Airworthiness Directives for Cessna 150 Aerobat

Full document text

Continental Motors Engine Component Information Sheet Printed: 11/09/2015 Serial:1031571 Spec:0200A48B New/Rebuilt: (NEW) Customer Name: AIR POWER, INC Shipping Address: 4900 SOUTH COLLINS Component CAMSHAFT CRANKSHAFT Serial Number 279495 N15IA050 CRANKCASE S15IA013 CONNROD AE15FA094 CONNROD AE15FA112 CONNROD AE15FA078 CONNROD AE15FA115 L MAGNETO D15JA277 R MAGNETO D15JA278 CARBURETOR MNB11309 STARTER 2CC-381505 ALTERNATOR H-P101325 CYLINDER-1 AC15EA684 CYLINDER 2 AC15HA836 CYLINDER - 3 AC15HA824 CYLINDER - 4 AC15HA827 Assembled: 11/05/2015 Shipped: / / . Packed: 11/09/2015 Back Inspection Stamp CM! 19 the information provided herein is subject to verification by the user. al Motors, Inc. makes no representation or warranty concerning the accuracy or pleteness of the information and assumes no responsibility with respect thereto. and Engine: continental Model No: 0-200-A48B les, Date: 5-17-23 Serial No: 1031571 Inspections Accomplished 100 Hr. Engine Insp. Maintenance accomplished 1. Tach: 1540.3 Wichita Falls, TX 76305 Total Time: 133.1 Compression #1 72/80, #2 76/80, #3 73/80, #4 76/80. 2. Clean and re-gap spark plugs 3. Check mag timing. 4. Replace intake filter. P/N BA-4108 5. Leak check heat muff. No discrepancies noted. 6. Profile propeller as needed. 7. Ground run and leak checks performed and found satisfactory. I certify that this engine has been inspected in accordance with a 100hr engine inspection and is approved for return to service at this time Signature & Rating A3682081 Date 5-17-23 AERO MAINTENANCE INC. N101MJ Engine Wichita Falls, TX 76305 Date: 7-3-24 Tach: 1541.6 Engine: continental Model No: 0-200-A48B Total Time: 134.4 Inspections Accomplished Serial No: 1031571 100 Hr. Engine Insp. Maintenance accomplished 1. Compression #1 78/80, #2 75/80, #3 78/80, #4 79/80. 2. Drained oil and cleaned oil screen. Service oil with XC20W-50. 3. Clean and re-gap spark plugs 4. Check mag timing. 5. Replace intake filter. P/N BA-4108 6. Leak check heat muff. No discrepancies noted. 7. Profile propeller as needed. 8. Ground run and leak checks performed and found satisfactory. I certify that this engine has been inspected in accordance with a 100hr engine inspection and is approved for return to service at this time. Signature & Rating AP3682081 Date 7-3-24 YEAR: RECORDING TACH TIME DATE TODAY'S FLIGHT 181 TOTAL TIME IN SERVICE Description of Inspections, Tests, Repairs and Alterations Entries must be endorsed with Name, Rating and Certificate Number of Technician or Repair Facility. (See back pages for other specific entries.) Date: 7-3-24 Tach: 1541.6 AERO MAINTENANCE INC. N101MJ Airframe Wichita Falls, TX 76305 Type: Cessna Model No: A150M Serial No: A1500528 TT: 1541.6 Inspection accomplished Annual inspection Maintenance accomplished 1. FAR 91.207 para. (d) ELT annual inspection and test complied with and found satisfactory. 2. Ops check lights and heats. 3. Leak check exhaust to cabin air heat exchanger. 4. Inspect and clean main fuel filter. Leak check filter assembly. 5. Charge and service aircraft battery. 6. Replaced induction air filter with new BA-4108.. Continue > Total Time Date Hours Min Time Since Last Overhaul Engine Service and Maintenance Record Record maintenance actions including engine part removal and Hours Min installation and compliance with inspections, Airworthiness Directives, AERO MAINTENANCE INC. N101MJ Engine Wichita Falls, TX 76305 Inspections Accomplished Date: 3-2-21 Serial No: 1031571 100 Hr. Engine Insp. Maintenance accomplished 1. Compression #1 68/80, #2 66/80, #3 64/80, #4 72/80. Tach: 1527.0 Engine: continental Model No: 0-200-A48B Total Time: 119.8 2. Clean and re-gap spark plugs 3. Check mag timing. 4. Profile propeller as required. 5. Replace intake filter. P/N BA-4108 6. Leak check heat muff. No discrepancies noted. 7. Drain oil and service with XC20W50. Clean oil screen. 8. Ground run and leak checks performed and found satisfactory. I certify that this engine has been inspected in accordance with a 100hr engine inspection and is approved for return to at this time. Signature & Rating Stan Noodell At 3364617 Date 3-2-21 AERO MAINTENANCE INC. N101MJ Engine Wichita Falls, TX 76305 Date: 3-31-22 Tach: 1533.5 Engine: continental Model No: 0-200-A48B Total Time: 126.3 Inspections Accomplished Serial No: 1031571 100 Hr. Engine Insp. Maintenance accomplished 1. Compression #1 72/80, #2 72/80, #3 74/80, #4 70/80. 2. Clean and re-gap spark plugs 3. Check mag timing. 4. Profile propeller as required. 5. Replace intake filter. P/N BA-4108 6. Leak check heat muff. No discrepancies noted. 7. Ground run and leak checks performed and found satisfactory. I certify that this engine has been inspected in accordance with a 100hr engine inspection and is approved for return to service at this time, Signature & Rating fund AP3682081 Date 3-21-22 N101MJ TACH: 1532.5 Ezell Avionics-220 PR 1501-B - Breckenridge, TX 76424-254 559 2972 - CRS#: ZZ6R885B CESSNA, A150M, S/N: A1500528 March 22, 2022 Removed KX-155 Nav/Com P/N 069-1024-00 - S/N: 28616, KI-208 Converter Indicator P/N 066-3056-00 - S/N: 15158, TDR-950 Transponder P/N 622-2092-001 - S/N: 16115 and associated mounts, connectors and wiring. Installed GNC-355 GPS/Com P/N 011-04956-00 - S/N: 5YR005717, GA-35 GPS Antenna P/N 013-00235-00- S/N: 210255, KI-209 Indicator P/N 066-3056-01 - S/N: 24801, GTX-327 Transponder P/N 011-00490-00 - S/N: 83717240. GNC355 installed with reference to Garmin STC SA02636SE. Weight and balance data revised and equipment list updated to reflect these changes. ATC Transponder has been tested with Aeroflex IFR6000 transponder test set and found to comply IAW Part 43 Appendix F as required by FAR 91.413. With respect to the work performed, this aircraft is approved for return to service. Details of work performed are on file with Ezell Avionics under work order: WO 2021-AV 2620. David Sorbello Repair Station ZZ6R885B FAA FORM 8130-3 SYSTEM TRACKING REF. NO. 291023