMER RELAY HARNESS 5 (24V) 1 1005043 TIMER RELAY HARNESS 6 1 1009143-01 PLACARD, K1 INDICATOR 7 1 1009143-02 PLACARD, K2 INDICATOR 8 1 1009143-03 PLACARD, K3 INDICATOR 9 1 1009144-01 PLACARD, CR INDICATOR 10 1 1009144-02 PLACARD, AC INDICATOR 11 1 1011798 ASSEMBLY, CAPACITOR 12 1 1011931 ELECTRONIC SIDE PLATE, HYDRAULIC PUMP 13 3 1N4004 DIODE, 2-1/2" 14 2 206062-3 CLAMP, CABLE, CPC SIZE 11 15 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 16 1 206430-2 CPC FREE HANG, 4 PIN, FEMALE 17 6 FT 22759-16-12-9 WIRE, 12 AWG, WHITE 18 10 FT 22759-16-20-9 WIRE, 20 AWG, WHITE 19 1 3453LF2A FUSE HOLDER 20 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 21 3 66103-4 CRIMP TERMINAL, MALE, 24-20 AWG 22 3 66105-4 CRIMP TERMINAL, FEMALE, 24-20 AWG 23 1 73F-250-32-NL CONNECTOR, FEMALE, 10-12 AWG, FULLY INSULATED 24 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG, FULLY INSULATED 25 1 AGC-1 FUSE, 250V, (S2565-1) 26 2 AN3-3A BOLT, 10-32, 0.0625 GRIP, UNDRILLED, STEEL 27 1 AN3-5A BOLT, 10-32, 0.25 GRIP, UNDRILLED, STEEL 28 2 AN526C632R8 SCREW, MACHINE, TRUSS HEAD 29 3 BR05-FW SOCKET, 5 PRONG, PLASTIC 30 2 MS21044N06 NUT, LOCKING, REGULAR HEIGHT, 6-32 UNC 31 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 32 1 MS21919WDG10 CLAMP, LOOP, CUSHIONED, 5/8 TUBE OD 33 12 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 34 1 MS35489-14 GROMMET, RUBBER, 5/16 HOLE, 11/16 GROOVE DIA, .062 PANEL 35 5 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL P/N 1002174 Page 119 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 36 1 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 37 (12V) 3 V23234- A0001-X032 RELAY, 12V, 5 PRONG 37 (24V) 3 0-332-209-211 RELAY, 24V, 5 PRONG PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 120 P/N 1002174 HYDRAULIC SYSTEM INSTALLATION POST SERVICE LETTER 221 P/N 1002174 Page 121 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1001382 CHANNEL, FWD, HYD PUMP 2 1 1001383 CHANNEL, AFT, HYD PUMP 3 1 1004685 SPACER, CHANNEL, FWD 4 1 1004686 SPACER, CHANNEL, AFT 5 (12V) 1 1011439 ASSEMBLY, HYDRAULIC POWER PACK, 12V 5 (24V) 1 1011548 ASSEMBLY, HDYRAULIC POWER PACK, 24V 6 LT. 1 1001432 ASSEMBLY, PUMP MOUNT, L/H SIDE 6 RT. 1 34A09000-244 ASSEMBLY, PUMP MOUNT, R/H SIDE 7 2 AN3-3A BOLT, 10-32, 0.0625 GRIP, UNDRILLED, STEEL 8 2 AN4-5A BOLT, 1/4-28, 0.1875 GRIP, UNDRILLED, STEEL 9 2 NAS1149D0416J WASHER, 0.265 ID, 0.016 THK, ALUMINUM 10 2 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 122 P/N 1002174 HYDRAULIC SYSTEM INSTALLATION PRE SERVICE LETTER 221 P/N 1002174 Page 123 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 34A09000-245 ASS’Y – HYDRAULIC PUMP (12V) 1 34A09000-277 ASS’Y – HYDRAULIC PUMP (24V) 2 2 34A09000-256 ASS’Y – HYDRAULIC HOSE 3 1 34A09000-244 ASS’Y – PUMP MOUNT 4 2 AN4-4A BOLT – ATTACH - LOWER 2 NAS1149D0416J WASHER 5 2 AN3-3A BOLT – ATTACH - UPPER 2 NAS1149FO332P WASHER 6 2 8A09000-048 ASS’Y – HOSE ACCUMULATOR 7 2 AN806-4D PLUG – HOSE END 8 1 34A09000-261 ASS’Y – HAND PUMP (COMPLETE WITH RETRACT HANDLE) 9 1 638203 HAND PUMP ONLY 10 1 21A09396-001 HANDLE PUMP 11 1 21A12000-052 ASS’Y – HANDLE SELECTOR 1 21A12414-005 HANDLE 1 21A12214-004 PIVOT 1 1/8 X 1” ROLL PIN 1 12A3-7379-1 PLACARD – HANDLE R. SIDE 12 2 MS16997-77 CAP – SCREW 2 MS35333-40 WASHER 2 NAS1149F0563J WASHER 13 1 AN815-4D UNION 3 MS28775-012 O-RING 1 AN916-6D O-RING 1 AN814-4D O-RING PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 124 P/N 1002174 HYDRAULIC PUMP ASSEMBLY POST SERVICE LETTER 221 P/N 1002174 Page 125 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 126 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011439 ASSEMBLY, HYDRAULIC POWER PACK, 12V - 1 1011548 ASSEMBLY, HYDRAULIC POWER PACK, 24V 1 4 02-09-2118 CRIMP TERMINAL, MALE, 22-18 2 2 03-09-2022 CONNECTOR PLUG, FEMALE 3 1 1009428 ASSEMBLY, SENSOR, FLUID LEVEL 4 2 1011062 ASSEMBLY, PLUG, PRESSURE SWITCH PORT 5 1 1011447 ANGLE, MOUNT, LOWER 6 (12V) 1 1011449 ASSEMBLY, SUPPORT PLATE, HYDRAULIC PUMP, 12V 6 (24V) 1 1011547 ASSEMBLY, SUPPORT PLATE, HYDRAULIC PUMP, 24V 7 1 1011542 SUPPORT, HYDRAULIC RESERVOIR, SIDE MOUNT 8 2 20PS001EB 700W500W PRESSURE SWITCH 9 1 6A3-2199 PLACARD, OIL LEVEL 10 1 93783A032 SEALING WASHER 11 1 93786A200 PRESSURE-SEALING WASHER, M12 12 2 AN3-3A BOLT, 10-32, 0.0625 GRIP, UNDRILLED, STEEL 13 1 AN833-4D FITTING, HYDRAULIC, 90° ELBOW 14 2 AN919-3D FITTING, REDUCER 15 1 AN924-4D JAM NUT 16 2 MS16997-96 SOCKET HEAD CAP SCREW 17 2 MS25036-157 RING TERMINAL, 1/4 STUD, 10-12 AWG, YELLOW 18 2 MS28775-013 "O" RING, HYDRAULIC 19 2 MS35333-39 STAR WASHER 20 2 MS35338-46 WASHER, SPLIT 21 1 NJAM12X1.0CLZ NUT, JAM, M12X1.0, ZINC 22 (12V) 1 YBZS- C0.63W1T100K/ UVZOT2 HYDRAULIC PUMP, 12 VDC 22 (24V) 1 YBZS- C0.63W2T100K/ UVZOT2 HYDRAULIC PUMP, 24 VDC P/N 1002174 Page 127 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 HYDRAULIC PUMP ASSEMBLY SUPPORT PLATE 24V POST SERVICE LETTER 221 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 128 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011449 ASSEMBLY, SUPPORT PLATE, HYDRAULIC PUMP, 12V - 1 1011547 ASSEMBLY, SUPPORT PLATE, HYDRAULIC PUMP, 24V 1 4 02-09-1104 CRIMP TERMINAL, FEMALE, 20-14 2 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 3 14 1-901-355-917 TERMINAL 4 1 1004949 CABLE, DIODE ADAPTER 5 (12V) 1 1005042 TIMER RELAY HARNESS, 12V 5 (24V) 1 1005043 TIMER RELAY HARNESS, 24V 6 1 1009143-01 PLACARD, K1 INDICATOR 7 1 1009143-02 PLACARD, K2 INDICATOR 8 1 1009143-03 PLACARD, K3 INDICATOR 9 1 1009144-01 PLACARD, CR INDICATOR 10 1 1009144-02 PLACARD, AC INDICATOR 11 1 1011448 TOP PLATE, HYDRAULIC PUMP 12 1 1011798 ASSEMBLY, CAPACITOR 13 3 1N4004 DIODE, 2-1/2" 14 1 206062-3 CLAMP, CABLE, CPC SIZE 11 15 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 16 1 22759-16-12-9 WIRE, 12 AWG, WHITE 17 1 22759-16-20-9 WIRE, 20 AWG, WHITE 18 1 3453LF2A FUSE HOLDER 19 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 20 3 66103-4 CRIMP TERMINAL, MALE, 24-20 AWG 21 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG, FULLY INSULATED 22 1 AGC-1 FUSE, 250V, (S2565-1) 23 2 AN3-3A BOLT, 10-32, 0.0625 GRIP, UNDRILLED, STEEL 24 1 AN3-5A BOLT, 10-32, 0.25 GRIP, UNDRILLED, STEEL 25 2 AN526C632R8 SCREW, MACHINE, TRUSS HEAD 26 3 BR05-FW SOCKET, 5 PRONG, PLASTIC 27 2 MS21044N06 NUT, LOCKING, REGULAR HEIGHT, 6-32 UNC 28 3 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 29 1 MS21919WDG10 CLAMP, LOOP, CUSHIONED, 5/8 TUBE OD 30 12 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 31 1 MS35489-14 GROMMET, RUBBER, 5/16 HOLE, 11/16 GROOVE DIA, .062 PANEL 32 3 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 33 3 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 34 (12V) 3 V23234- A0001-X032 RELAY, 12V, 5 PRONG 34 (24V) 3 0-332-209-211 RELAY, 24V, 5 PRONG P/N 1002174 Page 129 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 HYDRAULIC PUMP ASSEMBLY PRE SERVICE LETTER 221 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 130 P/N 1002174 P/N 1002174 Page 131 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 3 0-332-209-137 RELAY, 12V, 5 PRONG 3 0-332-209-211 RELAY, 24V, 5 PRONG 2 4 02-09-1104 PIN, CRIMP FEMALE, 1/8" DIA 3 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 4 14 1-901-355-917 TERMINAL 5 1 1004949 CABLE, DIODE ADAPTOR 6 1 1005042 TIMER RELAY HARNESS, 12V 1 1005043 TIMER RELAY HARNESS, 24V 7 3 1N4004 DIODE, 2-1/2" 8 2 206062-3 CLAMP, CABLE, CPC SIZE 11 9 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 10 1 206430-2 CPC FREE HANG, 4 PIN, FEMALE 11 1 21A09000-215 ASSEMBLY, HYDRAULIC PUMP, 12V 1 21A09000-282 ASSEMBLY, HYDRAULIC PUMP, 24V 12 1 21A09010-013 PLATE, SUPPORT, HYDRAULIC PUMP 13 1 21A09352-030 ANGLE, MOUNTING, HYD. PUMP 14 .5 FT 22759-16-12-9 WIRE, 12 AWG, WHITE 15 10.2 FT 22759-16-20-9 WIRE, 20 AWG, WHITE 16 1 73F-250-32NL CONNECTOR, FEMALE, 10-12 AWG 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG 17 1 3453LF2A FUSE HOLDER 18 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 19 3 66103-4 PIN, CRIMP SOCKET, 24-20G 20 3 66105-4 CRIMP SOCKET, FEMALE 21 1 AGC-1 FUSE, 250V, (S2565-1) 22 3 AN3-3A BOLT 23 2 AN526-632R8 SCREW, MACHINE, TRUSS HEAD 24 3 BR05FW SOCKET, 5 PRONG, PLASTIC 25 1.5 FT HS105-3/16-0 HEAT SHRINK, TUBING, BLACK 26 2 MS16997-96 SOCKET HEAD CAP SCREW 27 2 MS21044N06 NUT 28 3 MS21044N3 NUT 29 2 MS35338-46 WASHER, SPLIT 30 1 MS35489-14 GROMMET, RUBBER 31 4 NAS1149D0363J WASHER 32 6 NAS1149F0332P WASHER 33 12 R-3 RING CONNECTOR PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 132 P/N 1002174 HYDRAULIC PUMP FIREWALL (SOLOY ONLY) INSTALLATION POST SERVICE LETTER 242 P/N 1002174 Page 133 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 1009226 ANGLE, MOUNT, FIREWALL, HYDRAULIC PUMP 2 1 1011945 ASSEMBLY, HYDRAULIC POWER PACK, 24V 3 2 AKS4-1032 THREADED INSERT, 0.020-0.130 GRIP, 10-32 UNF 4 6 AN3-4A BOLT, 10-32, 0.125 GRIP, UNDRILLED, STEEL 5 2 AN4-5A BOLT, 1/4-28, 0.1875 GRIP, UNDRILLED, STEEL 6 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 7 2 MS21044N4 NUT, LOCKING, REGULAR HEIGHT, 1/4-28 UNF 8 2 MS35333-39 STAR WASHER 9 4 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 10 4 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 134 P/N 1002174 HYDRAULIC PUMP FIREWALL (SOLOY ONLY) ASSEMBLY POST SERVICE LETTER 242 P/N 1002174 Page 135 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 136 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011945 ASSEMBLY, HYDRAULIC POWER PACK 24V 1 4 02-09-2118 CRIMP TERMINAL, MALE, 22-18 2 2 03-09-2022 CONNECTOR PLUG, FEMALE 3 1 1009428 ASSEMBLY, SENSOR, FLUID LEVEL 4 2 1011062 ASSEMBLY, PLUG, PRESSURE SWITCH PORT 5 1 1011847 ASSEMBLY, HYDRAULIC RESERVOIR 6 1 1011943 ASSEMBLY, SUPPORT PLATE, HYDRAULIC PUMP 7 1 1011944 ANGLE, MOUNT, HYDRAULIC PUMP 8 2 20PS001EB 700W500W PRESSURE SWITCH 9 1 93786A200 PRESSURE-SEALING WASHER, M12 10 4 AN3-16A BOLT, 10-32, 1.375 GRIP, UNDRILLED, STEEL 11 1 AN914-1D ELBOW,90°, INTERNAL EXTERNAL PIPE 12 2 AN919-3D FITTING, REDUCER 13 2 MS16997-96 SOCKET HEAD CAP SCREW 14 8 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 15 2 MS25036-157 RING TERMINAL, 1/4 STUD, 10-12 AWG, YELLOW 16 2 MS28775-013 "O" RING, HYDRAULIC 17 2 MS35338-46 WASHER, SPLIT 18 2 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL 19 6 NAS1149F0363P WASHER, 0.203 ID, 0.063 THK, STEEL 20 2 NAS1149F0432P WASHER, 0.265 ID, 0.032 THK, STEEL 21 2 NAS1149F0632P WASHER, 0.39 ID, 0.032 THK, STEEL 22 1 YBZS- C0.63W2T100K/ UVZOT2 HYDRAULIC POWER PACK, 24VDC P/N 1002174 Page 137 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ASSEMBLY SUPPORT PLATE FIREWALL (SOLOY ONLY) POST SERVICE LETTER 242 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 138 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION - 1 1011943 ASSEMBLY, SUPPORT PLATE, HYDRAULIC POWER PACK 1 3 0-332-209-211 RELAY, 24V, 5 PRONG 2 4 02-09-1104 CRIMP TERMINAL, FEMALE, 20-14 3 2 03-09-1022 CONNECTOR PLUG, MALE, 2 CONN. 4 14 1-901-355-917 TERMINAL 5 1 1004949 CABLE, DIODE ADAPTER 6 1 1005043 TIMER RELAY HARNESS 7 1 1009143-01 PLACARD, K1 INDICATOR 8 1 1009143-02 PLACARD, K2 INDICATOR 9 1 1009143-03 PLACARD, K3 INDICATOR 10 1 1009144-01 PLACARD, CR INDICATOR 11 1 1009144-02 PLACARD, AC INDICATOR 12 1 1011798 ASSEMBLY, CAPACITOR 13 1 1011844 ELECTRONIC SIDE PLATE 14 1 1011940 TOP PLATE, HYDRAULIC PUMP 15 3 1N4004 DIODE, 2-1/2" 16 2 206062-3 CLAMP, CABLE, CPC SIZE 11 17 1 206429-1 PLUG, MALE, CPC SIZE 1, 4 PIN 18 1 206430-2 CPC FREE HANG, 4 PIN, FEMALE 19 6 FT 22759-16-12-9 WIRE, 12 AWG, WHITE 20 10.1 FT 22759-16-20-9 WIRE, 20 AWG, WHITE 21 1 3453LF2A FUSE HOLDER 22 1 6-140 TERMINAL BLOCK, 6 CONNECTOR 23 3 66103-4 CRIMP TERMINAL, MALE, 24-20 AWG 24 3 66105-4 CRIMP TERMINAL, FEMALE, 24-20 AWG 25 1 73F-250-32-NL CONNECTOR, FEMALE, 10-12 AWG, FULLY INSULATED 26 1 73M-250-32-NL CONNECTOR, MALE, 10-12 AWG, FULLY INSULATED 27 1 AGC-1 FUSE, 250V, (S2565-1) 28 4 AN3-3A BOLT, 10-32, 0.0625 GRIP, UNDRILLED, STEEL 29 2 AN526C632R8 SCREW, MACHINE, TRUSS HEAD 30 3 BR05-FW SOCKET, 5 PRONG, PLASTIC 31 2 MS21044N06 NUT, LOCKING, REGULAR HEIGHT, 6-32 UNC 32 4 MS21044N3 NUT, LOCKING, REGULAR HEIGHT, 10-32 UNF 33 1 MS21919WDG10 CLAMP, LOOP, CUSHIONED, 5/8 TUBE OD 34 12 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 35 1 MS35489-14 GROMMET, RUBBER, 5/16 HOLE, 11/16 GROOVE DIA, .062 PANEL 36 1 MS35489-9 GROMMET, RUBBER, 5/16 HOLE, 9/16 GROOVE DIA, .062 PANEL 37 7 NAS1149F0332P WASHER, 0.203 ID, 0.032 THK, STEEL P/N 1002174 Page 139 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 HYDRAULIC PUMP OVERVIEW POST SERVICE LETTER 221 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 140 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 1 1 202-0003 BI-DIRECTIONAL PUMP, 0.64 ML/R 2 1 299-0008 SEAL KIT, BI-DIRECTIONAL GEAR PUMP 3.1 1 610-0010 DC MOTOR, 12V, .8KW 3.2 1 610-0017 DC MOTOR, 24V, .8 KW 4 1 622-0016 RESERVOIR, 1 QT. 5 2 631-0005 PRESSURE RELIEF VALVE 6 2 631-0006 THERMAL RELIEF VALVE 7 2 632-0004 ASSEMBLY, PILOT OPERATED CHECK VALVE 8 1 637-0024 SHUTTLE VALVE 9 1 681-0050 CLAMP, HOSE, 1 LITER PLASTIC RESERVOIR 10 1 682-0019 FILTER, PICKUP TUBE, HYDRAULIC PUMP 11 1 682-0055 SUCTION HEX TUBE 12 1 682-0056 RETURN TUBE 13 1 683-0011 COUPLING, MOTOR TO PUMP 14 2 685-0012 SPRING, SHUTTLE VALVE 15 1 687-0001 SEAL KIT, RESERVIOR O-RING, PILOT OPERATED RELIEF VALVE O-RING, THERMAL AND PRESSURE RELIEF VALVE O-RING (NOT SHOWN) P/N 1002174 Page 141 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 HYDRAULIC PUMP OVERVIEW PRE SERVICE LETTER 221 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 142 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 1 1 21A09000-215 HYDRAULIC PUMP ASS’Y (12V) 1 21A09000-282 HYDRAULIC PUMP ASS’Y (24V) 1 640661 MOTOR (12V) 1 641131 MOTOR (24V) 2 1 634873 BASIC PUMP 3 2 362136 TUBE EXTENSIONS 4 2 410521* FILTER 5 1 410578* SEAL RESERVIOR 6 1 365047 RETURN TUBE 7 1 775260 RESERVIOR – GAUGE ASS’Y 8 1 415067 SEAL THREAD 9 1 409715* SCREW – RESERVIOR ATTACH 10 1 361183* COUPLING – MOTOR TO PUMP 11 1 410512 SEAL – PUMP SHAFT 12 1 405673 “O” RING MOTOR TO BASE 13 3 AN815-4D UNION 14 3 MS28775-012 O RING, HYDRAULIC PACKING 0.364 ID * Reference Wipaire drawing 1011065 for alternate part numbers. P/N 1002174 Page 143 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 HYDRAULIC PUMP SCHEMATIC PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 144 P/N 1002174 ITEM QTY PART NO. PART DESCRIPTION 1 2 34A09000-256 ASS’Y – HYDRAULIC HOSE 2 1 34A09000-257 ASS’Y – HYDRAULIC HOSE 3 2 34A09000-258 ASS’Y – HYDRAULIC HOSE 4 1 21A09000-218 ASS’Y HYDRAULIC HOSE 5 2 AN824-4D “T” FITTING 6 2 AN804-4D “T” FITTING 2 AN924-4D NUT 2 NAS1149F0763P WASHER 7 2 34A09000-259 ASS’Y HYDRAULIC HOSE 8 2 AN833-4D ELBOW 2 AN924-4D NUT 2 NAS1149F0763P WASHER 9 4 21A04000-080 ASS’Y – HYDRAULIC HOSE 10 2 30A09000-272 ASS’Y – HYDRAULIC HOSE 11 2 30A09000-273 ASS’Y – HYDRAULIC HOSE 12 2 30A09000-268 ASS’Y – HYDRAULIC HOSE 13 2 34A09000-274 ASS’Y – HYDRAULIC HOSE 14 2 34A09000-275 ASS’Y – HYDRAULIC HOSE 15 2 30A09000-269 ASS’Y – HYDRAULIC HOSE P/N 1002174 Page 145 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 11 ELECTRICAL CONTENTS ELECTRICAL SCHEMATIC POST SERVICE LETTER 221 .............................................................................146 ELECTRICAL SCHEMATIC PRE SERVICE LETTER 221 ...............................................................................148 GEAR CONTROL (ROUND) ...............................................................................................................................150 GEAR CONTROL (RECTANGLE) ......................................................................................................................152 GEAR CONTROL (RECTANGLE) (G1000 ONLY) .............................................................................................154 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 146 P/N 1002174 ELECTRICAL SCHEMATIC POST SERVICE LETTER 221 P/N 1002174 Page 147 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 4 1005724 GEAR POSITION SWITCH, PROXIMITY, 3 WIRE 2 4 1006668 SOLENOID, 2 WAY, 2 POSITION 3 1 1009426 ASSY, IND. LIGHT, HYD. FLUID LEVEL, 24V 4 1 1009428 ASSY, SENSOR, FLUID LEVEL 5 1 1009430 ASSY, IND. LIGHT, HYD FLUID LEVEL, 12V 6 1 1009433 WIRE HARNESS, HYD. FLUID LEVEL 7 8 21A09005-262 CLIP, GEAR POSITION SWITCH HOLDER 8 1 4A11000-011 WIRE HARNESS, GEAR SELECTOR, FLOATS 9 2 4-140 TERMINAL BLOCK, 4 POSITION 10 4 5801 GEAR POSITION SWITCH, 2 WIRE 11 2 6-140 TERMINAL BLOCK, 6 POSITION 12 1 6A10000-004 HARNESS WIRE, FLOATS LT 13 1 6A10000-005 HARNESS WIRE, FLOATS, RT 14 1 7277-2-5 CIRCUIT BREAKER, 5A 15 1 73F-250-32-NL CONNECTOR, FEMALE, 12-10 AWG 16 1 73M-250-32-NL CONNECTOR, MALE, 12-10 AWG 17 1 MS24523-21 TOGGLE SWITCH 18 8 S1635-1 PIN 19 8 S1636-1 SOCKET 20 8 S1637-1 HOUSING 21 8 S1637-2 HOUSING 22 1 W23-X1A1G-25 CIRCUIT BREAKER, 25 AMP, 24VDC 23 1 W23-X1A1G-40 CIRCUIT BREAKER, 40 AMP, 12VDC PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 148 P/N 1002174 ELECTRICAL SCHEMATIC PRE SERVICE LETTER 221 P/N 1002174 Page 149 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1A 3 0-332-209-211 RELAY 12V 1B 3 0-332-209-137 RELAY 24V 2 3 BR05FW RELAY SOCKET 3 7 1N4004 DIODE 4 1 AGC-1 FUSE 1 AMP 5 1 3453LF2A FUSE HOLDER 6A 1 1005042 ASSEMBLY, TIMER RELAY 12V 6B 2 1005043 ASSEMBLY, TIMER RELAY 24V 7 1 1004949 DIODE CABLE ADAPTOR 8 1 4A11000-014 WIRE HARNESS 9 1 4A11000-012 WIRE HARNESS 10 1 5 AMP CIRCUIT BREAKER 11 1 40 AMP CIRCUIT BREAKER (12V) 1 25 AMP CIRCUIT BREAKER (24V) 12 8 5801 SWITCH – PROXIMITY - MAGNETIC 8 21A09005-262 CLIP – SWITCH HOLDER PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 150 P/N 1002174 GEAR CONTROL (ROUND) P/N 1002174 Page 151 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 21A11000-009 GEAR SELECTOR ASSY. ROUND (12V) - 1 21A11000-019 GEAR SELECTOR ASSY. ROUND (24V) 1 1 8857K44 SWITCH 2 1 A101SYCB TOGGLE SWITCH, SPDT, ON-ON 3 9 515-0012 SOCKET 4 1 507-3914-1431-600 INDICATOR LAMP, 14V, RED 1 507-3918-1431-600 INDICATOR LAMP, 28V, RED 5 4 507-3914-1432-600 INICATOR LAMP, 14V, GREEN 4 507-3918-1432-600 INICATOR LAMP, 28V, GREEN 6 4 507-3914-1434-600 INDICATOR LAMP, 14V, BLUE 4 507-3918-1434-600 INDICATOR LAMP, 28V, BLUE 7 1 21A11179-001 BLOCK, GEAR CONTROL 8 1 4A11000-008 HARNESS ASSEMBLY, GEAR SELECTOR 9 1 21A11259-003 GEAR SWITCH KNOB 10 1 RH-5-35 RESISTOR, 14V, DALE RH5 5W 1 RH-5-180 RESISTOR, 28V, DALE RH5 5W 11 3 AN526-632R8 SCREW, TRUSS HEAD, 6-32 12 1 10B3-6202 PLACARD, ROUND2100 GEAR SELECTOR 13 3 R-3 RING CONNECTOR, #6, 20 AWG, RED 14 5 PLT1M-M CABLE TIE 15 16 IN HIXR-3/16 SHRINK WRAP, 3/16, WHITE 16 3 IN HS105-1/2-0 HEAT SHRINK TUBING 17 6 IN 22759-16-20-9 WIRE, 20AWG, WHITE PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 152 P/N 1002174 GEAR CONTROL (RECTANGLE) P/N 1002174 Page 153 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 21A11000-010 ASSEMBLY, INDICATOR, GEAR CONTROL, SQUARE, 12V - 1 21A11000-018 ASSEMBLY, INDICATOR, GEAR CONTROL, SQUARE, 24V 1 1 10B3-6277 PLACARD, GEAR CONTROL SQUARE 2 1 21A11179-002 BLOCK GEAR CONTROL SQUARE 3 1 21A11259-003 GEAR SWITCH KNOB 4 1 4A11000-008 WIRING HARNESS ASSY. SELECTOR 5 1 5073914-1431-600 LAMP LIGHT, RED 14V 1 5073918-1431-600 LAMP, LIGHT, RED, 28V 6 4 5073914-1432-600 LAMP LIGHT, GREEN 14V 4 5073918-1432-600 LAMP, LIGHT, GREEN, 28V 7 4 5073914-1434-600 LAMP LIGHT, BLUE, 14V 4 5073918-1434-600 LAMP, LIGHT, BLUE, 28V 8 9 515-0012 SOCKET 9 1 8857K44 SWITCH 10 1 A101SYCB TOGGLE SWITCH 11 3 AN526C632R8 SCREW, TRUSS HEAD MACHINE, 6-32 THREAD, 1/2" LENGTH 12 12" HS105-3/32-0 HEAT SHRINK, TUBING - BLACK 13 8 PLT1M-M CABLE TIE, NYLON, WHITE, 4" (SMALL) 14 3 R-3 TERMINAL, RING #6 STUD, 16-22 AWG, RED 15 1 RH-5-35 RESISTOR, 14V, DALE RH5 5W 1 RH-5-180 RESISTOR, 28V, DALE RH5 5W PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 154 P/N 1002174 GEAR CONTROL (RECTANGLE) (G1000 ONLY) P/N 1002174 Page 155 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION - 1 1001431 ASSEMBLY, INDICATOR, GEAR CONTROL, G1000 1 1 1001172 BLOCK, GEAR CONTROL, GLASS PANEL 2 1 1001173 PLACARD, GEAR CONTROL, GLASS PANEL 3 1 21A11259-003 GEAR SWITCH KNOB 4 1 4A11000-008 ASSEMBLY, WIRE HARNESS 5 1 507-3918-1431-600 INDICATOR LAMP, 28V, RED 6 4 507-3918-1432-600 INDICATOR LAMP, 28V, GRN 7 4 507-3918-1434-600 INDICATOR LAMP, 28V, BLU 8 9 515-0012 SOCKET, GEAR SELECTOR LIGHTS 9 1 8857K44 SWITCH, GEAR SELECTOR, 2100/7000 10 1 A101SYCB TOGGLE SWITCH, SPDT, ON 11 3 AN526-632R6 SCREW, MACHINE, TRUSS HEAD 12 3 MS25036-102 RING TERMINAL, #6 STUD, 16-22 AWG, RED 13 1 RH005180R0FE02 RESISTOR, 28V PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 156 P/N 1002174 THIS PAGE INTENTIONALLY LEFT BLANK P/N 1002174 Page 157 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 SECTION 12 VENTRAL FIN CONTENTS VENTRAL FIN INSTALLATION ..........................................................................................................................158 PARTS MANUAL 3450 FLOATS ON CESSNA 206 Revision P Page 158 P/N 1002174 VENTRAL FIN INSTALLATION P/N 1002174 Page 159 Revision P PARTS MANUAL 3450 FLOATS ON CESSNA 206 ITEM QTY PART NO. PART DESCRIPTION 1 1 4A12000-048 ASS’Y VENTRAL FIN 2 A/R